2003 CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO DEFECTIVE IGNITION SWITCH. *SMD THE CONSUMER STATED A YEAR AGO, WHILE DRIVING, THE ENGINE SUDDENLY STOPPED RUNNING. FOLLOWING THE DEMISE OF THE ENGINE, THE VEHICLE ENTERED INTO A REDUCED POWER MODE. HE WAS ABLE TO RE-START THE VEHICLE, AND SLOWLY DROVE TO A LOCAL DEALERSH…
Read full complaint
2003 CHEVROLET CORVETTE. CONSUMER WRITES IN REGARDS TO DEFECTIVE IGNITION SWITCH. *SMD THE CONSUMER STATED A YEAR AGO, WHILE DRIVING, THE ENGINE SUDDENLY STOPPED RUNNING. FOLLOWING THE DEMISE OF THE ENGINE, THE VEHICLE ENTERED INTO A REDUCED POWER MODE. HE WAS ABLE TO RE-START THE VEHICLE, AND SLOWLY DROVE TO A LOCAL DEALERSHIP. THE DEALER DETERMINED THE ROOT CAUSE AS A FAULTY IGNITION SWITCH. *JB
NHTSA ODI #10598219
35,000 miles · May 24, 2012
Air BagsElectrical SystemSteeringCrash
TL* THE CONTACT OWNS A 2003 CHEVROLET CORVETTE. THE CONTACT WAS DRIVING 25 MPH WHEN THE POWER STEERING FAILED AS THE CONTACT ATTEMPTED A SLIGHT TURN. THE CONTACT CRASHED INTO THE SIDE OF THE ROAD AND THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WA…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET CORVETTE. THE CONTACT WAS DRIVING 25 MPH WHEN THE POWER STEERING FAILED AS THE CONTACT ATTEMPTED A SLIGHT TURN. THE CONTACT CRASHED INTO THE SIDE OF THE ROAD AND THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 35,000. THE CONSUMER STATED WHILE DRIVING, THE STEERING COMPLETELY SHUT DOWN. SINCE HE HAD NO STEERING, SO HE APPLIED THE BRAKES, AND SOON AFTER, THE VEHICLE WENT FROM 25 MPH TO 60 MPH. HE HIT A CURB AND THE VEHICLE WENT AIRBORNE. THE VEHICLE SPUN AROUND AND LANDED ON THE OPPOSITE SIDE OF THE DITCH. THREE TIRE WERE BLOWN OUT, THE FRAME WAS BENT AND THE AIR BAGS NEVER DEPLOYED. THE CONSUMER STATED HE NEVER RECEIVED A RECALL REGARDING A PROBLEM WITH THE STEERING. ALSO, THE BATTERY WOULD GO DEAD, IF THE VEHICLE WAS STARTED ON A REGULAR BASIS. THE CONSUMER STATED THE VEHICLE HAD TO BE JUMP STARTED ON FIVE OCCASIONS. UPDATED 07/19/12
NHTSA ODI #10459589
34,547 miles · Apr 26, 2007
Electrical SystemLatches/locks/linkages
TL*THE CONTACT OWNS A 2003 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE HORN FAILED. THE DEALER DIAGNOSED THE AIR BAG AS HAVING A SHORT WHICH CAUSED THE HORN TO STOP OPERATING. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN. *AK THE CONSUMER PROVIDED THE INVOICE FOR REPAIRS. THE …
Read full complaint
TL*THE CONTACT OWNS A 2003 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE HORN FAILED. THE DEALER DIAGNOSED THE AIR BAG AS HAVING A SHORT WHICH CAUSED THE HORN TO STOP OPERATING. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN. *AK THE CONSUMER PROVIDED THE INVOICE FOR REPAIRS. THE CONSUMER STATED THERE HAD TO BE AN ACCIDENT IN ORDER FOR THE AIR BAGS TO DEPLOY. THE DEALER STATED THE DRIVERS DOOR WILL NOT LOCK, REPAIR WAS PERFORMED. UPDATED 06/08/07 *TR
NHTSA ODI #10188911
13,500 miles · Aug 3, 2006
Electrical System
DT*: THE CONTACT STATED THE DASHBOARD LIGHTS DARKENED WHILE DRIVING 60 MPH UNDER NORMAL ROAD CONDITIONS. THE VEHICLE WAS TAKEN TO THE DEALER SIX TIMES, HOWEVER THE PROBLEM PERSISTED. THE MANUFACTURER WAS CONTACTED AND DETERMINED THAT THE VEHICLE NEEDED TO BE TAKEN BACK TO THE DEALER.
NHTSA ODI #10164398
8,400 miles · Apr 11, 2006
Electrical System
MY 2003 Z06 CORVETTE BATTERY KEEPS DRAINING. I'M ON MY 3RD BATTERY AND THE SERVICE DEPT DOES NOT KNOW WHAT'S DRAINING THE BATTERY. THE PROBLEM IS FIXED WHEN I RECEIVE A NEW BATTERY, BUT IN 6 MONTHS THAT BATTERY BEGINS TO FAIL. IF THE CAR IS NOT STARTED WITHIN 3 DAYS THE BATTERY TENDS TO DIE. THE DEALERSHIP TELLS ME TO START …
Read full complaint
MY 2003 Z06 CORVETTE BATTERY KEEPS DRAINING. I'M ON MY 3RD BATTERY AND THE SERVICE DEPT DOES NOT KNOW WHAT'S DRAINING THE BATTERY. THE PROBLEM IS FIXED WHEN I RECEIVE A NEW BATTERY, BUT IN 6 MONTHS THAT BATTERY BEGINS TO FAIL. IF THE CAR IS NOT STARTED WITHIN 3 DAYS THE BATTERY TENDS TO DIE. THE DEALERSHIP TELLS ME TO START THE CAR EVERY DAY, BUT I HAVE 2 OTHER CARS (GMC'S) THAT DON'T NEED TO BE STARTED EVERY DAY. THIS CAR IS ONLY 3 YEARS OLD AND I DON'T THINK IT NEEDS TO BE STARTED EVERY DAY. I BELIEVE SOMETHING IS WRONG WITH THE CAR AND THE SERVICE DEPT, CAN'T FIGURE IT OUT. *JB
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
2003 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration