Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
4425–50K
3650–75K
1175–100K
4100–150K
3150K+
130 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Steering. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
157 reports
28,500 miles · Mar 20, 2006
Steering
DT*: THE CONTACT STATED THE STEERING COLUMN INTERMITTENTLY LOCKED WHILE ATTEMPTING SHARP TURNS AT SPEEDS OF 35 MPH OR LESS. THERE IS A NHTSA RECALL, #04V060000 CONCERNING THE STEERING. ALTHOUGH THE RECALL REPAIR WAS PERFORMED ACCORDINGLY, AFTERWARDS THE PROBLEM RETURNED. THE VEHICLE WAS TOWED TO THE DEALER AND IS AWAITING IN…
Read full complaint
DT*: THE CONTACT STATED THE STEERING COLUMN INTERMITTENTLY LOCKED WHILE ATTEMPTING SHARP TURNS AT SPEEDS OF 35 MPH OR LESS. THERE IS A NHTSA RECALL, #04V060000 CONCERNING THE STEERING. ALTHOUGH THE RECALL REPAIR WAS PERFORMED ACCORDINGLY, AFTERWARDS THE PROBLEM RETURNED. THE VEHICLE WAS TOWED TO THE DEALER AND IS AWAITING INSPECTION OF THE ONGOING STEERING PROBLEM. *AK
NHTSA ODI #10153219
Mileage unknown · Mar 18, 2006
Wheels
I AM ORIGINAL OWNER OF 2002 CORVETTE COUPE. IT CAME WITH OPTIONAL THIN SPOKE POLISHED ALUMINUM WHEELS. MY DRIVER REAR HAS A STRESS CRACK WHERE THE FORK MEETS THE RIM. MANY OF MY FELLOW CORVETTE FRIENDS HAVE SAME ISSUE. MY CAR HAS 30400 MILES ON THE ODO. SEE FORUM THREAD HERE: HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T…
Read full complaint
I AM ORIGINAL OWNER OF 2002 CORVETTE COUPE. IT CAME WITH OPTIONAL THIN SPOKE POLISHED ALUMINUM WHEELS. MY DRIVER REAR HAS A STRESS CRACK WHERE THE FORK MEETS THE RIM. MANY OF MY FELLOW CORVETTE FRIENDS HAVE SAME ISSUE. MY CAR HAS 30400 MILES ON THE ODO. SEE FORUM THREAD HERE: HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T=1300651&PAGE=1&PP=20 THANK YOU FOR CHECKING INTO THIS.*JB
NHTSA ODI #10153087
55,000 miles · Mar 7, 2006
Wheels
STOCK GM HIGH POLISHED RIGHT REAR CORVETTE C5 18" X 9.5" WHEEL CRACKED. TIRE WENT FLAT, DISCOVERED CRACKS AT 2 SPOKES, LEAKING AIR THROUGH CRACKS REPLACED WHEEL WITH ATERMARKET. *JB UPDATED 05/01/06
NHTSA ODI #10152161
55,700 miles · Feb 16, 2006
Fuel System, OtherWheels
DT*: THE CONTACT STATED CRACKS WERE DISCOVERED IN THE SPOKES ON BOTH REAR WHEELS OF THE VEHICLE. ALTHOUGH THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION, NO REPAIRS WERE MADE. UPDATED 3/9/2006 - THE WHEELS WERE INSPECTED BY FACTORY REPRESENTATIVE WHO AUTHORIZED THE DEALER TO REPLACE BOTH REAR WHEELS AT NO COST TO TH…
Read full complaint
DT*: THE CONTACT STATED CRACKS WERE DISCOVERED IN THE SPOKES ON BOTH REAR WHEELS OF THE VEHICLE. ALTHOUGH THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION, NO REPAIRS WERE MADE. UPDATED 3/9/2006 - THE WHEELS WERE INSPECTED BY FACTORY REPRESENTATIVE WHO AUTHORIZED THE DEALER TO REPLACE BOTH REAR WHEELS AT NO COST TO THE CONSUMER. THE ELECTRIC FUEL PUMP WAS ALSO REPLACED. *NM
NHTSA ODI #10150413
30,000 miles · Feb 15, 2006
Wheels
PROBLEM: O.E.M. REAR WHEELS ON MY 2002 CHEVROLET CORVETTE COUPE HAVE DEVELOPED HAIRLINE CRACKS. I RECENTLY NOTICED HAIRLINE CRACKS EACH ABOUT AN INCH LONG ON THE OUTER SPOKES NEAR THE EDGES ON BOTH REAR WHEELS. THE WHEELS ARE STOCK GM HIGH POLISHED 5 SPOKE WHEELS THAT HAVE NOT BEEN ALTERED. THIS VEHICLE'S SUSPENSION, WHEELS OR …
Read full complaint
PROBLEM: O.E.M. REAR WHEELS ON MY 2002 CHEVROLET CORVETTE COUPE HAVE DEVELOPED HAIRLINE CRACKS. I RECENTLY NOTICED HAIRLINE CRACKS EACH ABOUT AN INCH LONG ON THE OUTER SPOKES NEAR THE EDGES ON BOTH REAR WHEELS. THE WHEELS ARE STOCK GM HIGH POLISHED 5 SPOKE WHEELS THAT HAVE NOT BEEN ALTERED. THIS VEHICLE'S SUSPENSION, WHEELS OR BRAKES HAVE NOT BEEN MODIFIED. THE TWO FRONT 17 INCH O.E.M. WHEELS HAVE NOT DEVELOPED ANY CRACKS. NOTHING HAS BEEN DONE TO CORRECT THE FAILURE. ORIGINAL PARTS ARE AVAILABLE BUT HAVE NOT YET BEEN REPLACED. *JB
NHTSA ODI #10150335
45,500 miles · Feb 1, 2006
Wheels
I HAVE A 2002 CORVETTE I RECENTLY PURCHASED FROM A FRIEND OF MINE. WHILE CLEANING THE CAR RECENTLY I NOTICED A SMALL CRACK AT THE BASE OF ONE OF THE SPOKES ON MY LEFT REAR RIM. THIS CRACK HAD NOT BEEN THERE PREVIOUSLY. WORRIED ABOUT THE STRUCTURE I WENT TO A LOCAL TIRE SHOP TO ORDER A REPLACEMENT. WHILE THERE I NOTICED A 200…
Read full complaint
I HAVE A 2002 CORVETTE I RECENTLY PURCHASED FROM A FRIEND OF MINE. WHILE CLEANING THE CAR RECENTLY I NOTICED A SMALL CRACK AT THE BASE OF ONE OF THE SPOKES ON MY LEFT REAR RIM. THIS CRACK HAD NOT BEEN THERE PREVIOUSLY. WORRIED ABOUT THE STRUCTURE I WENT TO A LOCAL TIRE SHOP TO ORDER A REPLACEMENT. WHILE THERE I NOTICED A 2000 CORVETTE ON THE RACK FOR TIRES. I WENT OVER TO LOOK AT IT'S RIMS AND SAW THAT THE LEFT REAR HAD 3 SPOKES CRACKED. I ORDERED A NEW AFTERMARKET RIM, MINE ARE GM AND WENT HOME. WHEN I GOT HOME I RECHECKED THE VEHICLE AND NOW SAW THAT THE LEFT HAD MORE FRACTURES COMING FROM THE ORIGINAL CRACK, AND NOW THE RIGHT REAR ALSO HAD A CRACK AT THE BASE OF THE SPOKE. THE CAR HAS 46,000 MILES. THE WHEELS HAVE NEVER BEEN CURBED AND ONLY ONE NEW SET OF TIRES HAS BEEN PUT ON AT A REPUTABLE TIRE COMPANY. I CHECKED ON A CORVETTE WEB SITE AND GOT MANY RESPONSES OF ADDITIONAL CORVETTES WITH THE SAME PROBLEM. *JB
NHTSA ODI #10149178
Mileage unknown · Dec 5, 2005
Electrical System
NUMEROUS PROBLEMS WITH COMPUTER READOUT MESSAGE: SERVICE ABS, SERVICE ACTIVE HANDLING AND SERVICE TRACTION CONTROL. DEALER HAS FOUND THAT COMMUNICATION IS BEING LOST BETWEEN THE STEERING SENSOR AND COMPUTER. NO REASON WHY. POSSIBLE LOOSE PIN CONNECTION? ALL OTHER EQUIPMENT CHECKS OUT OK. HAD LOSS OF CONTROL AND LOSS OF BRAKIN…
Read full complaint
NUMEROUS PROBLEMS WITH COMPUTER READOUT MESSAGE: SERVICE ABS, SERVICE ACTIVE HANDLING AND SERVICE TRACTION CONTROL. DEALER HAS FOUND THAT COMMUNICATION IS BEING LOST BETWEEN THE STEERING SENSOR AND COMPUTER. NO REASON WHY. POSSIBLE LOOSE PIN CONNECTION? ALL OTHER EQUIPMENT CHECKS OUT OK. HAD LOSS OF CONTROL AND LOSS OF BRAKING TEMPORARILY. *JB
NHTSA ODI #10144518
31,600 miles · Nov 18, 2005
Wheels
I HAVE A 2002 CHEVROLET CORVETTE IT HAS 31,000 MILES ON IT I WAS GOING TO HAVE TIRES PUT ON IT FOR THE FIRST TIME AND NOTICED BOTH REAR WHEELS ARE CRACKED I DID NOT HAVE THE TIRES REPLACED YET BUT THE DEALER CENTER CHEVROLET GOT AHOLD OF THE GM REP AND THEY WILL ONLY BUY ONE RIM IF I BUY THE OTHER RIM .THIS CAR IS MY WIFE'S AND …
Read full complaint
I HAVE A 2002 CHEVROLET CORVETTE IT HAS 31,000 MILES ON IT I WAS GOING TO HAVE TIRES PUT ON IT FOR THE FIRST TIME AND NOTICED BOTH REAR WHEELS ARE CRACKED I DID NOT HAVE THE TIRES REPLACED YET BUT THE DEALER CENTER CHEVROLET GOT AHOLD OF THE GM REP AND THEY WILL ONLY BUY ONE RIM IF I BUY THE OTHER RIM .THIS CAR IS MY WIFE'S AND HAS BEEN VERY WELL TAKEN CARE OF , DOES THIS SOUND LIKE THERE MAY BE A PROBLEM WITH THESE WHEELS ( IT IS BOTH BACK WHEELS)?? PLEASE LET ME KNOW IF I NEED TO REPORT THIS ELSEWHERE. *JB
NHTSA ODI #10143134
21,910 miles · Oct 6, 2005
Steering
DT: NO PROBLEMS LEADING UP TO THE FAILURE, AND THEN WHILE BACKING CAR OUT OF GARAGE, STEERING COLUMN LOCKED, REMOVED KEY, WAITED 10 SECONDS AS SHOWN ON DASHBOARD AND THE VEHICLE STARTED. WENT FOR A FEW FEET AND THE FUEL LINE SHUT CAR OFF. HAD TO PUSH CAR INTO THE GARAGE AND THEN HAD IT TOWED TO THE DEALER THE NEXT DAY. THEY …
Read full complaint
DT: NO PROBLEMS LEADING UP TO THE FAILURE, AND THEN WHILE BACKING CAR OUT OF GARAGE, STEERING COLUMN LOCKED, REMOVED KEY, WAITED 10 SECONDS AS SHOWN ON DASHBOARD AND THE VEHICLE STARTED. WENT FOR A FEW FEET AND THE FUEL LINE SHUT CAR OFF. HAD TO PUSH CAR INTO THE GARAGE AND THEN HAD IT TOWED TO THE DEALER THE NEXT DAY. THEY REPLACED THE LOCKING PARTS, RACK/ SECTOR/ LOCK BOLT THAT LOCKED THE STEERING COLUMN, WHICH HAD BEEN RECALLED 04V06000 IN 2004. THE DEALER WANTED TO CHARGE A DEDUCTIBLE BECAUSE THE RECALL HAD ALREADY BEEN DONE, BUT GM AUTHORIZED THE REPAIR WITH NO DEDUCTIBLE CHARGED. *AK *NM
NHTSA ODI #10134904
43,727 miles · Sep 17, 2005
Steering
STEERING WHEEL INTERLOCK PROBLEMS (AGAIN AFTER RECALL). *JB
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
2002 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration