IllustrationTHE CHROMED WHEELS ON MY 2002 CHEVROLET CORVETTE ARE CRACKED. ALL 4 WHEES ARE CRACKED AND ON ONE WHEEL 3 OUT OF FIVE SPOKES ARE CRACKED ALMOST COMPLETELY THROUGH. *AK
2002 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 2002 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
320–25K
4425–50K
3650–75K
1175–100K
4100–150K
3150K+
130 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 59 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports0 fire reports1 injury reports
What owners actually said
157 reportsCRACKS IN THE CASTED SPOKES OF MY 2002 CHEVROLET CORVETTE
STEERING COLUMN LOCK-UP ON 2 CORVETTES ( 97 & 02 ) LOCKED UP 3 TIMES ON THE 2002 CORVETTE & 1 TIME ON 1997. BOTH MIRRORS BROKE ON 97 & HAD TO BE REPLACED. FUEL GAUGE WOULD GO FROM HALF TO EMPTY & LATER BACK TO HALF ON 2002 & PASSENGER DOOR WOULD NOT UNLOCK W / REMOTE & SOMETIMES PASSENGER WINDOW WOULD NOT GO DOWN WHEN CONVERTI…
Read full complaint
STEERING COLUMN LOCK-UP ON 2 CORVETTES ( 97 & 02 ) LOCKED UP 3 TIMES ON THE 2002 CORVETTE & 1 TIME ON 1997. BOTH MIRRORS BROKE ON 97 & HAD TO BE REPLACED. FUEL GAUGE WOULD GO FROM HALF TO EMPTY & LATER BACK TO HALF ON 2002 & PASSENGER DOOR WOULD NOT UNLOCK W / REMOTE & SOMETIMES PASSENGER WINDOW WOULD NOT GO DOWN WHEN CONVERTIBLE WAS PUT DOWN . READ-OUT ON HEATER / TEMP. GAUGE & RADIO DISPLAY WOULD FADE IN AND OUT. *NM
THE GAS GAUGE ON MY 2002 CORVETTE GOES TO EMPTY WHILE DRIVING, THE DIC FLASHES " LOW FUEL" & THE CHECK GAUGES LIGHT COMES ON. JUST AS SUDDENLY, IT WILL START WORKING AGAIN SEVERAL DAYS LATER. I PAID A LOCAL DEALER ~$700 TO REPLACE THE FUEL TANK SENSOR UNIT ABOUT A YEAR AGO. SINCE THEN THE PROBLEM HAS RECURRED SEVERAL TIMES. NOW …
Read full complaint
THE GAS GAUGE ON MY 2002 CORVETTE GOES TO EMPTY WHILE DRIVING, THE DIC FLASHES " LOW FUEL" & THE CHECK GAUGES LIGHT COMES ON. JUST AS SUDDENLY, IT WILL START WORKING AGAIN SEVERAL DAYS LATER. I PAID A LOCAL DEALER ~$700 TO REPLACE THE FUEL TANK SENSOR UNIT ABOUT A YEAR AGO. SINCE THEN THE PROBLEM HAS RECURRED SEVERAL TIMES. NOW THE DEALERSHIP IS TELLING ME TO ADD A GAS ADDITIVE, ONLY AVAILABLE FROM CHEVROLET AT $25 A TREATMENT, TO FIX THE PROBLEM. AFTER ADDING A BOTTLE OF THE GAS TREATMENT, MY GAS GAUGE WENT TO EMPTY & STAYED THERE FOR 3 DAYS. I UNDERSTAND NHTSA INVESTIGATED A SIMILAR PROBLEM FOR THE 2000 MALIBU (EA02028), BUT NO RECALL WAS ORDERED. SURFING THE WEB, THIS LOOKS LIKE A COMMON PROBLEM ON CHEVY AUTOS & TRUCKS. HAVE CONTACTED CHEVY OWNER ASSISTANCE WHO CONTACTED THE LOCAL DEALER & PARROTED THEIR "OLD" GASOLINE EXPLANATION FOR FOULING THE SENSOR. WHY DO YOU USE A SENSOR THAT IS NOT COMPATIBLE WITH THE FUEL AVAILABLE TO YOUR CUSTOMERS? I ONLY USE FUEL FROM BRAND NAME SUPPLIERS. THIS IS CLEARLY A DEFECT IN THE GAS SENSOR & NEEDS TO BE TREATED AS SUCH BY CHEVROLET. *JB
BOTH WINDOW MOTORS BROKEN, AFTER LOOKING UP ONLINE, ITS A VERY COMMON PROBLEM IN ALL CORVETTE UNTIL 2004, I THINK IT SHOULD BE RECALLED. *JB
THE DRIVER SIDE REAR WHEEL ON MY 2002 CORVETTE COUPE HAS A CRACK IN 2 OF THE SPOKES. I TOOK IT IN TO MY CHEVY DEALER (CREST CHEVROLET), THEY TOOK PICTURES AND SUBMITTED A CLAIM TO GM. THE GM REP. HAD THE DEALER TAKE THE TIRE OFF THE WHEEL AND SEE IF THE CRACKS GO THROUGH TO THE INSIDE AND GET THE FACTORY NUMBER OFF THE INSIDE & …
Read full complaint
THE DRIVER SIDE REAR WHEEL ON MY 2002 CORVETTE COUPE HAS A CRACK IN 2 OF THE SPOKES. I TOOK IT IN TO MY CHEVY DEALER (CREST CHEVROLET), THEY TOOK PICTURES AND SUBMITTED A CLAIM TO GM. THE GM REP. HAD THE DEALER TAKE THE TIRE OFF THE WHEEL AND SEE IF THE CRACKS GO THROUGH TO THE INSIDE AND GET THE FACTORY NUMBER OFF THE INSIDE & VERIFY IT WAS A GM WHEEL. THE DEALER SERVICE REP CALLED ME AND SAID GM AGREED TO PAY FOR HALF THE COST OF THE WHEEL. I TOLD THE SERVICE MANAGER THAT GM'S OFFER WAS NOT SATISFACTORY AND I WOULD PROCEED IN FILING FORMAL COMPLAINTS. THEY FACT THAT THESE WHEELS ARE A PROBLEM THAT GM IS AWARE OF HAS BEEN DISCUSSED AND DOCUMENTED ON THE CORVETTEFORUM.COM WEBSITE. HTTP://FORUMS.CORVETTEFORUM.COM/SHOWTHREAD.PHP?T=1461736. *JB
DT*: THE CONTACT STATED RECALL LETTER # 04060000 WAS RECEIVED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE STEERING WHEEL COULD NOT BE REMOVED TO PERFORM THE REQUIRED REPAIR. TO PERFORM THE REMEDY REPAIR, THE DEALER MANAGER DETERMINED THE STEERING WHEEL WOULD HAVE TO BE BROKEN AND THE COST OF NEW STEERING WHEEL WOULD NOT BE …
Read full complaint
DT*: THE CONTACT STATED RECALL LETTER # 04060000 WAS RECEIVED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE STEERING WHEEL COULD NOT BE REMOVED TO PERFORM THE REQUIRED REPAIR. TO PERFORM THE REMEDY REPAIR, THE DEALER MANAGER DETERMINED THE STEERING WHEEL WOULD HAVE TO BE BROKEN AND THE COST OF NEW STEERING WHEEL WOULD NOT BE COVERED UNDER THE RECALL. THE DEALER CONTACTED THE MANUFACTURER WHO AGREED WITH THE DEALER'S DECISION. THE MANUFACTURER WAS PENDING FOR RESOLUTION AND PROVIDED A REFERENCE REF# 1-423750902. THE VEHICLE REMAINED AT THE DEALER FOR MORE THAN A WEEK AND THE CONTACT CONTINUES TO WAIT FOR THE MANUFACTURER'S RESOLUTION. UPDATED 09/15/06. *JB
DRIVING IN A PARKING LOT THE STEERING COLUMN LOCKED UP. THE RECALL FOR THIS PROBLEM HAD BEEN COMPLETED BUT THE PROBLEM WAS NOT FIXED. *NM
FOUND STRESS CRACKS IN REAR WHEELS OF 2004 CHEVROLET CORVETTE WAITING FOR DEALER TO CORRECT THE PROBLEM DON'T WANT TO WAIT FOR INJURY, PROPERTY DAMAGE, OR DEATH. *JB
2002 CHEVROLET CORVETTE WITH CRACKED WHEELS. *JB
Official recalls
104V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.