IllustrationSERVICE COLUMN LOCK DID NOT DISENGAGE WHEN CAR STARTED AND WAS ABLE TO PULL OUT OF PARKING SPOT BEFORE REALIZING I COULD NOT STEER MY VEHICLE! LUCKILY I DID NOT HIT ANYTHING.
1999 Chevrolet Corvette
Owner reports · Recalls · Investigations
More warning signs than most Corvette years
Owner complaints for the 1999 Chevrolet Corvette are substantially higher than the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
230–25K
5725–50K
2250–75K
1775–100K
13100–150K
1150K+
133 reports with mileage · 175 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 194 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports3 fire reports8 injury reports
Steering complaints
194 reportsTL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. AFTER RESTARTING THE VEHICLE, THE STEERING COLUMN FAILED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL WOULD NOT UNLOCK. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), BUT THE REMEDY FAILED TO REPAIR THE FAILURE. THE CONTACT MENTIONED THAT THE STEERING L…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. WHILE ATTEMPTING TO START THE VEHICLE, THE STEERING WHEEL WOULD NOT UNLOCK. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), BUT THE REMEDY FAILED TO REPAIR THE FAILURE. THE CONTACT MENTIONED THAT THE STEERING LOCKED UP WHEN ATTEMPTING TO START THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000. UPDATED 06/29/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED, FREE OF CHARGE. UPDATED 08/03/16.*JB
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT THERE WAS A WARNING LIGHT THAT ILLUMINATED FOR THE STEERING COLUMN LOCKING. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND INDICATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING) BECAUSE THE STATUTE TO HAV…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT THERE WAS A WARNING LIGHT THAT ILLUMINATED FOR THE STEERING COLUMN LOCKING. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND INDICATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING) BECAUSE THE STATUTE TO HAVE THE REPAIR PERFORMED WAS EXPIRED. THE CONTACT WAS UNCERTAIN OF WHEN THE VEHICLE WOULD BE REPAIRED AS THE FAILURE WAS RECENTLY PROGRESSING. THE VEHICLE WAS EITHER TO BE TAKEN TO AN INDEPENDENT MECHANIC OR AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING AND REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 05/24/16*LJ *TR
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT STATED THAT WHILE ATTEMPTING TO DRIVE THE VEHICLE, THE SERVICE COLUMN LOCK WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), HOWEVER THE FAILURE RECURRED. TH…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT STATED THAT WHILE ATTEMPTING TO DRIVE THE VEHICLE, THE SERVICE COLUMN LOCK WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING), HOWEVER THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,846.
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN SEIZED WHILE DRIVING 25 MPH. DURING THE FAILURE, THE STEERING WHEEL LOCK WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO BE DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REME…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE STEERING COLUMN SEIZED WHILE DRIVING 25 MPH. DURING THE FAILURE, THE STEERING WHEEL LOCK WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO BE DIAGNOSED OR REPAIRED. PRIOR TO THE FAILURE, THE VEHICLE WAS REMEDIED ACCORDING TO NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 22,000. UPDATED 02/05/16*LJ UPDATED 05/02/18*JB
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE KEY WAS INSERTED IN THE IGNITION, THE STEERING WHEEL LOCK WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE WARNING INDICATOR LIGHT INSTRUCTED TO REMOVE THE KEY AND WAIT TEN0 SECONDS TO RETRY. THE CONTACT FOLLOWED THE INSTRUCTIONS, BUT IT FAILE…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE KEY WAS INSERTED IN THE IGNITION, THE STEERING WHEEL LOCK WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE WARNING INDICATOR LIGHT INSTRUCTED TO REMOVE THE KEY AND WAIT TEN0 SECONDS TO RETRY. THE CONTACT FOLLOWED THE INSTRUCTIONS, BUT IT FAILED TO UNLOCK THE STEERING WHEEL. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE REPAIR FAILED TO REMEDY THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE KEY WAS REMOVED, THE STEERING WHEEL SEIZED. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHEN THE KEY WAS REMOVED, THE STEERING WHEEL SEIZED. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING); HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.
I RECENTLY DISCOVERED I HAVE A SERVICE COLUMN LOCK ON MY CAR AND HAVE DISCOVERED ITS A RECALL PROBLEM.NHTSA CAMPAGN NUMBER IS 04V060000 AND NHTSA ACTION NUMBER IS EA02031 AND GM RECALL NUMBER IS 04006. MOMENTUMCHEVROLET LOCATED IN SAN JOSE ARE DENYING THIS RECALL AND DON'T WANT TO FIX IT WHEN IT CLEARLY IS A RECALL. SO MY QUESTI…
Read full complaint
I RECENTLY DISCOVERED I HAVE A SERVICE COLUMN LOCK ON MY CAR AND HAVE DISCOVERED ITS A RECALL PROBLEM.NHTSA CAMPAGN NUMBER IS 04V060000 AND NHTSA ACTION NUMBER IS EA02031 AND GM RECALL NUMBER IS 04006. MOMENTUMCHEVROLET LOCATED IN SAN JOSE ARE DENYING THIS RECALL AND DON'T WANT TO FIX IT WHEN IT CLEARLY IS A RECALL. SO MY QUESTION IS ARE THEY ALLOWED TO NOT FIX IT WHEN ITS A RECALL?
THE CORVETTE SHUT DOWN AND DISPLAYED STEERING COLUMN LOCK. BASED ON PRIOR GM CORVETTE RECALLS THE RECALL TO FIX THIS PROBLEM (STEERING COLUMN LOCK) WHERE THEY STATE "A CRASH COULD OCCUR WITHOUT WARNING" DID NOT COVER ALL CORVETTES MADE DURING THIS TIME PERIOD. GM SERVICE OPERATIONS DCS851 EFFECTIVE THROUGH 2003. I DID NOT GE…
Read full complaint
THE CORVETTE SHUT DOWN AND DISPLAYED STEERING COLUMN LOCK. BASED ON PRIOR GM CORVETTE RECALLS THE RECALL TO FIX THIS PROBLEM (STEERING COLUMN LOCK) WHERE THEY STATE "A CRASH COULD OCCUR WITHOUT WARNING" DID NOT COVER ALL CORVETTES MADE DURING THIS TIME PERIOD. GM SERVICE OPERATIONS DCS851 EFFECTIVE THROUGH 2003. I DID NOT GET FAR WITH GM OR THE DEALERSHIP ON ADDRESSING THE COLUMN LOCK ISSUE. SINCE GM STATES IT COULD RESULT IN A CRASH IT SURPRISED ME THAT THEY DON'T HAVE ANY INTEREST IN LOOKING INTO WHETHER THE RECALL SHOULD BE EXPANDED TO INCLUDE OTHER CORVETTES DURING THE TIME PERIOD THEY HAD OVER 126,000 AFFECTED. IF IT WAS NECESSARY BACK THAN WHAT IS DIFFERENT NOW?
Official recalls
204V060000 · Steering:column LOCKING:ANTI-THEFT Device
Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
00V111000 · Seat Belts:front
Apr 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence & remedy
Consequence: WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Remedy: DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE99076 · Front Lap Belt Malfunction
Opened Dec 10, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE99066 · Steering Column Lock Module
Opened Nov 8, 1999 · Closed Jul 21, 2000
Status: closed (inferred from source dates) · Steering
There is no summary currently available