NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
12 reportsClear category filterMileage unknown · Apr 12, 2022
Power TrainService Brakes
Almost every C5 (1997-2004) Corvette is affected by a faulty electronic brake control module. When this module fails, the car illuminates the ABS and traction control light. And displays service abs and service traction control messages. This is a serious safety issue as when this happens, the abs brakes no longer work nor does…
Read full complaint
Almost every C5 (1997-2004) Corvette is affected by a faulty electronic brake control module. When this module fails, the car illuminates the ABS and traction control light. And displays service abs and service traction control messages. This is a serious safety issue as when this happens, the abs brakes no longer work nor does the traction control. It blows my mind how this has never been recalled especially on a rear drive sports car.
NHTSA ODI #11460530
27,000 miles · Sep 11, 2017
Power TrainSteering
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. AFTER THE KEY WAS PLACED IN THE IGNITION, THE VEHICLE CRANKED. HOWEVER, THE STEERING WHEEL WAS IN A LOCKED POSITION AND THE GEAR SHIFTER FAILED TO SHIFT INTO GEAR. A FEW HOURS LATER, THE STEERING WHEEL UNLOCKED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEAL…
Read full complaint
TL* THE CONTACT OWNS A 1999 CHEVROLET CORVETTE. AFTER THE KEY WAS PLACED IN THE IGNITION, THE VEHICLE CRANKED. HOWEVER, THE STEERING WHEEL WAS IN A LOCKED POSITION AND THE GEAR SHIFTER FAILED TO SHIFT INTO GEAR. A FEW HOURS LATER, THE STEERING WHEEL UNLOCKED WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.
NHTSA ODI #11022687
20,000 miles · Jan 27, 2015
Power Train
AT APPROXIMATELY 20,000 MILES THE LINKAGE THAT CONNECTED THE SHIFTER TO THE TRANSMISSION DISENGAGED, I DO NOT HAVE THE SERVICE RECORD FOR THAT SERVICE. HOWEVER, I BELIEVE IT WAS FIXED UNDER THE ORIGINAL WARRANTY COVERAGE. APPARENTLY THERE IS A WEAKNESS IN THE GROMMET THAT CONNECTS THE CABLE. ON JANUARY 19, 2013, AT 71,126 …
Read full complaint
AT APPROXIMATELY 20,000 MILES THE LINKAGE THAT CONNECTED THE SHIFTER TO THE TRANSMISSION DISENGAGED, I DO NOT HAVE THE SERVICE RECORD FOR THAT SERVICE. HOWEVER, I BELIEVE IT WAS FIXED UNDER THE ORIGINAL WARRANTY COVERAGE. APPARENTLY THERE IS A WEAKNESS IN THE GROMMET THAT CONNECTS THE CABLE. ON JANUARY 19, 2013, AT 71,126 MILES THE SAME OCCURRED WHILE I WAS PARKED AT A COSTCO GAS STATION IN LAKE WORTH, FLORIDA. IT REQUIRED A TOW TO MAROONE CHEVROLET IN LAKE WORTH, FLORIDA. THIS SERVICE COST ME $499.34 FROM MY PERSONAL FUNDS. SERVICE REQUIRES A NEW CABLE. ON JANUARY 21, 2015, AT 81,321 MILES THE PROBLEM OCCURRED AGAIN WHILE I WAS PARKED AT THE BASS PRO SHOP IN PALM BAY, FLORIDA. THIS REQUIRED A TOW TO ROSNER CHEVROLET IN MELBORUNE, FLORIDA. THE SERVICE COST ME $397.55 FROM MY PERSONAL FUNDS. SERVICE REQUIRED A NEW CABLE AND GASKETS AS YOU CAN SEE, I AVERAGE ABOUT 5,000 MILES PER YEAR. ALBEIT, THIS CAR IS 16 YEARS OLD AND IN LIKE NEW CONDITION. HAVING OWNED SEVERAL CARS WITH EXCESS OF 100,000 MILES AND HAVE NEVER EXPERIENCED THIS PROBLEM. *TR
NHTSA ODI #10679215
77,893 miles · Feb 4, 2004
Power Train
AUTOMATIC TRANSMISSION LOST REVERSE AND 2ND GEAR WITHOUT WARNING OF ANY KIND. BROKEN SUN SHELL. *AK
NHTSA ODI #10056556
Mileage unknown · Dec 2, 2003
Engine And Engine CoolingExterior LightingPower Train
THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS…
Read full complaint
THE STEERING WHEEL WOULD LOCK AFTER LEAVING THE VEHICLE IDLING FOR A PERIOD OF THREE TO FIVE MINUTES. WHEN PLACING THE KEY IN THE IGNITION, THE WARNING INDICATOR SUGGESTED TAKING THE KEY OUT AND TRY AGAIN IN TEN SECONDS. THE DEALER MADE SOME REPAIRS TO THE STEERING COLUMN, BUT THE PROBLEM STILL OCCURRED. *AK OTHER PROBLEMS ARE AS FOLLOWED: THE RIGHT WINDOW LEAKED WATER WHERE THE TOP MEETS THE WINDSHIELD(BADLY), THE REAR DIFFERENTIAL AREA LEAKED FLUID WHEN SAT OVERNIGHT, THERE WAS A RATTLING NOISE UNDERNEATH THE VEHICLE DUE TO THE TRANSMISSION COOLER LINERS BEING MISADJUSTED, THERE WAS A RATTLE IN THE ENGINE WHEN ACCELERATED UP A HILL OR WHEN TAKING OFF, THE DRIVER DOOR LEAKED WHEN IT RAINED AND SCRAPES WHEN ROLLED DOWN, THERE WAS A GRINDING IN THE REAR END WHEN BACKED UP OR WHEN IT'S COLD, THE RIGHT DOOR GLASS RATTLED WHILE THE VEHICLE WAS IN MOTION, AND THE WIPERS WERE INOPERATIVE. THE CONVERTIBLE TOP WAS REPLACED. *SCC THE FOG LAMP WAS REPLACED AND THE SPOILER WAS LOOSE. *JB
NHTSA ODI #10044225
Mileage unknown · Aug 1, 2003
Power Train
CLUTCH INTERMITTENTLY WILL NOT RETURN TO THE HOUSING UNIT. TRANSMISSION WILL BECOME STUCK. *AK
NHTSA ODI #10031933
Mileage unknown · Sep 5, 2002
Power Train
CONSUMER STATES THERE IS A DESIGN FLAW IN THE MANUAL TRANSMISSION, CONSUMER IS UNABLE TO SHIFT FROM FIRST TO SECOND GEAR, GOES TO FOURTH GEAR INSTEAD. CONTACTED DEALER, WHO INFORMED CONSUMER THAT THIS WAS WHAT IT WAS SUPPOSED TO DO THIS AS A FUEL SAVER.*JB *NLM
NHTSA ODI #8017992
Mileage unknown · Mar 11, 2002
Power TrainCrashInjury
THE VEHICLE WAS PARKED, THE TRANSMISSION WAS IN PARK, BEFORE THE CAR COULD BE SHUT OFF. THE CAR TOOK OFF SPINNING THE REAR WHEELS, JUMPED OVER A CONCRETE PARKING STOP AND OVER A SMALL HEDGE INTO A TREE, WHEN THE CAR HIT THE TREE THE CAR CONTINUED TO SPIN THE REAR TIRES (WHILE IN PARK) UNTIL THE KEY WAS SHUT OFF. THE AIR BAGS DID…
Read full complaint
THE VEHICLE WAS PARKED, THE TRANSMISSION WAS IN PARK, BEFORE THE CAR COULD BE SHUT OFF. THE CAR TOOK OFF SPINNING THE REAR WHEELS, JUMPED OVER A CONCRETE PARKING STOP AND OVER A SMALL HEDGE INTO A TREE, WHEN THE CAR HIT THE TREE THE CAR CONTINUED TO SPIN THE REAR TIRES (WHILE IN PARK) UNTIL THE KEY WAS SHUT OFF. THE AIR BAGS DID NOT INFLATE, THE CAR HAS EXTENSIVE DAMAGE, THE COMPUTER SHOWED TO SERVICE VEHICLE SOON WHEN STARTED, PREVIOUS DAY THE VEHICLE WAS FILLED WITH GAS AND THE GUAGE WENT CRAZY AND THE DASH LIGHTS BLINKED OFF AND ON WHILE BEEING DRIVEN ON THE FREEWAY. THE VEHILCE HAS BEEN RECALLED FOR THE STEERING LOCKING TWICE, ONCE BY MAIL, ONCE THE STEERING DID LOCK UP AND HAD TO BE TOWED INTO THE DEALERSHIP FOR 72HRS OF REPAIR, SOUNDS LIKE A LIE, BUT THIS REALLY HAPPENED, I AM AFRAID THE CAR HAS A MALFUNCTION IN THE COMPUTER AND IT WILL KILL SOMEONE IF FIXED AND DRIVEN AGAIN. *AK REF. IN EA02-031 *CJS
NHTSA ODI #759226
Mileage unknown · Jun 22, 2000
Power TrainSteering
STEERING COLUMN LOCKED AT 10 MPH THEN STALLED WHEN CLUTCH RELEASED. *AK REF. IN EA02-031 *CJS
NHTSA ODI #724384
Mileage unknown · Feb 9, 2000
Power Train
THIS VEHICLE HAS A LOCKOUT ON THE STANDARD TRANSMISSION THAT REQUIRES THE DRIVER TO SHIFT FROM 1ST GEAR DIRECTLY TO 4TH GEAR AT INTERVALS I HAVE BEEN UNABLE TO DETERMINE. A LIGHT COMES ON THE DASH TELLING THE DRIVER TO SHIFT FROM 1ST TO 4TH AND IF IT IS NOT EXPECTED OR NOTICED ( MOSTLY WHEN TURNING AND YOUR EYES ARE FOCUSED ON …
Read full complaint
THIS VEHICLE HAS A LOCKOUT ON THE STANDARD TRANSMISSION THAT REQUIRES THE DRIVER TO SHIFT FROM 1ST GEAR DIRECTLY TO 4TH GEAR AT INTERVALS I HAVE BEEN UNABLE TO DETERMINE. A LIGHT COMES ON THE DASH TELLING THE DRIVER TO SHIFT FROM 1ST TO 4TH AND IF IT IS NOT EXPECTED OR NOTICED ( MOSTLY WHEN TURNING AND YOUR EYES ARE FOCUSED ON THE ROAD) CAUSES A SIGNIFICANT REDUCTION IN SPEED. THIS HAS CAUSED DRIVERS BEHIND ME TO STAND ON THEIR BRAKES TO KEEP FROM HITTING MY VEHICLE IN THE REAR ,AND HAS RESULTED IN SEVERAL DRIVERS BECOMING QUITE IRATE WITH ME. *AK
NHTSA ODI #718512
Official recalls
2Feb 9, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Apr 17, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence & remedy
Consequence: WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Remedy: DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA02031 · Steering Column Lockup
Opened Nov 15, 2002 · Closed Mar 11, 2004
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE99076 · Front Lap Belt Malfunction
Opened Dec 10, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE99066 · Steering Column Lock Module
Opened Nov 8, 1999 · Closed Jul 21, 2000
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration