FUEL PUMP LOUD HIGH PITCH HUM BEHIND DRIVER SEAT MENTIONED TO SERVICE 3 TIMES SINCE NEW. REAR HATCH POPS OPEN WHILE IN PARK VERY OFTEN,2 TIMES WHILE PARK SECURITY THREAT. STEERING COLUMN HAS JUST STARTED TO LOCK UP IN PARK-3 TIMES. SEAT BELTS REPLACED AT 700 MILES OR SO DUE TO NOT RETRACTING...STILL LOCK UP WHILE TRYING TO BE…
Read full complaint
FUEL PUMP LOUD HIGH PITCH HUM BEHIND DRIVER SEAT MENTIONED TO SERVICE 3 TIMES SINCE NEW. REAR HATCH POPS OPEN WHILE IN PARK VERY OFTEN,2 TIMES WHILE PARK SECURITY THREAT. STEERING COLUMN HAS JUST STARTED TO LOCK UP IN PARK-3 TIMES. SEAT BELTS REPLACED AT 700 MILES OR SO DUE TO NOT RETRACTING...STILL LOCK UP WHILE TRYING TO BEND FORWARD TO VIEW OTHER DRIVERS,IE; OFF RAMPS/YIELDS/PARKING LOTS. SAFETY PROBLEM AT HIGH SPEEDS. PAINT FLAKING OFF MUFFLERS SINCE NEW- VERY UNSIGHTLY FOR SHOWS,YELLOWING DOOR HANDLES AT LOCKS ON WHITE CAR,WATER DRIPS INTO REAR HATCH WHEN OPENED. LEATHER SEAT IS WEARING TOO SOON ON PASSENGER SIDE/WRINKLES IN LEATHER. ABS FAILED, 2 TIMES LOCKED UP. KEYLESS REMOTE WILL NOT KEEP MEMORY AND THE ASHTRAY IS TOO SMALL AND DRIVER COULD HAVE ACCIDENT TRYING TO FIND IT BEHIND THE SHIFT HANDLE. !) EDED BY ITSELF. *AK REF. IN EA02-031 *CJS
NHTSA ODI #735886
Mileage unknown · Oct 6, 2000
Steering
MY STEERING WHEEL COLUMN LOCKED WHEN MY CAR WAS PARKED. IT HAD TO BE TOWED TO THE NEAREST DEALER BAY CHEVROLET TO BE FIX. WHEN IT LOCKED THE COMPUTER OR (DIC) READ SERVICE COLUMN LOCKED. I WAS UNABLE TO MOVE MY CAR. THE CAR STARTED BUT I COULD NOT USE MY STEERING WHEEL TO GUIDE THE CAR. LUCKY FOR ME I WAS PARKED AT HOME. …
Read full complaint
MY STEERING WHEEL COLUMN LOCKED WHEN MY CAR WAS PARKED. IT HAD TO BE TOWED TO THE NEAREST DEALER BAY CHEVROLET TO BE FIX. WHEN IT LOCKED THE COMPUTER OR (DIC) READ SERVICE COLUMN LOCKED. I WAS UNABLE TO MOVE MY CAR. THE CAR STARTED BUT I COULD NOT USE MY STEERING WHEEL TO GUIDE THE CAR. LUCKY FOR ME I WAS PARKED AT HOME. IF I WAS ON THE ROAD AND THIS HAPPEN , I HATE TO EVEN THINK ABOUT THE LOSS OF MY LIFE AND THE OTHERS ON OUR HIGHWAYS. THIS PROBLEM CAME WITHOUT WARNING. THE DEALER SAID THAT AN ACTUATOR FAILED. SOME REPORTS ON THE NET HAS INDOCATED THAT THIS LOCKED STEERING UNIT FAIL S EVEN WHILEL DRIVING THE CAR. THIS IS A DANGER AND A HAZARD. PLEASE TO DEMANDED THAT GM RECALL THIS SAFETY DEFECT BEFORE SOMEONE LOSS THEIR LIFE NEEDLESSLY. *AK REF. IN EA02-031 *CJS
NHTSA ODI #733598
Mileage unknown · Oct 2, 2000
Steering
STEERING WHEEL COLUMN LOCK FAILS AND ENGAGES THE WHEEL IN A LOCKED POSITION. THE CAR BECOMES UNDRIVEABLE AND MUST BE TOWED. MY CONCERN IS IF THIS WERE TO HAPPEN WHILE DRIVING. I WAS PARKED. THE DEALERSHIP TOLD ME IT WAS A VERY COMMON PROBLEM. THERE IS. *AK REF. IN EA02-031 *CJS
NHTSA ODI #733150
Mileage unknown · Sep 11, 2000
Steering
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
NHTSA ODI #731022
Mileage unknown · Sep 5, 2000
Steering
THE MESSAGE "SERVICE COLUMN LOCK" CAME ON AND THE STEERING COLUMN LOCKED UP (LUCKILY NOT WHILE DRIVING). I UNDERSTAND THAT THIS IS QUITE A COMMON PROBLEM ON C5 CORVETTES AND WOULD LIKE TO KNOW WHAT GM ARE GOING TO DO ABOUT IT. THANK YOU. REF. IN EA02-031 *CJS
NHTSA ODI #730256
Mileage unknown · Aug 1, 2000
Steering
MY 97 COUPE, 16K, HAD ITS STEERING COLUMN LOCK TROUBLES WHILE BEING VALET PARKED DURING VACATION IN SC. REF. IN EA02-031 *CJS
NHTSA ODI #726350
Mileage unknown · Jul 19, 2000
Steering
THIS IS THE THIRD INCIDENT OF THIS TYPE ON THIS CAR. THE STEERING COLUMN LOCKS UP ON THE VEHICLE MAKING THE CAR INOPERABLE. THIS IS A WELL KNOWN DEFECT ON THIS CAR THAT COULD CAUSE A SERIOUS ACCIDENT IF IT WERE TO OCCUR WHILE DRIVING. MY CAR IS CURRENTLY AT THE DEALERSHIP FOR THE SECOND TIME WITHIN 6 WEEKS FOR THE SAME PROBLE…
Read full complaint
THIS IS THE THIRD INCIDENT OF THIS TYPE ON THIS CAR. THE STEERING COLUMN LOCKS UP ON THE VEHICLE MAKING THE CAR INOPERABLE. THIS IS A WELL KNOWN DEFECT ON THIS CAR THAT COULD CAUSE A SERIOUS ACCIDENT IF IT WERE TO OCCUR WHILE DRIVING. MY CAR IS CURRENTLY AT THE DEALERSHIP FOR THE SECOND TIME WITHIN 6 WEEKS FOR THE SAME PROBLEM. THE DEALER DOESN'T KNOW WHAT CUAES THE PROBLEM, AND CONSEQUENTLY HOW TO FIX IT. GM BARLEY ACKNOWLEDGES THE PROBLEM EVEN EXISTS, SAYING THEY HAVE BEEN WORKING ON A FIX FOR THE PROBLEM. THEY DON'T SEEM TO PERCEIVE IT AS A SAFETY ISSUE. I FEEL AS THOUGH THIS COMMON DEFECT NEEDS TO BE THE SUBJECT OF A RECALL BY THE MANUFACTURER SO THAT THE OWNERS OF THESE CARS CAN FEEL SAFE WHILE DRIVING THEM.*AK REF. IN EA02-031 *CJS
NHTSA ODI #725701
Mileage unknown · Jul 12, 2000
Steering
COMMON PROBLEM ON CORVETTE THAT SERVICE COLUMN LOCK LIGHT COMES ON AND COLUMN MAY LOCK AT SPEED. DEALER STATED THAT IT A COMMON PROBLEM AND THERE IS NO RECALL. THEY CAN ONLY REPLACE CURRENT PARTS. CAR IS UNSAFE !*AK
NHTSA ODI #725343
Mileage unknown · Jul 12, 2000
Steering
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #725340
Mileage unknown · Jun 30, 2000
Steering
I HAVE HEARD HUNDREDS OF THESE SAME PROBLEMS ON THE CORVETTE AND NOTHING IS BEING DONE ABOUT IT. THIS COULD BE A VERY SERIOUS PROBLEM IF IT WERE TO LOCK UP DURING DRIVING OPERATIONS. NO SAFETY DEFECT LISTED IN SUMMARY. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELTS IN THESE VEHICLES INCORPORATE AN ENERGY MANAGEMENT LOOP. THIS LOOP IS INADEQUATE TO ABSORB THE NECESSARY FORCES THAT CAN BE EXERTED ON IT. THEREFORE, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE ENERGY MANAGEMENT LOOP WILL NOT ABSORB ENOUGH ENERGY, AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE DRIVER AND PASSENGER SIDE SEAT BELT RETRACTOR ASSEMBLIES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE A TORN FUEL TANK SENDING UNIT/PUMP SEAL. THIS CAN CAUSE FUEL ODOR AND/OR LEAKAGE AT THE ATTACHMENT LOCATION.
Consequence & remedy
Consequence: FUEL LEAKAGE FROM A TORN SEAL CAN RESULT IN A FIRE IF AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT HAND FUEL TANK ASSEMBLIES (INCLUDING FUEL SENDING UNIT AND PUMP).
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE99076 · Front Lap Belt Malfunction
Opened Dec 10, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1997 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration