BATTERY LEAKAGE CAUSED EXTENSIVE DAMAGE TO WIRING HARNESS AND TCM COMPONETS.THE BATTERY POST FAILED AND ACID WAS RELEASED THRU BATTERY HOLDER TO COMPONETS BELOW.THIS ITEM IS A HAZARD SINCE IT TOTAL DISABLE CAR ELECTRONICS.AND IS OF POOR DESIGN PUTTING COMPUTER AND MAIN WIRING HARNESS DIRECTLY BELOW BATTERY CASE. AFTER SOME RESEA…
Read full complaint
BATTERY LEAKAGE CAUSED EXTENSIVE DAMAGE TO WIRING HARNESS AND TCM COMPONETS.THE BATTERY POST FAILED AND ACID WAS RELEASED THRU BATTERY HOLDER TO COMPONETS BELOW.THIS ITEM IS A HAZARD SINCE IT TOTAL DISABLE CAR ELECTRONICS.AND IS OF POOR DESIGN PUTTING COMPUTER AND MAIN WIRING HARNESS DIRECTLY BELOW BATTERY CASE. AFTER SOME RESEARCH I FIND THIS HAS BEEN MANY SUCH INSTINCES OF THIS HAPPENING AND THE COST IS NOT CHEAP AT ABOUT $3000 TO $4000.*AK
NHTSA ODI #10028754
66,000 miles · Dec 19, 2002
Electrical System
BATTERY LEAKED ACID ON TO PCM UNDER BATTERY TRAY AND ON TO A/C VACCUM HOSE.
NHTSA ODI #10000254
Mileage unknown · Jul 16, 2002
Electrical SystemSteering
KEY IN IGNITION SWITCH WILL NOT TURN ,AND STEERING WHEEL WOULD NOT UNLOCK. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK REF. IN EA02-031 *CJS
NHTSA ODI #8014040
Mileage unknown · Oct 12, 2001
Electrical SystemEngine And Engine Cooling
ON SEVERAL OCCASIONS WHILE DRIVING INSTRUMENT PANEL WOULD REGISTER "REDUCE ENGINE POWER" WHICH CAUSED VEHICLE NOT TO ACCELERATE, BUT GO NO MORE THEN 5 MPH. VEHICLE BACK IN DEALER'S SHOP AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS MATTER. *AK
NHTSA ODI #897672
Mileage unknown · Feb 17, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
VEHICLE HAS HAD CONTINUED NO START CONDITON AND VEHICLE NOT BEING ABLE TO GO OVER 5 MPH SEVERAL REPLACEMENTS AND REPAIRS. (BATTERY,ELECTRICAL CONTROL UNITS(TCM,EBTCM,TAC) REPLACED TWO TIMES, FOR LEAK AND FAILURE,TP SENSOR REPLACED. YH
NHTSA ODI #550989
Mileage unknown · Nov 16, 1998
Electrical SystemSeat Belts
10/14/97 RECALL- REPLACE BOTH SEAT BELT RETRACTORS 10/14/97 SPEAKERS RATTLE WHILE DRIVING, PARTS REPLACED ON 3/9/98. 3/9/98 WAS IN SERVICE FOR 'SERVICE TRACTION SYSTEM, ENGINE POWER IS REDUCED' MSG THAT WAS RECEIVED ON CAR'S SYSTEM. WHILE DRIVING 65 MPH DOWN THE EXPRESSWAY, THE CAR LOST SIGNIFICANT ENGINE POWER AND THE CAR'S S…
Read full complaint
10/14/97 RECALL- REPLACE BOTH SEAT BELT RETRACTORS 10/14/97 SPEAKERS RATTLE WHILE DRIVING, PARTS REPLACED ON 3/9/98. 3/9/98 WAS IN SERVICE FOR 'SERVICE TRACTION SYSTEM, ENGINE POWER IS REDUCED' MSG THAT WAS RECEIVED ON CAR'S SYSTEM. WHILE DRIVING 65 MPH DOWN THE EXPRESSWAY, THE CAR LOST SIGNIFICANT ENGINE POWER AND THE CAR'S SYSTEM VERY SUDDENLY REDUCED WHEN I WAS DRIVING DOWN THE I355 EXPRESSWAY. I WAS ALMOST REAR-ENDED. THE DEALER DID NOTHING TO FIX THE PROBLEM. (I HAVE A SERVICE RECORD INDICATING THIS.) 4/6/98 WAS IN SERVICE FOR 'SERVICE TRACTION SYSTEM, ENGINE POWER IS REDUCED' MSG THAT WAS RECEIVED ON CAR'S SYSTEM AGAIN. VEHICLE DID THE SAME THING AGAIN, AND I ALMOST GOT INTO AN ACCIDENT WHEN TURNING LEFT; NEARLY GOT SIDE SWIPED BECAUSE OF THE REDUCED SPEED. WAS ACCELERATING NORMALLY TO TURN LEFT. SERVICE DEALER REPLACED THE ELECTRONIC THROTTLE CONTROL MODULE & SAID THAT THIS WOULD FIX THE PROBLEM. 7/3/98 I COMPLAINED TO DEALER SVC DEPT ABOUT BURNING GAS SMELL. ALSO, SAME MSG CAME UP 'ENGINE POWER REDUCED. '11/5/98 SAME MSG' SERVICE TRACTION SYSTEM, ENGINE POWER REDUCED' CAME UP. THEY ARE REPLACING A PART & THEY ARE NOT SURE IF THIS WILL FIX THE PROBLEM. CHEVROLET TROUBLE TICKET :ON 4/17/98 I OPENED UP A TROUBLE TICKET WITH CHEVROLET REF # 980225396. 4/17/98 CALLED CUST SVC NUMBER (800) 222-1020 & TALKED TO ERNST AT X3797 HE SAID I WOULD BE CONTACTED WITHIN 2 DAYS TO DISCUSS STATUS OF THIS RECURRING PROBLEM. NOBODY EVER CONTACTED ME. 11/5/98 TALKED TO PATRICK AKANDU. HE SAID HE WOULD LEAVE A MESSAGE RICK WASHINGTON WHO IS REVIEWING MY FILE & HE WOULD GET BACK TO ME. NOBODY EVER DID. ON 11/5/98 I CALLED THE STATE ATTORNEY GENERAL'S OFFICE- IN ILLINOIS AT 312-814-3000 TO FIND OUT IF LEMON LAW APPLIES- APPARENTLY NOT BECAUSE IT'S OVER 1 YEAR OLD. ON 11/16/98 CALLED & TALKED TO CUST SVC (800) 222-1020 TO ASK STATUS OF MY TICKET. THEY HAD NOTHING TO TELL ME. JOHN MCDONOUGH FROM CELOZZI ETTLESON SERVICE INDICATED THAT HE CANNOT GUARANTEE THAT THIS PROBLEM W
NHTSA ODI #700645
Mileage unknown · Apr 28, 1998
Electrical SystemVehicle Speed Control
THREE TIMES ENGINE DIED UNEXPECTEDLY WHILE DRIVING .
NHTSA ODI #534916
Mileage unknown · Apr 23, 1998
Electrical SystemEngine And Engine CoolingVehicle Speed Control
DEFECTIVE THROTTLE CONTROL MODULE CAUSED ENGINE TO DIE/IDLE.ALSO POWER CONTROL MODULE AND ENGINE FAILED, CAUSING VEHICLE TO STALL.
NHTSA ODI #534703
Mileage unknown · Aug 4, 1997
Electrical System
CONSUMER'S VEHICLE SHUTS OFF AT ANY GIVEN TIME. THE FIRST TIME CONSUMER WAS AT 0 SPEED WAITING TO ENTER INTERSECTION WHEN SHUT DOWN OCCURRED; SECOND TIME, WAS DRIVING APPROX. 35 MPH ON FREEWAY WHEN SHUT DOWN OCCURRED. CONSUMER CONTACTED DEALER AND WAS TOLD THAT MANUFACTURER IS AWARE OF PROBLEM, AND WERE NOT SENDING OUT NOTICES …
Read full complaint
CONSUMER'S VEHICLE SHUTS OFF AT ANY GIVEN TIME. THE FIRST TIME CONSUMER WAS AT 0 SPEED WAITING TO ENTER INTERSECTION WHEN SHUT DOWN OCCURRED; SECOND TIME, WAS DRIVING APPROX. 35 MPH ON FREEWAY WHEN SHUT DOWN OCCURRED. CONSUMER CONTACTED DEALER AND WAS TOLD THAT MANUFACTURER IS AWARE OF PROBLEM, AND WERE NOT SENDING OUT NOTICES TO CONSUMERS. *AK
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence & remedy
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELTS IN THESE VEHICLES INCORPORATE AN ENERGY MANAGEMENT LOOP. THIS LOOP IS INADEQUATE TO ABSORB THE NECESSARY FORCES THAT CAN BE EXERTED ON IT. THEREFORE, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE ENERGY MANAGEMENT LOOP WILL NOT ABSORB ENOUGH ENERGY, AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE DRIVER AND PASSENGER SIDE SEAT BELT RETRACTOR ASSEMBLIES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE A TORN FUEL TANK SENDING UNIT/PUMP SEAL. THIS CAN CAUSE FUEL ODOR AND/OR LEAKAGE AT THE ATTACHMENT LOCATION.
Consequence & remedy
Consequence: FUEL LEAKAGE FROM A TORN SEAL CAN RESULT IN A FIRE IF AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT HAND FUEL TANK ASSEMBLIES (INCLUDING FUEL SENDING UNIT AND PUMP).
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Additional source detail variants (3)
Steering:column
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering:column LOCKING:ANTI-THEFT Device
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
Steering
IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.
PE02054 · Steering Column Lockup
Opened Jul 1, 2002 · Closed Nov 15, 2002
Status: closed (inferred from source dates) · Steering
SEE RESUME IN REPOSITORY.
EA00009 · Front Lap Belt Malfunction
Opened Mar 16, 2000 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Seat Belts
ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.
PE99076 · Front Lap Belt Malfunction
Opened Dec 10, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1997 Chevrolet Corvette Problems, Complaints & Recalls | Skip That Year
Illustration