IllustrationAPPEARS THE ASR UNIT HARD SHORTED SENDING ELECTRICITY THROUGH ALL 3 THROTTLE CABLES AND SEBSEQUENTLY MELTING THEM. THANKFULLY THE VEHICLE DIDN'T START ON FIRE. THIS PROBLEM OCCURRED ON THE FIRST DRIVE OF THE DAY AFTER ABOUT 7 MINUTES OF LOW SPEED (CITY) OPERATION SINCE ENGINE START.
1996 Chevrolet Corvette
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Chevrolet Corvette do not stand out strongly from the model-year median of 29.
About this comparison →How this year compares
Owner complaints by model year
Compare all Corvette years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 44 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Tires. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports4 fire reports1 injury reports
Electrical System complaints
9 reportsTRIED TO START VEHICLE, BUT 'SECURITY' LIGHT CAME ON & ENGINE WOULD NOT TURN OVER. RESEARCHED ISSUE ONLINE & FOUND THAT THIS IS DUE TO A KNOWN IGNITION LOCK CYLINDER PROBLEM. THE WIRES LEADING TO THE IGNITION LOCK CYLINDER BREAK, AND WILL NOT ALLOW THE ANTI-THEFT SYSTEM TO PROPERLY READ THE SECURITY CODE FROM THE KEY. *TR
UPON NORMAL AUTO START SEQUENCE, STARTER WOULD NOT DISENGAGE. REMOVED KEY FROM VEHICLE CYLINDER LOCK AND STARTER CONTINUED TO CRANK ENGINE. STARTER MOTOR BEGAN TO SMOKE AND CAUGHT FIRE BEFORE BATTERY COULD BE DISCONNECTED TO REMOVE POWER FROM VEHICLE. BURNED UP STARTER MOTOR AND O2 WIRING HARNESS AROUND LOCATION OF STARTER MOTO…
Read full complaint
UPON NORMAL AUTO START SEQUENCE, STARTER WOULD NOT DISENGAGE. REMOVED KEY FROM VEHICLE CYLINDER LOCK AND STARTER CONTINUED TO CRANK ENGINE. STARTER MOTOR BEGAN TO SMOKE AND CAUGHT FIRE BEFORE BATTERY COULD BE DISCONNECTED TO REMOVE POWER FROM VEHICLE. BURNED UP STARTER MOTOR AND O2 WIRING HARNESS AROUND LOCATION OF STARTER MOTOR. SAME FAILURE OCCURRED IN 1999. *TR
PASSIVE KEYLESS ENTRY LIGHT CAME ON AND THEN WHILE VEHICLE WAS MOVING HATCH RELEASED. ALTMOST LOSING CONTROL OF VEHICLE. *JB
CHECK ENGINE LIGHT ON / DISTRIBUTOR FAILED WHILE DRIVING, ENGINE STALLED, LOST POWER STEERING. ENGINE REFIRED. ON WAY TO DEALER ENGINE STALLED IN TRAFFIC.*AK
VEHICLE CAUGHT ON FIRE IN GARAGE DUE TO ELECTRICAL FAULT IN FACTORY WIRING. FIRE ORIGINATED ON DRIVER'S SIDE OF ENGINE COMPARTMENT. *AK
WHILE PARKED AN ELECTRICAL SHORT IN THE COMPUTER SYSTEM CAUSED THE VEHICLE TO CATCH ON FIRE. *AK CONSUMER STATES THAT THERE WAS ALSO STRUCTURAL DAMAGE TO FURNITURE AND PROPERTY. *SLC
INTAKE MANIFOLD GASKET FAILED.
TRANSMISSION CONTROLLED BY COMPUTERIZED EPA SHIFTING WHICH FORCED TRANSMISSION INTO TWO GEARS AT ONCE, CAUSING LOSS OF CONTROL. *SD
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
DP96006 · Brake Pull
Opened May 14, 1996 · Closed Oct 18, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THE PETITIONS STATED THAT:WE REPRESENT THE OWNER OF A 1990 CHEVROLET CORVETTE WHICH, WHEN THE BRAKES WERE APPLIED, SUDDENTLY, VIOLENTLY, AND UNEXPECTEDLY PULLS TO THE LEFT.THIS IS A INTERMITTENT DEFECT WHICH DOES NOT OCCUR WITH AN REGULARITY.