IllustrationThe FRAME rotten away
2005 Chevrolet Colorado
Owner reports · Recalls · Investigations
More warning signs than most Colorado years
Owner complaints for the 2005 Chevrolet Colorado are substantially higher than the model-year median of 84.
About this comparison →How this year compares
Owner complaints by model year
Compare all Colorado years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
760–25K
6425–50K
5550–75K
4575–100K
26100–150K
22150K+
288 reports with mileage · 68 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports11 fire reports16 injury reports
Unknown Or Other complaints
11 reportsThe driver side frame has rusted through in more than on location. Passenger side frame has rust but still solid. Dealership and private mechanic said this is a common problem with 2005 Colorado. Dealership will not buy vehicle for liability reasons. Frame could crack while driving and cause unsafe driving conditions. The bod…
Read full complaint
The driver side frame has rusted through in more than on location. Passenger side frame has rust but still solid. Dealership and private mechanic said this is a common problem with 2005 Colorado. Dealership will not buy vehicle for liability reasons. Frame could crack while driving and cause unsafe driving conditions. The body and engine is in good shape. 105000 miles on vehicle.
I'M ON DISABILITY ,HARD OF HEARING, AND BAD SPINE,,,BUT I BOUGHT THIS TRUCK AT FIELDMANS IN LANSING MICH,,THE DEALER OR CARFAX DID NOT MENTION THAT THE FRAME WAS RUSTED AND BROKE ON DRIVER SIDE REAR LEAFSPINGS,,NOW WHAT DO I DO
I'VE TRIED TO HAVE A GARAGE REPAIR/FIX MY HEATER/FAN MOTOR THREE TIMES TO NO AVAIL. HEATER WORKS ON HIGH ONLY...AND NOT ON ANY OTHER SPEEDS.
WAS DRIVING TO WORK IN THE MORNING AND HEARD A LOUD POP AS I WAS MOVING THROUGH MY RURAL TOWN, THE TRUCK STARTED TO HANDLE FUNNY. ONCE I GOT TO WORK I NOTICED THE BED DIDNT LOOK RIGHT. THE FRAME WAS CRACKED. BAD STEEL MADE IT RUST OUT BEFORE THE BODY. I DONT THINK THE FRAME WAS DESIGNED CORRECTLY OR MAYBE THE STEEL WAS POOR QUAL…
Read full complaint
WAS DRIVING TO WORK IN THE MORNING AND HEARD A LOUD POP AS I WAS MOVING THROUGH MY RURAL TOWN, THE TRUCK STARTED TO HANDLE FUNNY. ONCE I GOT TO WORK I NOTICED THE BED DIDNT LOOK RIGHT. THE FRAME WAS CRACKED. BAD STEEL MADE IT RUST OUT BEFORE THE BODY. I DONT THINK THE FRAME WAS DESIGNED CORRECTLY OR MAYBE THE STEEL WAS POOR QUALITY.
BOTH THE RIGHT AND LEFT SIDE FRAME RAILS ARE SERIOUSLY DETERIORATED WITH LARGE AMOUNTS OF THE STEEL MISSING. THE REMAINING FRAME IS HEAVILY RUSTED. THE FRONT OF THE TRUCK BED IS BEGINNING TO SINK DUE TO THE MISSING FRAME STEEL. THERE IS A REAL POSSIBILITY OF CATASTROPHIC FAILURE OF THE FRAME WHICH WILL RESULT IN LOSS OF CONTROL …
Read full complaint
BOTH THE RIGHT AND LEFT SIDE FRAME RAILS ARE SERIOUSLY DETERIORATED WITH LARGE AMOUNTS OF THE STEEL MISSING. THE REMAINING FRAME IS HEAVILY RUSTED. THE FRONT OF THE TRUCK BED IS BEGINNING TO SINK DUE TO THE MISSING FRAME STEEL. THERE IS A REAL POSSIBILITY OF CATASTROPHIC FAILURE OF THE FRAME WHICH WILL RESULT IN LOSS OF CONTROL OF THE VEHICLE.
TRUCK FRAME FAILURE AT THE WELD POINT OF THE REAR LEAF SPRING (FRONT FRAME MOUNT), DUE TO CORROSION.
TAKATA RECALL MY 2005 CHEVY COLORADO THE FRAME ON PASSAGER SIDE FRAME HAS A HOLE IN IT AND DUE TO RUST IF NOT FIXED SOON THE FRAME WILL BE INTO BE VERY UNSAFE TO DRIVE ON ANY ROAD FRAME. SOULD NOT BE BAD IN 11 YEARS I CAN SEND PICS TO JUST SAW THIS LAST OIL CHANGE.
MY TRUCK HAS STOPPED WHILE DRIVING. EVERYTHING SEEMS TO SHUT DOWN AND I HAVE NO CONTROL OF THE VEHICLE. THEN THE CHECK ENGINE SYMBOL COMES ON. AFTER A MINUTE OR TWO, IT STARTS BUT DOES THE SAME THING AGAIN.
NO SPEED REQUIRED. THE A/C & HEATER NOT WORKING. IT WAS FIXED WHILE UNDER WARRANTY AND IT WORKED FOR A SERIES OF MONTHS AND THEN IT BEGAN ACTING UP AGAIN TOOK THE VEHICLE IN AND IT HAD JUST GONE OUT OF WARRANTY. IT WAS OBVIOUS THAT THE ISSUE WAS EXACTLY THE SAME PROBLEM AND THEY REFUSED TO COMPLETE THEIR WORK. IN THE WINTER OR D…
Read full complaint
NO SPEED REQUIRED. THE A/C & HEATER NOT WORKING. IT WAS FIXED WHILE UNDER WARRANTY AND IT WORKED FOR A SERIES OF MONTHS AND THEN IT BEGAN ACTING UP AGAIN TOOK THE VEHICLE IN AND IT HAD JUST GONE OUT OF WARRANTY. IT WAS OBVIOUS THAT THE ISSUE WAS EXACTLY THE SAME PROBLEM AND THEY REFUSED TO COMPLETE THEIR WORK. IN THE WINTER OR DURING DAMP WEATHER IT'S IMPOSSIBLE TO DRIVE DUE TO WINDSHIELD FOGGING UP. IT PRESENTS A VERY UNSAFE CONDITION.
Official recalls
310V575000 · Child Seat
Nov 18, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2004-2011, CHEVROLET COLORADO, GMC CANYON, MODEL YEAR 2006, ISUZU I-280/I-350, AND MODEL YEAR 2007-2008, I-290/I-370, REGULAR CAB VEHICLES AND EXTENDED CAB VEHICLES WITHOUT A REAR SEAT AND EQUIPPED WITH A FRONT 60/40 SPLIT BENCH SEAT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT IS NOT ACCESSIBLE AND THE OWNER MANUAL DOES NOT INCLUDE INSTRUCTIONS REGARDING HOW TO USE THE TOP TETHER.
Consequence & remedy
Consequence: BOTH NHTSA AND GM DISCOURAGE PLACEMENT OF A CHILD IN A FRONT SEAT. NEVERTHELESS, THERE ARE INDIVIDUAL CIRCUMSTANCES THAT MAY REQUIRE PLACEMENT OF A CHILD IN A RESTRAINT IN THE FRONT CENTER SEATING POSITION OF THIS VEHICLE THAT DOES NOT OFFER A REAR SEAT. LACK OF ACCESS TO THE TOP TETHER ANCHOR AND A LACK OF INSTRUCTIONS AS TO HOW TO USE IT, MAY RESULT IN IMPROPER INSTALLATION OF A CHILD RESTRAINT. IMPROPER INSTALLATION OF A CHILD RESTRAINT CAN RESULT IN A REDUCTION IN THE RESTRAINT'S PERFORMANCE IN THE EVENT OF A CRASH AND AN INCREASED RISK OF INJURY OR DEATH TO THE CHILD SEATED IN THE RESTRAINT.
Remedy: DEALERS WILL CUT A HOLE INTO THE BACK PANEL TRIM COVER TO ALLOW ACCESS TO THE TOP TETHER ANCHOR FOR THE FRONT CENTER SEAT POSITION AND WILL PROVIDE SUPPLEMENTAL INFORMATION AS TO USE IN THE OWNER'S MANUAL. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR VISIT GM'S WEBSITE AT WWW.GMOWNERCENTER.COM.
09V310000 · Exterior Lighting:brake Lights:switch
Jul 29, 2009
GM IS RECALLING 185,903 MODEL YEAR 2004-2009 COLORADO, GMC MODEL YEAR 2009-2004 CANYON, MODEL YEAR 2006 I-280, I-350, MODEL YEAR 2007-2008 I-290, AND I-370, PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALABAMA, ARIZONA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, PUERTO RICO, SOUTH CAROLINA, TEXAS, U.S. VIRGIN ISLANDS AND UTAH. SOME OF THESE VEHICLES HAVE A BRAKE LAMP SWITCH THAT MAY NOT WORK AS DESIGNED DUE TO CONTAMINATION IN THE SWITCH.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE SIMULTANEOUS LOSS OF ALL BRAKE LAMPS OR CAUSE ALL OF THE BRAKE LAMPS TO STAY ON CONTINUOUSLY. BOTH OF THESE CONDITIONS COULD FAIL TO WARN OTHERS OF THE DRIVER'S INTENTIONS AND COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS AS SPECIFIED IN THE RECALL BULLETIN FREE OF CHARGE. GM ANTICIPATES THAT PARTS WILL BE AVAILABLE BY JUNE 2010. A SPECIAL COVERAGE FOR VEHICLES REGISTERED IN ALL OTHER STATES WILL BE IMPLEMENTED IN THE SAME TIME FRAME. IN THE INTERIM, OWNERS WHO EXPERIENCE THE FAILURE CAN OBTAIN A FREE REPAIR, HOWEVER THEY WILL BE REQUIRED TO RETURN WHEN THE NEW DESIGN PART BECOMES AVAILABLE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.
06V139000 · Exterior Lighting:brake Lights:switch
Apr 27, 2006
CERTAIN PICKUP TRUCKS MAY EXPERIENCE THE PERMANENT LOSS OF BRAKE LAMP FUNCTION OR BRAKE LAMPS THAT ARE ILLUMINATED AT ALL TIMES. THE CENTER HIGH-MOUNTED STOP LAMP (CHMSL) IS AFFECTED IN BOTH INSTANCES. ALSO, IF EQUIPPED, THE CRUISE CONTROL WILL BECOME INOPERATIVE. ANY TRAILER BRAKE LAMPS WHICH ARE CONNECTED TO THE VEHICLE'S BRAKE LAMP WIRING WILL MIMIC THE VEHICLE'S BRAKE LAMPS WHEN EITHER CONDITION OCCURS.
Consequence & remedy
Consequence: A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY. THE RECALL BEGAN ON DECEMBER 5, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463 OR ISUZU AT 1-800-255-6727.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ09001 · Brake Lamp Switch Malfunction
Opened Feb 25, 2009 · Closed Jul 30, 2009
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
Exterior Lighting
ON JULY 28,2009, GM INITIATED A REGIONAL RECALL CAMPAIGN ON CERTAIN MODEL YEAR (MY) 2004-2009 CHEVROLET COLORADO AND GMC CANYON VEHICLES AND MY2006-2008 ISUZU I-SERIES VEHICLES.THE STATES AND U.S. TERRITORIES INVOLVED ARE AL, AZ, FL, GA, HI, LA, MS, NV, NM, PR, SC, TX, VI AND UT.A TOTAL OF 185,903 VEHICLES WILL BE RECALLED WITH 92,272 VEHICLES WITHIN THE SCOPE OF THIS INVESTIGATION.IN ADDITION, A SPECIAL COVERAGE/EXTENDED WARRANTY PROGRAM WILL BE INITIATED FORVEHICLES REGISTERED IN ALL OTHER STATES. GM DETERMINED THAT BRAKE LAMP SWITCH FAILURES ARE MORE LIKELY TO OCCUR IN VEHICLES IN WHICH CUSTOMERS USED INTERIOR CLEANERS CONTAINING SILICON AND THAT RESIDE IN HOT GEOGRAPHICAL LOCATIONS.BRAKE LAMP SWITCH CONTAMINATION FAILURE CAN CAUSE LOSS OF THE BRAKE LAMPS OR THE BRAKE LAMPS TO STAY ON CONTINUOUSLY, INCREASING THE RISK OF REAR-END CRASHES.GM HAS REPORTED NO CRASHES OR INJURIES DUE TO THE FAILURE OF THE BRAKE LAMP SWITCH.ODI INITIALLY REPORTED ONE CRASH INCIDENT, BUT LATER DOWNGRADED THE REPORT DUE TO THE ABSENCE OF ACTUAL PROPERTY DAMAGE OR COST INCURRED WHEN THE VEHICLE WAS LIGHTLY TAPPED FROM BEHIND AT LOW SPEED.THIS INVESTIGATION IS CLOSED (SEE RECALL CAMPAIGN 09V0310).
PE05065 · Brake Lamp Switch Failure
Opened Dec 2, 2005 · Closed May 1, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
BY LETTER DATED APRIL 26, 2006, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO. 06V139) INVOLVING CERTAIN MODEL YEAR (MY) 2004-06 CHEVROLET COLORADO, GMC CANYON AND 2006 MY ISUZU I280/I350 VEHICLES.GM'S RECALL COVERS 404,733 VEHICLES.GM REPORTS THAT LOSS OF BRAKE LAMP ILLUMINATION WAS CAUSED BY INSUFFICIENT PLATING ON THE STATIONARY CONTACT IN THE BRAKE LAMP SWITCH.GM WILL REPLACE THE BRAKE LAMP SWITCH ASSEMBLY ON ALL INVOLVED VEHICLES WITH THE NEW SWITCH THAT HAS THE INCREASED PLATING ON THE STATIONARY CONTACT.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.