2004 Chevrolet Colorado

DRIVER/OWNER TRAVELLED INTO A PARKING LOT, PARKED WITHOUT INCIDENT AND TURNED THE IGNITION COMPLETELY OFF. WITHIN SECONDS, THE DRIVER STEPPED OUT OF THE VEHICLE, THEN LEANED OVER TO RETRIEVE THE KEY WHICH WAS STILL IN THE IGNITION. AS THE DRIVER REMOVED KEY FROM IGNITION, WITHOUT WARNING, THE DRIVER'S SIDE AIRBAG DEPLOYED, STRIKING HIM IN THE LEFT CHEEK. THE DRIVER SUSTAINED FACIAL BURNS. PARAMEDICS AND FIRE RESPONDED. LATER, HE WAS TAKEN TO AN EMERGENCY ROOM. PRIOR TO THIS INCIDENT, THE VEHICLE OPERATED PROPERLY AND RECEIVED ROUTINE MAINTENANCE WITH DEALER.

SOMETIMES, ESPECIALLY IN WINTER MONTHS WHEN IT IS COLD OUTSIDE THE DOOR LOCKS WILL STOP WORKING. FOR EXAMPLE, USING THE REMOTE TO LOCK THE DOORS, THEY WON'T LOCK AND THE SECURITY ALARM (HORNS) WILL GO OFF IF YOU OPEN THE CLOSED DOOR BECAUSE THE COMPUTER SYSTEM THINKS THE DOOR IS LOCKED SENDING SECURITY SYSTEM INTO TAMPER MODE. ALSO WHEN SHIFTING TO DRIVE, THE DOORS WILL NOT LOCK AS THEY NORMALLY DO WHEN VEHICLE IS SHIFTED OUT OF PARK. ALSO SOME LIGHTS MAY NOT ILLUMINATE SUCH AS THE LEFT FRONT SIDE MARKER LAMP/TURN SIGNAL. EVENTUALLY THE ELECTRICAL SYSTEM WILL RESET AND THE DOOR LOCKS WILL WORK NORMALLY. IT ISN'T JUST DURING COLD WEATHER THAT THIS HAPPENS BUT IT SEEMS TO HAPPEN MORE OFTEN DURING COLDER WEATHER. GM DEALER REPLACED A COUPLE OF SWITCHES WHEN I BROUGHT MY TRUCK IN WHILE UNDER WARRANTY BUT HAVEN'T BROUGHT IT IN SINCE THE EXPIRATION OF MY WARRANTY AND IT STILL DOES IT ON CERTAIN OCCASIONS. *TR

2004 CHEVY COLORADO ABS FAILURE INDICATES ON DASH FOR NO REASON ON DRY PAVEMENT AT ANY SPEED WHEN NOT APPLYING BRAKES, GOES OFF ONCE TRUCK IS SHUT OFF. COMES BACK ON PERIODICALLY WHILE DRIVING ON DRY PAVEMENT. ABS SEEMS TO ENGAGE AT SLOW SPEEDS FOR NO REASON ON DRY PAVEMENT,BRAKE PEDAL STARTS TO PULSATE AND TRUCK DOES NOT SEEM TO WANT TO STOP. *TR

AFTER DRIVING VEHILCE A SHORT DISTANCE FROM THE HOUSE, THE ABS SYSTEM ACTIVATED AS IF ON A SLICK SURFACE AS I BRAKED TO STOP AT STOP SIGN. I EVENTUALLY HAD TO PRESS EXTREMELY HARD ON BRAKE PEDAL TO STOP MY VEHICLE BEFORE STOP SIGN. THE TRUCKS ABS FAULT LIGHT IMMEDIATELY SHOWED UP ON THE DASH ALONG WITH THE ABS LIGHT. DURING SHORT DRIVE TO WORK, THE ABS FAULT MESSAGE CONTINUED TO SHOW. AFTER RESTARTING THE TRUCK AFTER WORK, THE SAME PROCESS OF ABS ACTIVATING AS IF ON SLICK SURFACE AND WARNING MESSAGE SHOWED.

THE HVAC BLOWER MOTOR RESISTOR ASSEMBLY MELTED ON THE VEHICLE. THE CURRENT PASSING THROUGH THE UNIT IS SUFFICIENT TO MELT THE CONNECTOR AND DEGRADE THE WIRES TO BRITTLE. I BELIEVE THIS IS A POSSIBLE FIRE HAZARD. A NUMBER OF CO-OWNERS HAVE FOUND THE SAME DEFECT. THE CONNECTION IN QUESTION TERMINAL (C) GOES TO A GROUND DISTRIBUTION BLOCK THAT MIGHT NOT BE SUFFICIENT.

TL*THE CONTACT OWNS A 2004 CHEVROLET COLORADO EQUIPPED WITH COOPER COBRA G/T RADIAL TIRES, TIRE SIZE P255/70/15. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH AND THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE THEY INFORMED THAT THE REAR PASSENGER SIDE TIRE TREAD BELT EXHIBITED BUBBLING. THE TIRE WAS REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 06T016000 (TIRES:TREAD/BELT). THE DOT NUMBER WAS NOT INCLUDED IN THE RECALL. RECENTLY, THE FRONT PASSENGER SIDE TIRE TREAD EXHIBITED A SIMILAR DEFECT. THE CONTACT WAS IN THE PROCESS OF REPLACING THE TIRE. THE FAILURE MILEAGE WAS 69,000.

2004 CHEVY COLORADO ZQ8 HVAC BLOWER HARNESS AND RESISTOR. PART WAS REPLACED AT APPROXIMATELY 15,000 MILES UNDER MFG WARRANTY WITH IDENTICAL PARTS. AGAIN OUT OF WARRANTY WITH NO NEW REVISED PARTS AT 45,000 AND NOW AGAIN AT 77,000 MILES. HARNESS AND RESISTOR FAILURE HAD GOTTEN SO HOT EACH TIME THAT IT HAD MELTED THE HARNESS TO THE RESISTOR. POSSIBLE FIRE HAZARD, WITH SEVERELY BURNT WIRES. LOOKING IT UP ON FORUMS THIS IS COMMON ON ALL GM MODEL COLORADO AND CANYON TRUCKS, GM KNOWS OF THE PROBLEM, BUT REFUSES TO OFFER A REVISED PART OR REAL SOLUTION. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET COLORADO. WHILE DRIVING 35 MPH, THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT THE REAR BRAKE LIGHTS WERE INOPERABLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE BRAKE LIGHT SWITCH WAS REPLACED. PRIOR TO THE FAILURE, THE VEHICLE HAD BEEN REPAIRED AT THE DEALER FOR RECALL 06V139000 (EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 59,000.