NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,649 reports95,000 miles · Mar 11, 2010
SteeringCrashInjury
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING AT SPEEDS OF 60 MPH, THE VEHICLE BEGAN VEERING TO THE LEFT, WITHOUT WARNING. THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO STEER IN A STRAIGHT DIRECTION WHICH RESULTED IN A CRASH INTO THE MEDIAN AND A SMALL DITCH. THE VEHICLE BEGAN SPINNING OUT OF …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING AT SPEEDS OF 60 MPH, THE VEHICLE BEGAN VEERING TO THE LEFT, WITHOUT WARNING. THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS UNABLE TO STEER IN A STRAIGHT DIRECTION WHICH RESULTED IN A CRASH INTO THE MEDIAN AND A SMALL DITCH. THE VEHICLE BEGAN SPINNING OUT OF CONTROL, AND ROLLED OVER AT LEAST THREE TIMES. THE DRIVER SUFFERED VERY MINOR INJURIES. HOWEVER, THE PASSENGER SUFFERED SEVERAL MAJOR INJURIES. THE POLICE ARRIVED TO THE SCENE AND THE PASSENGER WAS AIR LIFTED FROM THE SCENE. THE PASSENGER'S PELVIC BONE WAS BROKE IN THREE PLACES, A FRACTURED VERTEBRAE AND TAIL BONE, RIGHT HIP WAS BROKEN, LEFT HIP INJURY, AND ALL FIVE RIBS ON THE RIGHT SIDE WERE BROKEN. THE VEHICLE WAS COMPLETELY DESTROYED. THE FAILURE MILEAGE WAS 95,000.
NHTSA ODI #10319032
70,000 miles · Mar 11, 2010
Electrical SystemPower TrainSteering
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WITH A LOSS OF POWER STEERING. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION WITH CAUTION. ADDITIONALLY, THE TRANSMISSION SLIPPED AND THE SPEEDOMETER FLUCTUATED AND DISPLAYED INACCURATE READINGS. THE MANUFACTURER WAS NOTIFIED; THE VEHICLE W…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH WITH A LOSS OF POWER STEERING. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION WITH CAUTION. ADDITIONALLY, THE TRANSMISSION SLIPPED AND THE SPEEDOMETER FLUCTUATED AND DISPLAYED INACCURATE READINGS. THE MANUFACTURER WAS NOTIFIED; THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE VIN NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 70,000. THE CURRENT MILEAGE WAS 72,000.
NHTSA ODI #10318953
40,000 miles · Mar 11, 2010
Latches/locks/linkagesSteering
THE POWER STEERING ON MY 2005 CHEVY COBALT WENT OUT WHILE I WAS DRIVING, LUCKILY IT DIDN'T RESULT IN AN ACCIDENT. I COULD HAVE JUST AS EASILY BEEN IN AN ACCIDENT DUE TO THE FACT I COULDN'T TURN MY WHEEL AT ALL. I TOOK THE COBALT TO A SHOP, AND IT TURNS OUT IT WAS THE MOTOR. APPARENTLY THIS HAPPENS TO A TON OF CHEVY COBALTS ALL T…
Read full complaint
THE POWER STEERING ON MY 2005 CHEVY COBALT WENT OUT WHILE I WAS DRIVING, LUCKILY IT DIDN'T RESULT IN AN ACCIDENT. I COULD HAVE JUST AS EASILY BEEN IN AN ACCIDENT DUE TO THE FACT I COULDN'T TURN MY WHEEL AT ALL. I TOOK THE COBALT TO A SHOP, AND IT TURNS OUT IT WAS THE MOTOR. APPARENTLY THIS HAPPENS TO A TON OF CHEVY COBALTS ALL THE TIME. THIS IS SOOO DANGEROUS! ALSO, OCCASIONALLY MY DRIVER SIDE DOOR WON'T OPEN FROM THE INSIDE OR OUTSIDE. THIS COULD BE A HUGE SAFETY RISK IF I NEEDED TO GET OUT OF MY VEHICLE IN A HURRY. *TR
NHTSA ODI #10318952
57,500 miles · Mar 11, 2010
Steering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE TRAVELING AT APPROXIMATELY 20 MPH, THE DRIVER NOTICED THE POWER STEERING INDICATOR LIGHT ILLUMINATED ON THE WARNING PANEL IMMEDIATELY FOLLOWED BY A LOSS OF POWER STEERING ASSIST. THE DRIVER SHUT OFF THE ENGINE AND UPON RESTARTING, THE POWER STEERING ASSIST WOULD RESET ITSELF. W…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE TRAVELING AT APPROXIMATELY 20 MPH, THE DRIVER NOTICED THE POWER STEERING INDICATOR LIGHT ILLUMINATED ON THE WARNING PANEL IMMEDIATELY FOLLOWED BY A LOSS OF POWER STEERING ASSIST. THE DRIVER SHUT OFF THE ENGINE AND UPON RESTARTING, THE POWER STEERING ASSIST WOULD RESET ITSELF. WITHIN MINUTES, THE FAILURE WOULD OCCUR AGAIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED. THE DEALER VERIFIED THE POWER STEERING AS WELL AS ANOTHER UNKNOWN PART HAD FAILED. REPAIRS WERE MADE TO THE VEHICLE AT THE OWNERS EXPENSE. THERE WERE NO RECALLS ON THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 57,500 AND THE CURRENT WAS 58,000.
NHTSA ODI #10318928
15,000 miles · Mar 11, 2010
Electrical System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS, THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER APPLIED EXCESSIVE FORCE TO THE STEERING WHEEL AND WAS ABLE TO PULL OVER TO THE SID…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS, THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER APPLIED EXCESSIVE FORCE TO THE STEERING WHEEL AND WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF AND AFTER 20 MINUTES, THE VEHICLE RESTARTED AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRENCE WAS CONSISTENT WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON FOUR SEPARATE OCCASIONS FOR THE IDENTICAL FAILURE WITH REPLACEMENT OF THE STEERING COLUMN AND MOTOR. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM); HOWEVER HIS VIN WAS EXCLUDED FROM THE RECALL. THE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS UNKNOWN.
NHTSA ODI #10318801
78,850 miles · Mar 10, 2010
Steering
I HAD LEFT MY DRIVEWAY AND STARTED HEADING DOWN THE ROAD WHEN MY POWERSTEERING SHUTDOWN. TURN THE CAR OFF AND START IT AGAIN AND I HAVE POWERSTEERING FOR A SHORT TIME. NOW IT DOES IT AT LEAST ONCE A DAY. WAITING FOR GM TO COME UP WITH A FIX BEFORE I SEE A MECHANIC. HARD TO STEER BUT STILL DRIVABLE. *TR
NHTSA ODI #10318743
40,000 miles · Mar 10, 2010
Steering
POWER STEERING FAILURE AT RANDOM. I BOUGHT A 2005 CHEVY COBALT BRAND NEW IN 2005. AFTER DRIVING 40,000 MILES I WOULD GET A POWER STEERING FAILURE. WHEN I FIRST TURN THE CAR ON I HAVE POWER STEERING, BUT AFTER A RANDOM MOMENT OF TIME IT CUTS OUT AND THE LIGHT ON THE DASH COMES ON. IT WILL GO OUT IN MID TURN OR WHILE GOING STR…
Read full complaint
POWER STEERING FAILURE AT RANDOM. I BOUGHT A 2005 CHEVY COBALT BRAND NEW IN 2005. AFTER DRIVING 40,000 MILES I WOULD GET A POWER STEERING FAILURE. WHEN I FIRST TURN THE CAR ON I HAVE POWER STEERING, BUT AFTER A RANDOM MOMENT OF TIME IT CUTS OUT AND THE LIGHT ON THE DASH COMES ON. IT WILL GO OUT IN MID TURN OR WHILE GOING STRAIGHT & BOTH FORWARD AND IN REVERSE. MOST REPORTS I CAN FIND ABOUT THE PROBLEM SAY IT WILL COST ABOUT $2000 TO FIX AND THE PROBLEM RECURS. THE ONLY WAY TO GET A PART TO FIX IT IS TO TAKE IT TO THE DEALERSHIP AND SOME DEALERSHIPS ARE SAYING ITS THE STEERING COLUMN WHILE OTHERS SAY ITS A MOTOR. I THINK ITS A SCAM FROM GM TO MAKE A PART THAT GOES OUT AND CHARGE AN ARM AND A LEG TO FIX. THE FAILURE HAPPENS DAILY NOW. ITS DIFFICULT TO TURN THE STEERING WHEEL. IT IS UNSAFE TO TURN INTO BUSY TRAFFIC IN THE CITY AND DRIVING AROUND MOUNTAINS. IT WAS THE CHEAPEST NEW CAR I COULD FIND AT THE TIME BECAUSE I'M POOR, SO FORKING OVER $2000.00 FOR A PART THAT WILL GO OUT AGAIN IN ANOTHER 40,000 MILES IS NEVER GOING TO HAPPEN. EVEN THOUGH THERE IS A LIGHT ON THE DASH TO INDICATE A POWER STEERING FAILURE, IT DOES NOT SHOW UP ON DIAGNOSTICS. IT IS AN ELECTRICAL ISSUE AND NOT MECHANICAL, SO ITS NOT UNDER WARRANTY. I HAVE NOT YET BEEN IN A CRASH, BUT I HAVE COME CLOSE MANY TIMES. MANY OWNERS I HAVE SPOKE WITH HAVE THIS PROBLEM, AND HAVE CRASHED OR COME CLOSE TO CRASHING ON MANY OCCASIONS. *TR
NHTSA ODI #10318352
35,000 miles · Mar 10, 2010
Steering
I BOUGHT A USED 2005 CHEVY COBALT ABOUT 2 YEARS AGO. A FEW MONTHS AFTER THE PURCHASE THE POWER STEERING STARTED TO FAIL AT SEEMINGLY RANDOM INTERVALS, BUT ON AN ALL TO REGULAR BASIS. I DON'T BELIEVE I HAD ANYTHING TO DO WITH THE PROBLEM AS I WAS SIMPLY DRIVING DOWN THE ROAD WHEN IT CHOSE TO FIRST FAIL. IT OCCURS NUMEROUS TIMES D…
Read full complaint
I BOUGHT A USED 2005 CHEVY COBALT ABOUT 2 YEARS AGO. A FEW MONTHS AFTER THE PURCHASE THE POWER STEERING STARTED TO FAIL AT SEEMINGLY RANDOM INTERVALS, BUT ON AN ALL TO REGULAR BASIS. I DON'T BELIEVE I HAD ANYTHING TO DO WITH THE PROBLEM AS I WAS SIMPLY DRIVING DOWN THE ROAD WHEN IT CHOSE TO FIRST FAIL. IT OCCURS NUMEROUS TIMES DAILY AND HAS NEARLY CAUSED ME TO CRASH SEVERAL TIMES (ESPECIALLY WHEN IT FAILS MID-TURN). NOTHING HAS BEEN DONE TO CORRECT SEEING AS THEY TOLD ME TO FIX THE POWER STEERING I WOULD HAVE TO REPLACE THE ENTIRE STEERING COLUMN COSTING ME UP TO 2500 DOLLARS. SOMETHING THAT I JUST CANNOT AFFORD TO PAY FOR. *TR
NHTSA ODI #10318348
38,000 miles · Mar 9, 2010
SteeringCrashInjury
VEHICLE WOULD NOT TURN RIGHT STEERING ISSUE. AS A RESULT THE CAR CONTINUED STRAIGHT, OVER MEDIAN, OVER 2 CURBS BEFORE DRIVER COULD STOP VEHICLE JUST SHY OF GAS METER. FILED COMPLAINT WITH GM > THE DEALERSHIP WHERE I PURCHASED THE VEHICLE INFORMED ME OF A RECALL ON GM COBALT AND THE PARTS TO FIX PROBLEM WILL NOT BE AVAILABLE…
Read full complaint
VEHICLE WOULD NOT TURN RIGHT STEERING ISSUE. AS A RESULT THE CAR CONTINUED STRAIGHT, OVER MEDIAN, OVER 2 CURBS BEFORE DRIVER COULD STOP VEHICLE JUST SHY OF GAS METER. FILED COMPLAINT WITH GM > THE DEALERSHIP WHERE I PURCHASED THE VEHICLE INFORMED ME OF A RECALL ON GM COBALT AND THE PARTS TO FIX PROBLEM WILL NOT BE AVAILABLE. AND IT APPEARS THAT IS WHAT HAPPENED WHY THE VEHICLE WOULD NOT TURN. AND MY VEHICLE CANNOT BE REPAIRED. *TR
NHTSA ODI #10318094
57,155 miles · Mar 9, 2010
Steering
WE HAVE A 2005 CHEVY COBALT. ISSUE 1: THE POWER STEERING HAS FAILED INTERMITTENTLY WHILE DRIVING. THE POWER STEERING HAS FAILED COMPLETELY FOR THE LAST 4 MONTHS BUT, NOW STARTING TO WORK INTERMITTENTLY AGAIN. WE CALLED SEVERAL DEALERS BACK IN MAY 2009 ABOUT THIS ISSUE. SOME DEALERS WERE ARE VERY AWARE OF THE PROBLEM. THE DEALERS…
Read full complaint
WE HAVE A 2005 CHEVY COBALT. ISSUE 1: THE POWER STEERING HAS FAILED INTERMITTENTLY WHILE DRIVING. THE POWER STEERING HAS FAILED COMPLETELY FOR THE LAST 4 MONTHS BUT, NOW STARTING TO WORK INTERMITTENTLY AGAIN. WE CALLED SEVERAL DEALERS BACK IN MAY 2009 ABOUT THIS ISSUE. SOME DEALERS WERE ARE VERY AWARE OF THE PROBLEM. THE DEALERS TOLD ME THE ENTIRE STEERING COLUMN HAS TO BE REPLACED BECAUSE IT IS A ELECTRONIC FAILURE. THE POWER STEERING IS CONTROLLED BY AN ELECTRIC MOTOR INSTEAD OF HYDRAULICS THAT ARE FOUND IN MOST CARS. THE COST TO REPLACE THE STEERING COLUMN IS $1,200+. I WOULD LIKE THIS ISSUE FIXED BECAUSE IT HAS ALMOST CAUSED SEVERAL ACCIDENTS WHEN IT INITIALLY STARTED. WE WANT TO SELL THE VEHICLE BUT, WE DO NOT WANT TO PASS THIS LEMON ON TO ANOTHER CONSUMER WHO MAY NOT BE AWARE OF THESE ISSUES. ISSUE 2: THE WHEEL WELL COVERS AND INTERIOR MOLDING ARE ATTACHED TO THE VEHICLE WITH CHEAP PLASTIC GROMETS THAT FAIL FROM FATIGUE AND POOR ENGINEERING. THE WHEEL WELL COVERS HAVE COME OFF WHILE DRIVING. I REATTACHED A PARTIALLY ATTACHED WHEEL WELL COVER WITH SHEET METAL SCREWS AND REMOVED THE REST. THESE ITEMS ARE ACCIDENTS WAITING TO HAPPEN. I AM DISAPPOINTED IN GM'S QUALITY AND ENGINEERING PRACTICES. *TR
NHTSA ODI #10317955
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration