NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,649 reports19,860 miles · Oct 17, 2007
Service Brakes, HydraulicCrash
BRAKE FAILURE/BRAKE PEDAL WENT DOWN WHEN APPLIED AND VEHICLE ACCELERATED AT A HIGH RATE OF SPEED,TRAVELED 20-25 FEET STRUCK TRUCK IN FRONT OF ME CAUSING OVER $4,000 IN DAMAGE TO MY 2005 CHEVY COBALT SINCE THE JUNE 13TH 2007 ACCIDENT THE BRAKES FAILED 2 MORE TIMES THE LAST TIME THE BRAKE PEDAL COLLAPSED TO THE FLOOR WITH NO BRAKE…
Read full complaint
BRAKE FAILURE/BRAKE PEDAL WENT DOWN WHEN APPLIED AND VEHICLE ACCELERATED AT A HIGH RATE OF SPEED,TRAVELED 20-25 FEET STRUCK TRUCK IN FRONT OF ME CAUSING OVER $4,000 IN DAMAGE TO MY 2005 CHEVY COBALT SINCE THE JUNE 13TH 2007 ACCIDENT THE BRAKES FAILED 2 MORE TIMES THE LAST TIME THE BRAKE PEDAL COLLAPSED TO THE FLOOR WITH NO BRAKES(BUSHING &CLIP MISSING FROM BRAKES, I THINK THIS WAS DONE AT THE FACTORY). I HAD TO STOP IT USING THE EMERGENCY BRAKE. I REFUSED TO DRIVE IT AGAIN. MY WIFE HAD IT DO THIS TO HER, WITH THE BRAKES FAILING AND ACCELERATING AT A FAST PACE, LUCKILY NO CARS WERE NEAR HER AT THE TIME,BECAUSE I TRADED THE COBALT GENERAL MOTORS REFUSES TO DO ANYTHING ABOUT THE PROBLEM REFERENCE NUMBER 71-562139648 TALKED TO SEVERAL PEOPLE ONE WAS JAKE EXT 22795. *TR
NHTSA ODI #10205988
3,000 miles · Oct 3, 2007
Engine And Engine Cooling
ENGINE LIGHT TURNED ON AT 3,000 MILES NOW THE CAR HAS 45K AND ENGINE LIGHT IS STILL ON CAR HAS BEEN TO THE DEALER NUMEROUS TIMES AND THEY CAN;T FIND THE PROBLEM. THE LIGHT BANK ONE LEAN CODE. THE DEALERS STILL CAN'T FIND THE PROBLEM. CAR RUNS ROUGH AND IT MAY RESULT IN ENGINE DAMAGE OR OTHER PROBLEMS OR SAFETY PROBLEMS IF SITUA…
Read full complaint
ENGINE LIGHT TURNED ON AT 3,000 MILES NOW THE CAR HAS 45K AND ENGINE LIGHT IS STILL ON CAR HAS BEEN TO THE DEALER NUMEROUS TIMES AND THEY CAN;T FIND THE PROBLEM. THE LIGHT BANK ONE LEAN CODE. THE DEALERS STILL CAN'T FIND THE PROBLEM. CAR RUNS ROUGH AND IT MAY RESULT IN ENGINE DAMAGE OR OTHER PROBLEMS OR SAFETY PROBLEMS IF SITUATION PERSISTS. TO MUCH AIR NOT ENOUGH FUEL. *JB
NHTSA ODI #10204794
41,500 miles · Sep 26, 2007
Steering
ELECTRONIC POWER STEERING WENT OUT WITH OUT WARNING. IT'S A GOOD THING THAT I WASN'T MAKING A TURN AT THIS IMPARTIAL MOMENT BECAUSE IF I WOULD HAVE BEEN I WOULD HAVE CRASHED INTO SOMETHING. IF I TURN THE CAR OFF AND THEN BACK ON AGAIN IT STARTS TO WORK BUT ONLY FOR A SHORT PERIOD OF TIME. IT SEEMS THAT THE COOLER IT IS OUTSID…
Read full complaint
ELECTRONIC POWER STEERING WENT OUT WITH OUT WARNING. IT'S A GOOD THING THAT I WASN'T MAKING A TURN AT THIS IMPARTIAL MOMENT BECAUSE IF I WOULD HAVE BEEN I WOULD HAVE CRASHED INTO SOMETHING. IF I TURN THE CAR OFF AND THEN BACK ON AGAIN IT STARTS TO WORK BUT ONLY FOR A SHORT PERIOD OF TIME. IT SEEMS THAT THE COOLER IT IS OUTSIDE THE LONGER THAT THE POWER STEERING WORKS, HOWEVER IT DOES CONTINUE TO TURN OFF. I BELIEVE THAT THE SYSTEM THINKS THAT ITS OVER HEATING AND IS LOCKING UP THE POWER STEERING. I HAVE FOUND SEVERAL OTHER PEOPLE WITH THIS EXACT SAME PROBLEM, AND I MEAN EXACT. *TR
NHTSA ODI #10204225
23,000 miles · Sep 26, 2007
SteeringCrash
I WAS DRIVING OUR COBALT 2005 AT A SPEED OF ABOUT 25-30 MPH WHEN THE STEERING FAILED WITHOUT ANY WARNING ON A SUBURBAN STREET. THE STEERING WHEEL WAS COMPLETELY LOOSE AND DID NOT CONTROL THE CAR. THE VEHICLE SLID INTO A CURB, JUMPED IT AND ENDED UP ON SOMEONE'S LAWN. THERE WAS SEVERE DAMAGE TO CAR'S UNDERSIDE. WHEELS AND TIRES …
Read full complaint
I WAS DRIVING OUR COBALT 2005 AT A SPEED OF ABOUT 25-30 MPH WHEN THE STEERING FAILED WITHOUT ANY WARNING ON A SUBURBAN STREET. THE STEERING WHEEL WAS COMPLETELY LOOSE AND DID NOT CONTROL THE CAR. THE VEHICLE SLID INTO A CURB, JUMPED IT AND ENDED UP ON SOMEONE'S LAWN. THERE WAS SEVERE DAMAGE TO CAR'S UNDERSIDE. WHEELS AND TIRES (OVER $ 5,700). I WAS TOLD THAT THE "STEERING KNUCKLE" BROKE (WHY???). CAR WAS DECLARED "REPAIRABLE" BUT EVERYTHING IS IN LIMBO BECAUSE OF CONCERNS ABOUT THE SAFETY OF THE VEHICLE. I REQUESTED AN INVESTIGATION BY CHEVROLET IN DETROIT . NO REPAIRS WILL BE DONE UNTIL CHEVROLET HAS FINISHED THE INVESTIGATION, WHICH IS TO BEGIN 2-6 DAYS AFTER THE REQUEST. *TR
NHTSA ODI #10204219
17,000 miles · Sep 25, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING BETWEEN 40 AND 50 MPH, THE ENGINE STALLED. ALL THE WARNING INDICATOR LIGHTS FLASHED ON THE INSTRUMENT PANEL. THE VEHICLE WAS ABLE TO BE RESTARTED AND THE DEALER REPLACED THE CAM SHAFT SENSOR. THE CURRENT AND FAILURE MILEAGES WERE 17,000.
NHTSA ODI #10204042
72,000 miles · Sep 18, 2007
Steering
POWER STEERING MOTOR FAILURE, NEARLY CAUSED A CRASH BECAUSE I COULD NOT TURN THE VEHICLE. *TR
NHTSA ODI #10203368
Mileage unknown · Sep 7, 2007
Electrical SystemStructureVisibility
I HAVE A 2005 CHEVY COBALT WITH LESS THAT 30K MILES I WAS DRIVING HOME FROM WORK WHEN MY CAR JUST SHUT OFF NO HAZARD LIGHTS TURN SIGNALS BRAKES STEERING NO POWER AT ALL I COULD HAVE BEEN KILLED IN ALL TRAFFIC BECAUSE THERE WAS NO WAY OF SIGNALING. IT TOOK THREE TRIES TO GET IT STARTED AGAIN THERE WAS NO WARNING CHECK ENGIN…
Read full complaint
I HAVE A 2005 CHEVY COBALT WITH LESS THAT 30K MILES I WAS DRIVING HOME FROM WORK WHEN MY CAR JUST SHUT OFF NO HAZARD LIGHTS TURN SIGNALS BRAKES STEERING NO POWER AT ALL I COULD HAVE BEEN KILLED IN ALL TRAFFIC BECAUSE THERE WAS NO WAY OF SIGNALING. IT TOOK THREE TRIES TO GET IT STARTED AGAIN THERE WAS NO WARNING CHECK ENGINE LIGHT NEVER CAME ON I IMMEDIATELY TOOK IT TO THE DEALERSHIP BECAUSE THIS WAS THE SECOND TIME IT HAS HAPPENED TO ME I HAD THIS PROBLEM LAST YEAR ALSO GM NEVER HAD A RECALL THEY JUST PUT A PLASTIC PIECE AROUND THE IGNITION AND SAID IT WAS FIXED I TOLD MY DEALER THAT THERE WAS A BULLETIN OUT ABOUT THIS AND I ASKED THEM WHY THERE WAS NO RECALL TO REPLACE THE IGNITION SWITCH AFTER THIS SECOND INCIDENT GM WANTED TO PUT A MAGNETIC DEVICE IN TO KEEP THE KEY FROM MOVING IN THE IGNITION ANY THEY PLACED A PIECE OF PLASTIC IN MY ACTUAL KEY I CALLED GM AND PLACED A FORMAL COMPLAINT BECAUSE THIS IS A SERIOUS SAFETY CONCERN PEOPLE ARE GOING TO BE HURT OR KILLED IF THEY GET INVOLVED IN A REAR END COLLISION OR HAVE NO WAY OF PULLING OFF ROADWAY SPOKE TO MY SERVICE MANAGER AND DEALERSHIP REPLACED IGNITION SWITCH THERE HAS NEVER BEEN A RECALL ON THIS I DO NOT TRUST THAT IT WILL NOT HAPPEN AGAIN I AM AFRAID TO DRIVE THIS CAR THIS IS NOT THE ONLY PROBLEM I HAVE HAD WITH THIS CAR THE FAN BLOWER THE SHIFT ON THE FLOOR THE SUNROOF SWITCH KEEPS FALLING OUT OF THE ROOF THE WINDOW MOTORS HAVE BURNED OUT MY INTERIOR PAINT AND DOOR HANDLES WERE PEELING AFTER THE FIRST YEAR I DON'T BLAME MY SERVICE DEPARTMENT BECAUSE THEY HAVE FIXED THE CAR THE WAY GM TOLD THEM TO I FEEL VERY UNSAFE IN THIS CAR WHY SHOULD I HAVE TO WAIT UNTIL HE IGNITION SHUTS OFF A THIRD TIME THIS COULD BE MY LAST IF WHAT IS GM DOING ABOUT THIS? ARE THEY GOING TO DO A RECALL? WHAT ELSE HAS TO HAPPEN TO ME BEFORE THEY TAKE THIS SERIOUSLY? I AM EXTREMELY DISSATISFIED WITH THIS CAR AND I DO NOT WANT IT ANYMORE. *TR * 12/12/07 *BF THE DEALER STATED DRIVER SIDE REAR POWER WINDOW WAS INOPERABLE. UPDATED 12/12/07 *TR
NHTSA ODI #10202169
26,996 miles · Sep 3, 2007
Electrical System
I HAD BEEN DRIVING MY 2005 CHEVY COBALT COUPE YESTERDAY FOR ABOUT AN HOUR AND A HALF WHEN IT JUST SUDDENLY SHUT OFF. I HAD THE CRUISE CONTROL ON AND WAS GOING ABOUT 80MPH AND I HAVE ABOUT 27,000 MILES ON THE CAR. I LOST POWER STEERING AND HAD TO COAST OVER TO THE SIDE OF THE ROAD. NO WARNLING LIGHTS CAME ON BEFORE HAND. AFTER I …
Read full complaint
I HAD BEEN DRIVING MY 2005 CHEVY COBALT COUPE YESTERDAY FOR ABOUT AN HOUR AND A HALF WHEN IT JUST SUDDENLY SHUT OFF. I HAD THE CRUISE CONTROL ON AND WAS GOING ABOUT 80MPH AND I HAVE ABOUT 27,000 MILES ON THE CAR. I LOST POWER STEERING AND HAD TO COAST OVER TO THE SIDE OF THE ROAD. NO WARNLING LIGHTS CAME ON BEFORE HAND. AFTER I PULLED THE CAR OVER, I WAS ABLE TO RESTART IT WITH NO PROBLEMS AND IT DROVE FINE ALL THE WAY HOME FOR ANOTHER HOUR OR SO. I HAVE SEEN MANY OTHER COMPLAINTS ON THIS WEBSITE SIMILAR TO THIS ONE. LUCKILY THERE WERE NO CARS AROUND AND THE ROAD WASN'T VERY BUSY BUT ITS DISTURBING TO IMAGINE WHAT WOULD HAVE HAPPENED IF THAT HAD NOT BEEN THE CASE. THE CAR IS GOING TO BE WORKED ON TOMORROW SO I DON'T KNOW WHAT THE DEALER THINKS IS WRONG WITH IT YET. *JB
NHTSA ODI #10201741
20,536 miles · Aug 27, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 45 MPH THE VEHICLE TURNED OFF AND CAME TO A COMPLETE STOP. THE VEHICLE RESTARTED AFTER A FEW MINUTES. THERE WERE NO WARNING INDICATOR LIGHTS. THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 20,536. THE CURRENT MILEAGE WAS 20,636. …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 45 MPH THE VEHICLE TURNED OFF AND CAME TO A COMPLETE STOP. THE VEHICLE RESTARTED AFTER A FEW MINUTES. THERE WERE NO WARNING INDICATOR LIGHTS. THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 20,536. THE CURRENT MILEAGE WAS 20,636.
NHTSA ODI #10200915
15,700 miles · Aug 22, 2007
Electrical System
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE ENGINE TURNED COMPLETELY OFF. THERE WERE NO PRIOR WARNING INDICATORS. THE MPH WAS UNKNOWN. THE DEALER REPLACED THE IGNITION SWITCH, HOWEVER; THE FAILURE CONTINUED. THE CURRENT MILEAGE WAS 15,804. THE FAILURE MILEAGE WAS 15,700.
NHTSA ODI #10200507
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration