NHTSA owner reports · September 18, 2026 snapshot.
Structure complaints
46 reportsClear category filter115,000 miles · Mar 1, 2011
Structure
THE DRIVERS DOOR CANNOT BE OPENED FROM EITHER THE INSIDE HANDLE OR THE OUTSIDE HANDLE OF THE THE DOOR, THUS TRAPPING THE DRIVER INSIDE THE CAR OR PREVENTING THE DRIVER FROM ACCESSING THE CAR IF THEY ARE NOT IN IT WHEN THIS HAPPENS. THE DOOR CANNOT BE OPENED WITH EITHER THE DOOR KEY, THE REMOTE OR UNLOCKING THE DOOR FROM THE INS…
Read full complaint
THE DRIVERS DOOR CANNOT BE OPENED FROM EITHER THE INSIDE HANDLE OR THE OUTSIDE HANDLE OF THE THE DOOR, THUS TRAPPING THE DRIVER INSIDE THE CAR OR PREVENTING THE DRIVER FROM ACCESSING THE CAR IF THEY ARE NOT IN IT WHEN THIS HAPPENS. THE DOOR CANNOT BE OPENED WITH EITHER THE DOOR KEY, THE REMOTE OR UNLOCKING THE DOOR FROM THE INSIDE. THIS RESULTS IN THE DRIVER BEING FORCED TO ENTER AND EXIT THE CAR BY ENTERING THE PASSENGER SIDE AND THEN CLIMBING OVER THE CONSOLE. THIS IS A COMMON COMPLAINT FROM MANY OWNERS OF COBALTS AND NEEDS TO BE ADDRESSED. IF THE OCCUPANT WAS INVOLVED IN AN ACCIDENT IN WHICH IT WAS CRITICAL TO EXIT THE VEHICLE, THEY COULD NOT. AFTER SEVERAL DAYS THE DOOR BEGAN WORKING AGAIN. THIS HAS HAPPENED SEVERAL TIMES.
NHTSA ODI #10387108
10,225 miles · May 20, 2010
StructureSuspension
I OWN A 2005 CHEVROLET COBALT. IT HAS 10225 MILES ON IT. IT WOULD NOT PASS THE NEW HAMPSHIRE STATE INSPECTION BECAUSE IT WAS UNSAFE TO DRIVE. THE FRONT END CONTROLLER ARMS NEEDED TO BE REPLACED. I FEEL THAT THERE MUST BE OTHERS OUT THERE WITH LIKE PROBLEMS. *TR
NHTSA ODI #10331396
45,000 miles · Mar 17, 2010
Latches/locks/linkagesStructure
MY 2005 COBALT HAS PROBLEMS WITH THE DOORS GETTING STUCK SHUT. THEY WILL NOT OPEN FROM THE INSIDE OR OUTSIDE . I FEEL THAT THIS IS A MAJOR SAFETY ISSUE DUE TO THE FACT THAT IF I NEED TO GET OUT OF MY CAR IN A HURRY THAT THIS WILL NOT BE POSSIBLE. SOMETHING NEEDS TO BE DONE ABOUT THIS PROBLEM. *TR
NHTSA ODI #10320388
61,882 miles · Mar 2, 2010
Seat BeltsSteeringStructure
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 15-20 MPH ON NORMAL ROAD CONDITIONS. A CHIME SOUNDED INSIDE THE VEHICLE; FOLLOWED BY THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATION. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD.…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 15-20 MPH ON NORMAL ROAD CONDITIONS. A CHIME SOUNDED INSIDE THE VEHICLE; FOLLOWED BY THE POWER STEERING WARNING LIGHT INDICATOR ILLUMINATION. IMMEDIATELY, THERE WAS A LOSS OF POWER STEERING. THE DRIVER PULLED OVER TO THE SIDE OF THE ROAD. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATION FOR A SHORT PERIOD OF FIVE SECONDS. IN ADDITION, THE FRONT DRIVER DOOR CAUSED AN EXTREMELY INTENSE ELECTRICAL SHOCK WHENEVER ACCESSING THE DOOR. THE FRONT DRIVER SIDE SEAT BELT BUCKLE FAILED TO FUNCTION. THE FAILURE OCCURRENCES WERE WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN REFUSED TO PERFORM A DIAGNOSTIC TESTING WITHOUT A SERVICE CHARGE. THE VEHICLE HAS NOT BEEN INSPECTED FOR THE FAILURE OR REPAIRED AT THIS TIME. THE CONTACT HAD CONCERN OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 61,882.
NHTSA ODI #10315456
50,000 miles · Feb 12, 2010
SteeringStructure
I HAVE A 2005 CHEVY COBALT, FOR THE LAST MONTH OR SO THE POWER STEERING HAS STOPPED WORKING LOTS OF TIMES, SOMETIMES IT GOES OUT A COUPLE TIMES A DAY. OTHER TIMES IT DON'T GO OUT FOR A WEEK. I AM AN OLDER LADY AN I THOUGHT WITH GAS MILEAGE THE COBALT WOULD BE A GREAT CAR FOR ME. NOW I AM SCARED EVERY TIME I DRIVE,AS I AM AFRAI…
Read full complaint
I HAVE A 2005 CHEVY COBALT, FOR THE LAST MONTH OR SO THE POWER STEERING HAS STOPPED WORKING LOTS OF TIMES, SOMETIMES IT GOES OUT A COUPLE TIMES A DAY. OTHER TIMES IT DON'T GO OUT FOR A WEEK. I AM AN OLDER LADY AN I THOUGHT WITH GAS MILEAGE THE COBALT WOULD BE A GREAT CAR FOR ME. NOW I AM SCARED EVERY TIME I DRIVE,AS I AM AFRAID THE STEERING WILL GO OUT AND CAUSE ME TO WRECK. I CAN'T AFFORD TO HAVE THIS WORKED ON . WANT TO KNOW IF THERE WILL BE A RECALL AS ON THE TV THEY SAID THERE WERE LOTS OF COBALTS DOING THIS. *TR
NHTSA ODI #10308883
6,000 miles · Jan 18, 2008
Electrical SystemEquipmentStructure
WENT OUT TO WARM UP MY CAR, AS I DO EVERY MORNING. THE CAR WOULD NOT START. WHEN WE GOT IT STARTED , IT SOUNDED LIKE A GO KART OR 4 WHEELER PUTTING. DECIDED TO DRIVE IT TO DEALER AND HAD MY HUSBAND FOLLOW. IT MADE IT ABOUT 5 MILES AND STARTED SMOKING AND SPARKS WERE COMING FROM THE EXHAUST. IT DIED AND WOULDN'T START BACK. WE HA…
Read full complaint
WENT OUT TO WARM UP MY CAR, AS I DO EVERY MORNING. THE CAR WOULD NOT START. WHEN WE GOT IT STARTED , IT SOUNDED LIKE A GO KART OR 4 WHEELER PUTTING. DECIDED TO DRIVE IT TO DEALER AND HAD MY HUSBAND FOLLOW. IT MADE IT ABOUT 5 MILES AND STARTED SMOKING AND SPARKS WERE COMING FROM THE EXHAUST. IT DIED AND WOULDN'T START BACK. WE HAD TO CALL IN A TOW TRUCK TO TAKE IT TO A DEALER. THE DEALER JUST INFORMED ME THAT IT IS AN IGNITION MODULE. WE WILL SEE IF THAT FIXES THE PROBLEM. THIS CAR HAD PROBLEMS SINCE THE DAY I GOT IT. WHEN I GOT HOME WITH IT IN AUGUST 2005, THE TRUNK AJAR LIGHT STAYED ON EVEN THOUGH THE TRUNK WAS NOT OPEN. TOOK IT IN TO A SHOP AND THEY REPLACED A COMPUTER, WHICH IMMEDIATELY BURNT OUT WHILE THERE. I HAD TO WAIT AN ADDITIONAL WEEK FOR THEM TO GET ANOTHER ONE IN. ABOUT MAY OF 2006 THE CAR WAS LEAKING FROM THE AIR VENTS AND THE PASSENGER DASHBOARD. TOOK IT IN AND THE PROBLEM SEEMED TO BE FIXED FOR A WHILE. MAY OF 2007 I HAD THE SAME PROBLEM AND TOOK IT TO ANOTHER CHEVY DEALERSHIP THE PROBLEM SEEMED TO BE FIXED FOR ONLY 2 DAYS. IT STILL LEAKS TO THIS DAY AND I GET CONDENSATION ON THE DASHBOARD WHEN IT S HOT ENOUGH. MY RADIO HAS SHORTED OUT TWICE FROM THIS PROBLEM. MY TRUNK CONSTANTLY MAKES WEIRD TAPPING NOISES AND WHEN PEOPLE ARE IN MY CAR, THEY THINK SOMEONE IS IN THE TRUNK. MY CAR IS NOW AT THE THIRD LOCAL DEALERSHIP ON ABOUT ITS 6 + VISIT. I SEE OTHER PEOPLE WITH THE SAME COMPLAINTS AS MYSELF, AND WONDER WHY WE ARE ALL PAYING OUT OF POCKET FOR THINGS THAT SHOULD APPARENTLY BE RECALLS. MY GAUGES ALSO WORK BY THEMSELVES, WHEN THE CAR IS OFF AND KEYS ARE REMOVED. THE DEALERS CLAIM THIS NEVER HAPPENS IN THEIR VIEW. I AM VERY DISSATISFIED WITH MY PURCHASE AND WOULD NOT RECOMMEND THIS VEHICLE TO ANYONE. MAINLY BECAUSE OF THE LACK OF CONCERN FROM THE CHEVY DEALERS TO FIX THE SOLUTIONS FOR MYSELF AND OTHERS THAT I HAVE READ ABOUT. *TR
NHTSA ODI #10215322
Mileage unknown · Oct 18, 2007
StructureCrash
2005 CHEVY COBALT WITH INADEQUATE PROTECTION IN AN ACCIDENT. CONSUMER WRITING WOULD LIKE ANY INFORMATION ABOUT THIS RECALL DUE TO HIS CLIENT BEING KILLED IN AN ACCIDENT WITH THIS SAME MODEL AND YEAR OF VEHICLE. *KB (LAWYER REPRESENTING THE ESTATE OF HIS DECEASED CLIENT) )*TR
NHTSA ODI #10207136
Mileage unknown · Sep 7, 2007
Electrical SystemStructureVisibility
I HAVE A 2005 CHEVY COBALT WITH LESS THAT 30K MILES I WAS DRIVING HOME FROM WORK WHEN MY CAR JUST SHUT OFF NO HAZARD LIGHTS TURN SIGNALS BRAKES STEERING NO POWER AT ALL I COULD HAVE BEEN KILLED IN ALL TRAFFIC BECAUSE THERE WAS NO WAY OF SIGNALING. IT TOOK THREE TRIES TO GET IT STARTED AGAIN THERE WAS NO WARNING CHECK ENGIN…
Read full complaint
I HAVE A 2005 CHEVY COBALT WITH LESS THAT 30K MILES I WAS DRIVING HOME FROM WORK WHEN MY CAR JUST SHUT OFF NO HAZARD LIGHTS TURN SIGNALS BRAKES STEERING NO POWER AT ALL I COULD HAVE BEEN KILLED IN ALL TRAFFIC BECAUSE THERE WAS NO WAY OF SIGNALING. IT TOOK THREE TRIES TO GET IT STARTED AGAIN THERE WAS NO WARNING CHECK ENGINE LIGHT NEVER CAME ON I IMMEDIATELY TOOK IT TO THE DEALERSHIP BECAUSE THIS WAS THE SECOND TIME IT HAS HAPPENED TO ME I HAD THIS PROBLEM LAST YEAR ALSO GM NEVER HAD A RECALL THEY JUST PUT A PLASTIC PIECE AROUND THE IGNITION AND SAID IT WAS FIXED I TOLD MY DEALER THAT THERE WAS A BULLETIN OUT ABOUT THIS AND I ASKED THEM WHY THERE WAS NO RECALL TO REPLACE THE IGNITION SWITCH AFTER THIS SECOND INCIDENT GM WANTED TO PUT A MAGNETIC DEVICE IN TO KEEP THE KEY FROM MOVING IN THE IGNITION ANY THEY PLACED A PIECE OF PLASTIC IN MY ACTUAL KEY I CALLED GM AND PLACED A FORMAL COMPLAINT BECAUSE THIS IS A SERIOUS SAFETY CONCERN PEOPLE ARE GOING TO BE HURT OR KILLED IF THEY GET INVOLVED IN A REAR END COLLISION OR HAVE NO WAY OF PULLING OFF ROADWAY SPOKE TO MY SERVICE MANAGER AND DEALERSHIP REPLACED IGNITION SWITCH THERE HAS NEVER BEEN A RECALL ON THIS I DO NOT TRUST THAT IT WILL NOT HAPPEN AGAIN I AM AFRAID TO DRIVE THIS CAR THIS IS NOT THE ONLY PROBLEM I HAVE HAD WITH THIS CAR THE FAN BLOWER THE SHIFT ON THE FLOOR THE SUNROOF SWITCH KEEPS FALLING OUT OF THE ROOF THE WINDOW MOTORS HAVE BURNED OUT MY INTERIOR PAINT AND DOOR HANDLES WERE PEELING AFTER THE FIRST YEAR I DON'T BLAME MY SERVICE DEPARTMENT BECAUSE THEY HAVE FIXED THE CAR THE WAY GM TOLD THEM TO I FEEL VERY UNSAFE IN THIS CAR WHY SHOULD I HAVE TO WAIT UNTIL HE IGNITION SHUTS OFF A THIRD TIME THIS COULD BE MY LAST IF WHAT IS GM DOING ABOUT THIS? ARE THEY GOING TO DO A RECALL? WHAT ELSE HAS TO HAPPEN TO ME BEFORE THEY TAKE THIS SERIOUSLY? I AM EXTREMELY DISSATISFIED WITH THIS CAR AND I DO NOT WANT IT ANYMORE. *TR * 12/12/07 *BF THE DEALER STATED DRIVER SIDE REAR POWER WINDOW WAS INOPERABLE. UPDATED 12/12/07 *TR
NHTSA ODI #10202169
8,000 miles · Mar 27, 2007
Structure
TL* - THE CONTACT OWNS A 2005 CHEVROLET 2005 COBALT. THE CONTACT RECEIVED RECALL 07V014000 FOR THE STRUCTURE. THE DEALER STATED IT WOULD TAKE TWO WEEKS FOR THE PART TO COME IN. THE CURRENT MILEAGE WAS 8,000. THE CONTACT HAD NOT EXPERIENCED ANY PROBLEMS. *AK
NHTSA ODI #10186270
Mileage unknown · Mar 26, 2007
Exterior LightingStructure
TL*- THE CONTACT RECEIVED TWO RECALLS 04560000 CONCERNING EXTERIR LIGHTING:HEADLIGHTS AND 07V014000 CONCERNING STRUCTURE ON THE 2005 CHEVROLET COBALT IN AUGUST 2006. HE MADE THREE ATTEMPTS TO GET THE VEHICLE REPAIRED. THE DEALER WILL NOT GIVE HIM A LOANER VEHICLE FOR THE DAY AND/OR WILL NOT GIVE HIM A RIDE TO WORK. THE CU…
Read full complaint
TL*- THE CONTACT RECEIVED TWO RECALLS 04560000 CONCERNING EXTERIR LIGHTING:HEADLIGHTS AND 07V014000 CONCERNING STRUCTURE ON THE 2005 CHEVROLET COBALT IN AUGUST 2006. HE MADE THREE ATTEMPTS TO GET THE VEHICLE REPAIRED. THE DEALER WILL NOT GIVE HIM A LOANER VEHICLE FOR THE DAY AND/OR WILL NOT GIVE HIM A RIDE TO WORK. THE CURRENT MILEAGE WAS 45,000. THERE HAD BEEN NO FAILURES TO DATE.*AK
NHTSA ODI #10186213
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration