IllustrationMY POWER STEERING WILL STOP WORKING WHILE I DRIVE AND I HAVE TO PHYSICALLY MANIPULATE THE VEHICLE TO A STOP AND TURN OFF THE CAR AND RESTART IT TO RESET THE ELECTIRICAL MOTOR IN THE POWER STEERING. *LN
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Steering complaints
1,143 reportsCHEVY DEALER REPLACED POWER STEERING ASSIST, SINCE THE REPAIR, ISSUE HAS BEEN RECURRING. TRANSMISSION SLIPS AND KNOCKS THE CAR FORWARD, POWER STEERING ERROR APPEARS, TACHOMETER AND SPEEDOMETER SHORT OUT. *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE EXITING A RESIDENTIAL DRIVEWAY AT 1 MPH, THE VEHICLE LOST ALL POWER STEERING CAPABILITIES. THE VEHICLE WAS SHUT OFF AND UPON RESTART, THE FAILURE PERSISTED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V0…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE EXITING A RESIDENTIAL DRIVEWAY AT 1 MPH, THE VEHICLE LOST ALL POWER STEERING CAPABILITIES. THE VEHICLE WAS SHUT OFF AND UPON RESTART, THE FAILURE PERSISTED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM) SEVEN MONTHS PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER ADVISED THE CONTACT THAT THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS RELEASED TO THE CONTACT NOVEMBER 12, 2010. THE CONTACT STATED THAT THE POWER STEERING WARNING ALARM SOUNDED AND THE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 124,000. UPDATED 04/12/11*LJ THE CONSUMER ALSO STATED THE BRAKES LOCKED UP ON A CONSISTENT BASIS. ALSO, THE DEFROSTER WORKED INTERMITTENTLY.
POWER STEERING WAS RECALLED IN MY 2005 CHEVY COBALT...BUT THE WHOLE STEERING COLUMN NEEDS TO BE RECALLED. I WILL NEVER BY A CHEVY AGAIN. *TR
I RECENTLY PURCHASED USED MY 2005 CHEVY COBALT AND SUNDAY A WEEK AFTER HAVING THE CAR GAVE ME PROBLEMS. ACCORDING TO THE CARFAX REPORT THE POWER STEERING WAS REPLACED IN APRIL ASSUMING DO TO THE RECALL. BUT I GOT IN MY CAR AND THE POWER STEERING READ ACROSS THE MILEAGE AREA AND CHIMED. VERY LITTLE NOTICEABLE ISSUES DO TO STEER…
Read full complaint
I RECENTLY PURCHASED USED MY 2005 CHEVY COBALT AND SUNDAY A WEEK AFTER HAVING THE CAR GAVE ME PROBLEMS. ACCORDING TO THE CARFAX REPORT THE POWER STEERING WAS REPLACED IN APRIL ASSUMING DO TO THE RECALL. BUT I GOT IN MY CAR AND THE POWER STEERING READ ACROSS THE MILEAGE AREA AND CHIMED. VERY LITTLE NOTICEABLE ISSUES DO TO STEERING BUT WHEN I CAME TO A STOP LIGHT IT VIBRATED REALLY BAD AND THEN EVERYTIME IT SHIFTED(ITS AN AUTOMATIC) TO ANOTHER GEAR HIGHER OR LOWER IT WOULD ACT LIKE IT HAD SHIFTING PROBLEMS. ALSO WHEN I WOULD COME TO STOPS AT A LIGHT OR STOP SIGN IT WOULD VIBRATE REALLY BAD TO THE POINT WHERE IT SEEMED LIKE IT WOULD STALE OUT. IT HAD ONLY STALLED ONCE. I JUST HOPE SOMEONE CAN RESOLVE THIS ISSUE BECAUSE IT SEEMS LIKE TONS OF PEOPLE ARE HAVING THIS ISSUE. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 75 MPH, THE POWER STEERING FAILED. THE CONTACT PULLED TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. WHEN SHE RESTARTED, THE POWER STEERING RESET ITSELF AND FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED ACCORDING TO RECALL 1…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 75 MPH, THE POWER STEERING FAILED. THE CONTACT PULLED TO THE SIDE OF THE ROAD AND TURNED THE ENGINE OFF. WHEN SHE RESTARTED, THE POWER STEERING RESET ITSELF AND FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS REPAIRED ACCORDING TO RECALL 10V073000 (STEERING:ELECTRIC POWER ASSIST SYSTEM). WHILE DRIVIGN 35 MPH, THE POWER STEERING FAILED AGAIN AND SHE ALMOST CRASHED INTO A POLE. THE CONTACT CALLED THE DEALER AND SCHEDULE ANOTHER APPOINTMENT. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE POWER STEERING LIGHT FLASHED ON THE INSTRUMENT PANEL AND THE STEERING WHEEL SUDDENLY LOCKED UP. THE CONTACT PULLED OVER AND TURNED THE VEHICLE OFF. THE POWER STEERING FUNCTIONED PROPERLY AFTER THE VEHICLE WAS RESTARTED. THE VEHICLE HAD…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE POWER STEERING LIGHT FLASHED ON THE INSTRUMENT PANEL AND THE STEERING WHEEL SUDDENLY LOCKED UP. THE CONTACT PULLED OVER AND TURNED THE VEHICLE OFF. THE POWER STEERING FUNCTIONED PROPERLY AFTER THE VEHICLE WAS RESTARTED. THE VEHICLE HAD NOT BEEN EXAMINED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
CHEVY TODAY SAID THAT THEIR IS NOTHING WRONG WITH MY PWR STEERING YET BOTH MYSELF AND MY BROTHER TEST DROVE IT. NOW IN AUG I HAD THE RECALL AND THEY FIXED IT SO THEY CLAIMED IN AUG BUT YET IT IS DOING THE SAME THING ONLY WORSE THIS PAST WK. AMAZING HOW CHEVY WILL TRY TO USE THE EXCUSE THAT IT IS SOMETHING ELSE OTHER THEN THE PWR…
Read full complaint
CHEVY TODAY SAID THAT THEIR IS NOTHING WRONG WITH MY PWR STEERING YET BOTH MYSELF AND MY BROTHER TEST DROVE IT. NOW IN AUG I HAD THE RECALL AND THEY FIXED IT SO THEY CLAIMED IN AUG BUT YET IT IS DOING THE SAME THING ONLY WORSE THIS PAST WK. AMAZING HOW CHEVY WILL TRY TO USE THE EXCUSE THAT IT IS SOMETHING ELSE OTHER THEN THE PWR STEERING WHEN THE INSTRUMENT LIGHT CHIMING PWR STEERING WAS A [XXX] GOOD INDICATION THAT IT WAS THE STEERING. NOT TO MENTION I COULD NOT TURN MY STEERING WHEEL AND WHEN I TRY TO ACCELERATE THE CAR WOULD JOLT LIKE IT WAS NOT GOING INTO GEAR. LET ME NOT FORGET TO MENTION THE CLICKING NOISE I GET UNDERNEATH THE DASH NEAR THE STEERING WHEEL AND THE CLICKING IN THE SHIFTER. SAME PROBLEM NEW DAY AND THEY TELL ME IT'S FINE. I GUESS I HAVE TO KILL SOMEONE ON THE RD FOR THEM TO DO SOMETHING ABOUT THE CAR. YOU GUYS NEED TO STEP IN BECAUSE I AM 2 STEPS AWAY FROM CALLING A LAWYER AND SUING EVERYONE THAT IS INVOLVED WITH KNOWING AND NOT DOING ANYTHING ABOUT IT. I SURELY DO NOT FEEL LIKE BEING SCRAPED OFF THE DARN HWY OR THE GUILT OF KILLING SOMEONE OVER SOMETHING THAT YOU GUYS SHOULD HAVE TAKEN CARE OF BACK IN 2005 WHEN ALL THIS STARTED HAPPENING. WE NEED TO RECALL ALL CARS FROM 05 TO 09 AND GET THEM OFF THE STREET AND HAVE CHEVY REIMBURSE US OR GIVE US A SAFER CAR. I KNOW IT MAY SEEM LIKE A LOT OF MONEY BUT 1 LIFE BEING SAVED MAKES A DIFFERENCE. I KNOW CAR DEALERS HAVE WHAT THEY CALL A BEAN COUNTER AND THEY DON'T CARE IF 1 OR A 12 PEOPLE DIE FROM FAULTY EQUIPMENT AND YOU GUYS CAN LIVE WITH THAT. BUT TO ME THAT IS HORRIBLE AND NEEDS TO BE STOPPED IMMEDIATELY....NOW MEANS NOW!!!!!!!!! THANK YOU FOR YOUR TIME NOT SO HAPPY WITH HOW YOU GUYS MANAGE SAFETY AND THE RESPONSE TIME. IGNORE THE PARTS SECTION OR EQUIPMENT SECTION BECAUSE I DID NOT KNOW THE MANUFACTURER OF THE PWR MOTOR REPLACED. I TRULY DO NOT FEEL THEY EVEN REPLACED IT. I THINK AMERICA HAS BEEN HAD ONCE AGAIN BY THE CAR INDUSTRY. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
WELL LAST YEAR I HAD ISSUES WITH MY 05 CHEVY COBALT POWER STEERING UNIT AND IT DID ALMOST GET ME KILLED ALONG WITH SOME PEDESTRIANS ON THE SIDE OF THE ROAD. LUCKILY NO ONE GOT HURT. YOU GUYS FINALLY RECALLED THE CAR AND I HAD MY UNIT REPLACED ON AUGUST 16 OF 2010. HOWEVER THIS PAST MONDAY OCTOBER 4TH MY CAR DID THE SAME THING AF…
Read full complaint
WELL LAST YEAR I HAD ISSUES WITH MY 05 CHEVY COBALT POWER STEERING UNIT AND IT DID ALMOST GET ME KILLED ALONG WITH SOME PEDESTRIANS ON THE SIDE OF THE ROAD. LUCKILY NO ONE GOT HURT. YOU GUYS FINALLY RECALLED THE CAR AND I HAD MY UNIT REPLACED ON AUGUST 16 OF 2010. HOWEVER THIS PAST MONDAY OCTOBER 4TH MY CAR DID THE SAME THING AFTER THE REPAIRED RECALL WAS FIXED. IT WOULD APPEAR THAT ANY VEHICLE FROM 05 - 09 HAS THIS PROBLEM AND IT WILL NEVER BE FULLY REPAIRED CORRECTLY OR IT CAN'T BE. BUT I THINK IT WILL TAKE HUNDREDS OF MORE ACCIDENTS AND MAYBE A FEW HUNDRED DEATHS BEFORE IT IS TRULY DEALT WITH ACCORDINGLY. I THINK THEY JUST NEED TO TAKE ALL THESE VEHICLES BACK AND SCRAP THEM AS RECYCLABLES BECAUSE THEY WILL NEVER BE SAFE OR LIABLE. THEY WERE POORLY MANUFACTURED AND I TRULY DO NOT FEEL SAFE IN IT. HOWEVER I CAN NOT AFFORD A NEW CAR SO I AM STUCK WITH THE RISK OF KILLING INNOCENT PEOPLE ALONG WITH MYSELF. GOD BE WITH US ALL AS WE TAKE OUR CHANCES AND VENTURE INTO THE VALLEY OF DEATH. KEEPING THESE CARS ON THE ROAD, YOU ARE KILLING PEOPLE. WAKE UP GUYS AND LETS FIXED THIS PROBLEM NOW BEFORE MORE PEOPLE GET KILLED........I AM ALREADY FOR A CLASS ACTION SUIT AGAINST CHEVY. I RATHER DO IT NOW BEFORE IT IS TOO LATE AND OTHERS DIE OR GET HURT BECAUSE OF A COMPUTER CONTROLLED DEVICE THAT I THINK IS TRULY UNREPAIRABLE.... SORRY UNDER EQUIPMENT I ADDED ZF AND I-SHAFT. I DID NOT KNOW THE PART MANUFACTURER THAT THEY INSTALLED SO IGNORE THAT PART. ALL I KNOW IS THEY FIXED THE SO CALLED POWER STEERING RECALL ISSUE THING AND IT DID NOT FIX THE PROBLEM. OR THE REPAIRS WILL NEVER TRULY FIX THIS PROBLEM AND YOU NEED TO ISSUE A STATEWIDE ALERT TO GET THESE VEHICLES OFF THE ROAD COMPLETELY BEFORE SOMEONE GETS HURT IF NOT KILLED. HAVE SOME DIGNITY FOR HUMAN LIFE PLEASE IS ALL I ASK. THANK YOU!!! *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE STEERING WHEEL BEGAN TO JERK AND THE POWER STEERING FAILED WHICH CAUSED THE VEHICLE TO PULL TO THE SIDE OF THE ROAD. THE FAILURE OCCURRED THREE TIMES BEFORE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE MOTOR SENSOR, STEERING COLUMN AND RACK AND PI…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 65 MPH, THE STEERING WHEEL BEGAN TO JERK AND THE POWER STEERING FAILED WHICH CAUSED THE VEHICLE TO PULL TO THE SIDE OF THE ROAD. THE FAILURE OCCURRED THREE TIMES BEFORE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE MOTOR SENSOR, STEERING COLUMN AND RACK AND PINION SHAFT WERE REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.