IllustrationVEHICLE HAS A RATTLE AND VIBRATION AT HIGHWAYS SPEEDS FROM 50-80. STEERING IS VERY LOOSE AND RATTLING SOUND IS LOUD. ALSO, AT SLOW SPEEDS AND GOING OVER BUMPS THERE IS A CLUNKING SOUND IN THE STEERING COLUMN AND RATTLING NOISE FROM WHEEL. *TR
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Steering complaints
1,143 reportsTHE TRACTION CONTROL LIGHT CAME ON, THE CAR STARTED JERKING REALLY BAD. THE CHECK ENGINE LIGHT CAME ON, AND THE "POWER STEERING" STARTED FLASHING ON MY DASHBOARD. MY POWER STEERING WENT OUT, I WAS UNABLE TO STEER THE CAR. I HAD THE CAR TOWED TO THE DEALERSHIP, THEY COULD NOT GET IT TO DUPLICATE THE PROBLEM. EXACTLY ONE WEEK LATE…
Read full complaint
THE TRACTION CONTROL LIGHT CAME ON, THE CAR STARTED JERKING REALLY BAD. THE CHECK ENGINE LIGHT CAME ON, AND THE "POWER STEERING" STARTED FLASHING ON MY DASHBOARD. MY POWER STEERING WENT OUT, I WAS UNABLE TO STEER THE CAR. I HAD THE CAR TOWED TO THE DEALERSHIP, THEY COULD NOT GET IT TO DUPLICATE THE PROBLEM. EXACTLY ONE WEEK LATER, IT DID IT AGAIN, ONCE AGAIN I HAD IT TOWED TO THE DEALER. THEY HAD THE CAR FOR 2 WEEKS AND COULD NOT GET IT TO DUPLICATE THE PROBLEM. SO, ONCE AGAIN I HAVE THE CAR BACK, LETS SEE HOW LONG IT TAKES TO SCREW UP THIS TIME. *TR
AT RANDOM TIMES, MY 2005 CHEVY COBALT WILL POP UP A "CHECK ENGINE" LIGHT AND A "TRACTION CONTROL" LIGHT, WHERE I LOSE MY POWER STEERING, THE MOTOR SHIFTS HARD INTO EACH GEAR, AND THE MOTOR RUNS VERY ROUGH. ALSO, THERE ARE CLICKING SOUNDS AT THE SHIFTER, LIKE IT IS TRYING TO SHIFT INTO A GEAR OR SOMETHING. THIS IS A SERIOUS HAZ…
Read full complaint
AT RANDOM TIMES, MY 2005 CHEVY COBALT WILL POP UP A "CHECK ENGINE" LIGHT AND A "TRACTION CONTROL" LIGHT, WHERE I LOSE MY POWER STEERING, THE MOTOR SHIFTS HARD INTO EACH GEAR, AND THE MOTOR RUNS VERY ROUGH. ALSO, THERE ARE CLICKING SOUNDS AT THE SHIFTER, LIKE IT IS TRYING TO SHIFT INTO A GEAR OR SOMETHING. THIS IS A SERIOUS HAZARD AND AS I'VE READ ONLINE, I AM NOT THE ONLY ONE THIS HAS HAPPENED TO. THERE ARE THOUSANDS OF OTHERS. THIS ENTIRE CAR NEEDS TO BE RECALLED BECAUSE NO ONE KNOWS WHAT IS DOING THIS! *TR
I WAS DRIVING DOWN THE HILL AND MY CAR MADE A "DING NOISE" THREE TIMES AND ON THE DISPLAY IT SAID POWER STEERING AT WHICH TIME IT MADE A CLICKING NOISE AND I COULD BARELY TURN THE STEERING WHEEL, I MADE IT ABOUT 3 FEET WITH THE CAR "BUCKING" AND WAS ABLE TO PULL INTO THE NEAREST PARKING LOT AND SAT THERE AND TURNED MY CAR OFF AN…
Read full complaint
I WAS DRIVING DOWN THE HILL AND MY CAR MADE A "DING NOISE" THREE TIMES AND ON THE DISPLAY IT SAID POWER STEERING AT WHICH TIME IT MADE A CLICKING NOISE AND I COULD BARELY TURN THE STEERING WHEEL, I MADE IT ABOUT 3 FEET WITH THE CAR "BUCKING" AND WAS ABLE TO PULL INTO THE NEAREST PARKING LOT AND SAT THERE AND TURNED MY CAR OFF AND THEN TURNED IT ON THE STEERING WHEEL WOULD ONLY TURN SLIGHTLY AND MY CAR WOULD NOT REVERSE. THIS HAPPENED ABOUT 3 YEARS AGO AND I HAD IT FIXED FOR $800 AND NOW IT'S HAPPENING AGAIN. I AM FEARFUL THAT THIS CAR IS NOT SAFE TO DRIVE AND I DON;T KNOW WHAT IS WRONG WITH MY POWER STEERING. I HAD A NEW ENGINE PUT IN LAST YEAR AND ALL THIS FOR A CAR THAT IS ONLY 7 YRS OLD. I DON'T HAVE THE MONEY TO KEEP REPLACING PARTS AND I AM CONCERNED THAT THIS IS NOT A SAFE CAR FOR MYSELF AND MY CHILDREN. *TR
I WAS DRIVING DOWN THE ROAD AND THE POWER STEERING GAVE OUT. I HAD THIS REPLACED IN 2010 AND IT HAS ALREADY GIVEN OUT. I CALLED THE CUSTOMER SERVICE LINE AND THEY SAID IT WAS MY PROBLEM UNLESS I WENT TO THE DEALERSHIP AND GOT ANOTHER DIAGNOSTIC TEST DONE ON THE CAR WHICH WAS MY RESPONSIBILITY. I WAS UNAWARE OF THE FIRST RECALL A…
Read full complaint
I WAS DRIVING DOWN THE ROAD AND THE POWER STEERING GAVE OUT. I HAD THIS REPLACED IN 2010 AND IT HAS ALREADY GIVEN OUT. I CALLED THE CUSTOMER SERVICE LINE AND THEY SAID IT WAS MY PROBLEM UNLESS I WENT TO THE DEALERSHIP AND GOT ANOTHER DIAGNOSTIC TEST DONE ON THE CAR WHICH WAS MY RESPONSIBILITY. I WAS UNAWARE OF THE FIRST RECALL AND WAS CHARGED 100 DEDUCTIBLE. I FIGURED SINCE I WAS THERE GETTING MY CAR SERVICED I WOULD GET OTHER THINGS FIXED. *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE STEERING WHEEL BECAME HARD TO TURN. IN ADDITION, THE TRACTION CONTROL AND THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED HOWEVER, THE DIAGNOSTIC WAS UNABLE TO DETER…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE STEERING WHEEL BECAME HARD TO TURN. IN ADDITION, THE TRACTION CONTROL AND THE POWER STEERING WARNING LIGHT ILLUMINATED AS THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED HOWEVER, THE DIAGNOSTIC WAS UNABLE TO DETERMINE A SPECIFIC FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 101,000 AND THE CURRENT MILEAGE WAS 102,000.
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THERE WAS A COMPLETE LOSS OF POWER STEERING WITH THE ILLUMINATION OF THE WARNING INDICATOR. THE STEERING WHEEL WAS EXTREMELY DIFFICULT TO MANEUVER WHICH CAUSED A SLIGHT LOSS OF CONTROL AND THE VEHICLE CRASHED INTO ANOTHER VEH…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THERE WAS A COMPLETE LOSS OF POWER STEERING WITH THE ILLUMINATION OF THE WARNING INDICATOR. THE STEERING WHEEL WAS EXTREMELY DIFFICULT TO MANEUVER WHICH CAUSED A SLIGHT LOSS OF CONTROL AND THE VEHICLE CRASHED INTO ANOTHER VEHICLE. THERE WERE NO PERSONAL INJURIES. A POLICE REPORT WAS NOT FILED OF THE INCIDENT. THE VEHICLE WAS DRIVEN WITH CAUTION AND HAD NOT BEEN REPAIRED. IN 2010, THE VEHICLE WAS REPAIRED UNDER A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING). THE FAILURE RECURRED TWO DAYS AFTER THE REMEDY REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN BACK TWICE TO THE DEALER WHERE THE SPARK PLUGS WERE REPLACED. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 14,902.
MY 2005 CHEVY COBALT BEGINS TO SHAKE WHILE DRIVING ON THE FREEWAY. I CAN FEEL THE VIBRATION STARTING THROUGH THE FLOOR BOARD AND EVENTUALLY THE WHOLE FRONT END BEGINS TO SHAKE. THE STEERING WHEEL VIOLENTLY SHAKES FROM FRONT TO BACK(VERSUS SIDE TO SIDE) AND THE VEHICLE IS HARD TO CONTROL. I ALWAYS HAVE TO PULL OVER OR GET OFF THE…
Read full complaint
MY 2005 CHEVY COBALT BEGINS TO SHAKE WHILE DRIVING ON THE FREEWAY. I CAN FEEL THE VIBRATION STARTING THROUGH THE FLOOR BOARD AND EVENTUALLY THE WHOLE FRONT END BEGINS TO SHAKE. THE STEERING WHEEL VIOLENTLY SHAKES FROM FRONT TO BACK(VERSUS SIDE TO SIDE) AND THE VEHICLE IS HARD TO CONTROL. I ALWAYS HAVE TO PULL OVER OR GET OFF THE FREEWAY. IT FEELS LIKE THE WHOLE FRONT END IS GOING TO FALL APART. AFTER COMING TO A COMPLETE STOP I CAN CONTINUE TO DRIVE WITHOUT ANY PROBLEMS. THIS BEGAN ALMOST 6 MONTHS AGO. I HAVE HAD MY CAR LOOKED AT SEVERAL TIMES AND EACH TIME I TAKE IT AND SOMEONE TEST DRIVES IT THEY CANNOT FIND A PROBLEM. THEY HAVE DONE INSPECTIONS OF BRAKES, TIRES ( REBALANCE AND ROTATE, CHECKED FRONT END ALIGNMENT, CHECKED STEERAGE AND LINKAGE AND THEY FIND NOTHING WRONG. THEY ALSO TELL ME THAT MY CAR IS IN GREAT CONDITION. BUT IT CONTINUES TO SHAKE ALL THE TIME. SOMETIMES IT WON'T HAPPEN FOR A WEEK OR TWO, SOMETIMES IT HAPPENS TWO OR THREE TIMES A WEEK. . *TR
I WAS ALMOST KILLED IN THIS CAR WHEN MY STEERING FROZE UP ON THE HIGHWAY. I COULDN'T TURN MY WHEEL. THANK GOD I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD, BUT WAS VERY DANGEROUS & SCARY. LONG STORY SHORT I HAD IT CHECKED OUT AND WAS TOLD IT NEEDS A NEW STEERING ASSIST MOTOR WHICH WAS RECALLED BACK IN 2010. MY DEALERSHIP CL…
Read full complaint
I WAS ALMOST KILLED IN THIS CAR WHEN MY STEERING FROZE UP ON THE HIGHWAY. I COULDN'T TURN MY WHEEL. THANK GOD I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD, BUT WAS VERY DANGEROUS & SCARY. LONG STORY SHORT I HAD IT CHECKED OUT AND WAS TOLD IT NEEDS A NEW STEERING ASSIST MOTOR WHICH WAS RECALLED BACK IN 2010. MY DEALERSHIP CLAIMS THEY FIXED IT BACK IN 2010 WHEN THE RECALL WAS ISSUED. THEY CLAIM TO HAVE THE PAPERWORK (ACTUALLY ONLY 1/2 OF THE PAPER WORK). IF IT WAS FIXED IT ISN'T WORKING NOW AND I WAS ALMOST KILLED. THIS WAS A RECALL AND I DON'T THINK I SHOULD HAVE TO PAY $500. TO GET IT FIXED. I HAVE COMPLAINED TO GM & SPOKE TO [XXX] AT YOUR COMPANY AND GOT NOWHERE! IN FACT [XXX] SIDED WITH THE DEALERSHIP. I WOULD LIKE THIS FIXED AT NO EXPENSE TO MYSELF. IF HIS ISSUE IS NOT RESOLVED I AM GOING TO MY LOCAL TV SHOW AND ALSO TO MY STATE SENATOR RON BLUMENFELD WHO WILL INDEED RESOLVE THIS ISSUE IF YOU ARE AT ALL FAMILIAR WITH CHANNEL 8 AND MR BLUMENFELD. I CAN'T BELIEVE YOU WOULD JEOPARDIZE SOMEONE'S SAFETY OVER THE ALMIGHTY DOLLAR! I SHOULD NOT HAVE TO PAY $115. JUST TO GET IT LOOKED AT AND THEN ANOTHER $500 TO REPLACED THE MOTOR....YET AGAIN!! I LOOK FORWARD TO HEARING BACK FROM YOU. I AM COPYING THIS LETTER TO [XXX] AS WELL AS MY ATTORNEY. ALSO, TERRYVILLE CHEVY, WHERE I BOUGHT THE CAR HAS BEEN TOTALLY UNHELPFUL AND REFUSING TO HELP ME WITHOUT MONEY. IT IS A 2005 CHEVY COBALT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT BOTH THE TRACTION CONTROL AND POWER STEERING WARNING INDICATORS ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THERE WAS ALSO A COMPLETE LOSS OF POWER STEERING AND THE TRANSMISSION BEGAN TO DOWN SHIFT INDEPENDENTLY. THE CONTACT WAS ABLE TO CONTINUE TO DRIVE WITH…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT BOTH THE TRACTION CONTROL AND POWER STEERING WARNING INDICATORS ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THERE WAS ALSO A COMPLETE LOSS OF POWER STEERING AND THE TRANSMISSION BEGAN TO DOWN SHIFT INDEPENDENTLY. THE CONTACT WAS ABLE TO CONTINUE TO DRIVE WITH EXCESSIVE FORCE BEING APPLIED TO THE STEERING WHEEL. THE FAILURES WOULD RECUR SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING). THE FAILURE RECURRED ONE YEAR AFTER THE RECALL REMEDY WAS PERFORMED. THE VEHICLE WAS NOT REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 45,000. THE VIN WAS UNAVAILABLE.
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.