IllustrationTHE ELECTRIC POWER STEERING WILL OCCASIONALLY SHUT OFF DURING DRIVING. THE CAR MUST BE SHUT OFF THEN TURNED BACK ON TO RESTART THIS. THIS IS A REPEATING OCCURRENCE SOMETIMES HAPPENING MORE THAN 10 TIMES A DAY. THE ONLY FIX RIGHT NOW IS REPLACING THE STEERING COLUMN. *TR
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Steering complaints
1,143 reportsELECTRONIC POWER STEERING ASST. COMPLETE FAILURE POWER STEER RETURNS AFTER KEY CYCLE DATA INDICATOR FLASHER (POWER STEERING) IMMEDIATELY AFTER MANUAL STEERING ALMOST LOCK UP ONLY SMALL CORRECTIONS CAN BE MADE IN STEERING AT THAT TIME THIS IS A LIFE THREATENING PROBLEM!! FOR ME OR SOMEONE ELSE. CAR HOPPED CURB CAUSING SMALL AM…
Read full complaint
ELECTRONIC POWER STEERING ASST. COMPLETE FAILURE POWER STEER RETURNS AFTER KEY CYCLE DATA INDICATOR FLASHER (POWER STEERING) IMMEDIATELY AFTER MANUAL STEERING ALMOST LOCK UP ONLY SMALL CORRECTIONS CAN BE MADE IN STEERING AT THAT TIME THIS IS A LIFE THREATENING PROBLEM!! FOR ME OR SOMEONE ELSE. CAR HOPPED CURB CAUSING SMALL AMOUNT OF DAMAGE TO RIMS DEALER SUGGESTED A REPAIR OF 831.45$ +TAX CAUSED BY DTC CO475 ELEC. STEERING MOTOR CIRCUIT. THEY DID NOT INDICATE WHAT THE CAUSE OF THE FAILURE IN THE CIRCUIT! *TR
2005 COBALT, POWER STEERING GOES OUT EVERYTIME IT MOVES. THE POWER STEERING IN MY CAR HAS BEEN OUT FOR ABOUT 7 MONTHS NOW. I JUST READ SEVERAL OTHER COMPLAINTS OF THE EXACT SAME THING SO IT IS NOTHING I HAVE DONE AND IS COMMON WITH THE COBALTS. GM TAKES NO RESPONSIBILITY FOR THIS DEFECT AND HAS LEFT THE $1,000.00 REPAIR UP TO…
Read full complaint
2005 COBALT, POWER STEERING GOES OUT EVERYTIME IT MOVES. THE POWER STEERING IN MY CAR HAS BEEN OUT FOR ABOUT 7 MONTHS NOW. I JUST READ SEVERAL OTHER COMPLAINTS OF THE EXACT SAME THING SO IT IS NOTHING I HAVE DONE AND IS COMMON WITH THE COBALTS. GM TAKES NO RESPONSIBILITY FOR THIS DEFECT AND HAS LEFT THE $1,000.00 REPAIR UP TO THE OWNERS TO PAY OUT. THIS IS A BIG SAFETY ISSUE, WILL IT TAKE SOMEONE BEING KILLED BEFORE THIS IS ADDRESSED? IT SEEMS THERE SHOULD BE SOMEONE OUT THERE FORCING THESE MANUFACTURES TO TAKE RESPONSIBILITY FOR THEIR PRODUCTS. *TR
STEERING LOCKS CAR SHAKES WHILE DRIVING CAN BE A BIG PROBLEM HAS HAPPENED MANY TIMES DEALER CAN NOT FIND THE PROBLEM BUT SEE MANY COMPLAINTS ON WED SITES. WAS IN FLORIDA TO GEORGE MOORE DEALER IN JACKSONVILLE ON AUGUST 20 2007 PROBLEM STILL HAPPENING WHAT NEXT? *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 50 MPH, THE POWER STEERING STOPPED WORKING. THE POWER STEERING WARNING LIGHT ILLUMINATED AND IT BECAME EXTREMELY DIFFICULT FOR THE CONTACT TO STEER THE VEHICLE. THE VEHICLE HAS NOT BEEN TO THE DEALER. THE VIN AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 47,0…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 50 MPH, THE POWER STEERING STOPPED WORKING. THE POWER STEERING WARNING LIGHT ILLUMINATED AND IT BECAME EXTREMELY DIFFICULT FOR THE CONTACT TO STEER THE VEHICLE. THE VEHICLE HAS NOT BEEN TO THE DEALER. THE VIN AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 47,000 AND FAILURE MILEAGE WAS 34,000.
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING AT ANY SPEED, THE POWER STEERING INTERMITTENTLY SHUTS OFF. THE FAILURE HAS PROGRESSIVELY WORSENED OVER TIME. THE DEALER STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED AT THE COST OF $2,000. THE VIN, ENGINE SIZE, AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MIL…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING AT ANY SPEED, THE POWER STEERING INTERMITTENTLY SHUTS OFF. THE FAILURE HAS PROGRESSIVELY WORSENED OVER TIME. THE DEALER STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED AT THE COST OF $2,000. THE VIN, ENGINE SIZE, AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE WAS 55,000 AND FAILURE MILEAGE WAS 49,000.
THE ELECTRONIC POWER STEERING SENSOR FAILS WHILE DRIVING AND SHUTS OFF THE POWER STEERING WITHOUT WARNING, OR A CHANCE TO PULL OFF THE ROAD. IF I MAKE IT TO THE SIDE OF THE ROAD WITHOUT BEING HIT, I CAN RESTART MY CAR AND THE POWER STEERING COMES BACK ON. BY DEFAULT THE COMPUTER SHUTS OFF THE POWER STEERING TO PREVENT DAMAGE TO …
Read full complaint
THE ELECTRONIC POWER STEERING SENSOR FAILS WHILE DRIVING AND SHUTS OFF THE POWER STEERING WITHOUT WARNING, OR A CHANCE TO PULL OFF THE ROAD. IF I MAKE IT TO THE SIDE OF THE ROAD WITHOUT BEING HIT, I CAN RESTART MY CAR AND THE POWER STEERING COMES BACK ON. BY DEFAULT THE COMPUTER SHUTS OFF THE POWER STEERING TO PREVENT DAMAGE TO THE CAR. GM HAS MADE THE DECISION THAT A $900 POWER STEERING SENSOR IS WORTH MORE THAN MY LIFE. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 45 MPH, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. THE FAILURE OCCURRED APPROXIMATELY THREE TIMES WHILE DRIVING. THE DEALER STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED AND THE POWER STEERING WILL NEED TO BE REPROGRAMMED AT A 50% OFF …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 45 MPH, THE POWER STEERING LIGHT ILLUMINATED AND THE POWER STEERING FAILED. THE FAILURE OCCURRED APPROXIMATELY THREE TIMES WHILE DRIVING. THE DEALER STATED THAT THE STEERING COLUMN NEEDED TO BE REPLACED AND THE POWER STEERING WILL NEED TO BE REPROGRAMMED AT A 50% OFF DISCOUNT. THE CURRENT MILEAGE WAS 59,950 AND FAILURE MILEAGE WAS 56,322.
EVENTS LEADING UP TO COMPLAINT OF '05 CHEVROLET COBALT STEERING PROBLEMS: THE COBALT WAS UNDER WARRANTY & GM ROAD SIDE ASSISTANCE WAS CALL FOR EACH FAILURES. 3 TIMES THE POWER STEERING WENT OUT. AFTER THE FIRST 2 FAILURES THERE WAS NOT ANY CHANGE IN THE SENSITIVITY OF THE STEERING. 12/2/07 FAILURE #1 @ I-75 NEAR ADEL DRIVE…
Read full complaint
EVENTS LEADING UP TO COMPLAINT OF '05 CHEVROLET COBALT STEERING PROBLEMS: THE COBALT WAS UNDER WARRANTY & GM ROAD SIDE ASSISTANCE WAS CALL FOR EACH FAILURES. 3 TIMES THE POWER STEERING WENT OUT. AFTER THE FIRST 2 FAILURES THERE WAS NOT ANY CHANGE IN THE SENSITIVITY OF THE STEERING. 12/2/07 FAILURE #1 @ I-75 NEAR ADEL DRIVER WAS ABLE TO DRIVE THE CAR TO THE NEXT EXIT (EXIT 39). GM SENT THE CAR TO PRINCE AUTOMOTIVE IN VALDOSTA, GA FOR REPAIR. PRINCE AUTO. REPLACED THE STEERING COLUMN. 12/14 THE CAR WAS DRIVEN FROM S. GA TO ATL. 12/24 FAILURE #2 @ GAHWY 141 IN DULUTH. GM SENT THE CAR TO BILL HEARD CHEVROLET IN KENNESAW, GA (WHERE CAR WAS PURCHASE NEW) FOR REPAIR. 12/26 BILL HEARD DETERMINED THE PROBLEM WAS IN THE COMMUNICATION BETWEEN THE COMPUTER & STEERING COLUMN. 12/31 FAILURE #3 @ CAMP CREEK PKWY & FULTON IND. GM SENT THE CAR BACK TO BILL HEARD FOR REPAIR. BILL HEARD REPLACED THE STEERING COLUMN WITH A DIFFERENT STEERING COLUMN. SERVICE TECH @ BILL HEARD SAID THERE WAS AN ISSUE WITH THE ORIGINAL MANUFACTURE OF THE STEERING COLUMN, GM HAS A NEW VENDOR. PRINCE AUTO. HAD REPLACED THE COLUMN WITH ONE FROM THE ORIGINAL MANUFACTURE. BILL HEARD REPLACED THE STEERING COLUMN WITH ONE FROM THE NEW MANUFACTURE. 1/8-9/08 DURING DAILY COMMUTE TO WORK NOTICED MORE SENSITIVITY OF THE STEERING. THE CAR WAS MORE SENSITIVE WHEN DRIVING THROUGH A CURVE IN THE ROAD OR OVER BUMPS AND/OR POTHOLES. 1/19 CAR RETURNED TO DRIVER IN S. GA., SHE NOTICED A MORE SENSITIVE STEERING RESPONSE DURING HER AROUND TOWN DRIVING. 2/1/08 GA HWY 221: DRIVER SWERVED RIGHT TO MISS SOMETHING IN THE ROAD; CAR WENT OFF ONTO THE RIGHT SHOULDER. WHEN CORRECTIVE ACTION WAS TAKEN, THE COBALT WENT INTO A SPIN HITTING AN ON COMING VEHICLE. THE COBALT'S FRONT AIRBAGS WERE DEPLOYED, FRONT DOORS, JAMMED; THE COBALT DRIVER & PASSENGER ESCAPED THROUGH THE DRIVER SIDE WINDOW, THE CAR WAS ENGULFED IN FLAMES WITHIN 3 MINUTES FROM IMPACT. THE OTHER DRIVER VEHICLE DIED IN THE ACCIDENT. *TR
POWER STEERING IS FAILING CONSTANTLY WHEN DRIVING. THE POWER STEERING WORDS COME UP ON THE DASH AND THEN IT QUITS--VERY DANGEROUS IF IT HAPPENS SUDDENLY DURING A TURN. SO FAR, I'M FORTUNATE THAT IT HAPPENS ONLY WHEN DRIVING STRAIGHT. WHEN I TURN CAR OFF AND RESTART IT'S O.K. FOR 5 OR 10 MINUTES. I HAVE 53,000 MILES ON CAR. …
Read full complaint
POWER STEERING IS FAILING CONSTANTLY WHEN DRIVING. THE POWER STEERING WORDS COME UP ON THE DASH AND THEN IT QUITS--VERY DANGEROUS IF IT HAPPENS SUDDENLY DURING A TURN. SO FAR, I'M FORTUNATE THAT IT HAPPENS ONLY WHEN DRIVING STRAIGHT. WHEN I TURN CAR OFF AND RESTART IT'S O.K. FOR 5 OR 10 MINUTES. I HAVE 53,000 MILES ON CAR. FROM WHAT I'VE READ ONLINE, THEY WILL TELL ME IT NEEDS A NEW STEERING COLUMN AND IT WILL COST BETWEEN $1200 AND $2,000 TO REPAIR! VERY UNHAPPY, VERY CONCERNED FOR SAFETY AND NOW, OUT OF WARRANTY, WILL HAVE TO PAY THAT MUCH FOR SOMETHING THAT SURE SOUNDS LIKE A MAJOR SAFETY DEFECT? *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.