IllustrationTL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING AT ANY SPEED, THE ELECTRIC POWER STEERING SHUTS DOWN. THE CONTACT STATED THAT THE WARNING LIGHT BLINKS TWICE AND THEN THE POWER STEERING FAILS AND BECOMES DIFFICULT TO STEER. THE FAILURE MILEAGE WAS 68,000. UPDATED 10/16/08 *BF UPDATED 10/21/08. *JB
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Steering complaints
1,143 reportsON 9/3/08 MY HUSBAND AND I WERE DRIVING OUR 2005 CHEVY COBALT WITH 45,700 MILES ON IT GOING 35 MPH, WE CAME TO A CURVE IN THE ROAD AND THE WARNING LIGHT IN OUR CAR WENT OFF AND IT READ, "POWER STEERING", WE THEN LOST ALL POWER STEERING. MY HUSBAND VEERED OFF THE ROAD BECAUSE IT WAS HARD TO STEER, WE THEN TURNED THE CAR OFF HOPIN…
Read full complaint
ON 9/3/08 MY HUSBAND AND I WERE DRIVING OUR 2005 CHEVY COBALT WITH 45,700 MILES ON IT GOING 35 MPH, WE CAME TO A CURVE IN THE ROAD AND THE WARNING LIGHT IN OUR CAR WENT OFF AND IT READ, "POWER STEERING", WE THEN LOST ALL POWER STEERING. MY HUSBAND VEERED OFF THE ROAD BECAUSE IT WAS HARD TO STEER, WE THEN TURNED THE CAR OFF HOPING IT WOULD CLEAR THE ERROR. WE STARTED THE CAR AND IT THEN DROVE FINE. WHEN WE GOT TO WHERE WE WERE GOING WE DECIDED TO CHECK THE POWER STEERING FLUID BUT COULDN'T FIND WHERE IT WAS. WE LOOKED IN OUR OWNER'S MANUAL AND IT STATED THAT IT WAS ELECTRICAL AND THERE WAS NO FLUID. THE NEXT DAY ON THE INTERSTATE AT 60 MPH DRIVING TO WORK THE WARNING LIGHT WENT OFF AND IT READ, "POWER STEERING", MY HUSBAND MAINTAINED CONTROL AND IT NEVER REGAINED POWER STEERING. FROM THAT INCIDENT ON EVERY TIME WE DROVE IT KEPT HAPPENING AND WE WOULD NEVER REGAIN POWER STEERING UNTIL WE TURNED THE CAR OFF AND RESTARTED IT. FIRST THING MONDAY MORNING 9/8/08 WE TOOK IT TO THE DEALERSHIP. THEY TOLD US THERE WAS AN INTERNAL FAULT IN THE STEERING COLUMN MOTOR AND THEY NEEDED TO REPLACE THE ELECTRONIC COLUMN. I ASKED IF THERE HAD BEEN A RECALL BECAUSE I FOUND HUNDREDS OF INCIDENTS WITH THE SAME PROBLEM WITH OUR SAME VEHICLE, MAKE AND YEAR ON THE INTERNET. THE DEALERSHIP CLAIMED THIS IS THE FIRST THEY HAD HEARD OF. I TOLD THE DEALERSHIP THAT WHEN THEY REPLACED MY MOTOR I WANTED THE FAULTY ONE BACK. THEY GOT AN ATTITUDE QUICKLY AND TOLD ME THAT I COULDN'T HAVE THE OLD PART BECAUSE IT WAS UNDER GM WARRANTY. I THEN ASKED IF THAT'S THE CASE THEN WHY DO I HAVE TO PAY FOR THIS NEW PART BECAUSE MY OLD ONE IS OBVIOUSLY FAULTY. THEY TOLD ME IT WAS PART OF GM POLICY AND I COULD NOT HAVE THE OLD PART. AFTER THAT IT MADE US VERY SUSPICIOUS AS TO WHY THEY WOULDN'T LET US TAKE THE OLD PART. I TOLD THEM THIS WAS A SAFETY ISSUE ENDANGERING PEOPLE'S LIVES THAT NEEDED TO BE ADDRESSED. I CONTACTED THE GM CORPORATE OFFICE AND THEY GAVE ME THE SAME SPILL THAT THEY HAVEN'T HEARD OF THIS ISSUE. *TR
2005 COBOLT POWER STEERING BLEW FUSES. NOW LIGHT COMES ON CAR JUMPS TRIES TO DIE ON ME. POWER STEERING LIGHT COMES ON. *TR
TWO WEEKS AGO MY 2005 COBALT LS SEDAN SUDDENLY STARTING HAVING PROBLEMS WITH THE POWER STEERING. WHILE DRIVING MY WARNING LIGHT DISPLAYED "POWER STEERING" AND I NOTICED THAT TRYING TO STEER THE WHEEL WAS EXTREMELY DIFFICULT. I DROVE TO A SAFE PLACE AND TURNED THE CAR OFF AND THEN RESTARTED IT AND THE POWER STEERING WAS WORKING F…
Read full complaint
TWO WEEKS AGO MY 2005 COBALT LS SEDAN SUDDENLY STARTING HAVING PROBLEMS WITH THE POWER STEERING. WHILE DRIVING MY WARNING LIGHT DISPLAYED "POWER STEERING" AND I NOTICED THAT TRYING TO STEER THE WHEEL WAS EXTREMELY DIFFICULT. I DROVE TO A SAFE PLACE AND TURNED THE CAR OFF AND THEN RESTARTED IT AND THE POWER STEERING WAS WORKING FINE. I AM NOTICING THAT THE TIME THE POWER STEERING IS WORKING CORRECTLY IS GETTING TO BE LESS AND LESS. THIS PROBLEM IS VERY DANGEROUS AND SOMEONE COULD GET SERIOUSLY HURT OR KILLED IF CHEVROLET CONTINUES TO IGNORE THE PROBLEM. *TR
2005 COBALT, 40K MILES. ELECTRIC POWER ASSIST STEERING SYSTEM GOING OUT. LIGHT COMES ON SOMETIMES AND POWER STEERING WILL GO OUT. WILL STOP CAR, AND SOMETIMES THIS STOPS. MOSTLY BAD ON HOT DAYS. OUT OF WARRANTY, RESEARCHING WILL COST ME 1,200 TO 2,000. UNDERSTAND THIS IS A KNOWN ISSUE. WHY ISN'T THERE A RECALL. I HAVE A 3 YEAR O…
Read full complaint
2005 COBALT, 40K MILES. ELECTRIC POWER ASSIST STEERING SYSTEM GOING OUT. LIGHT COMES ON SOMETIMES AND POWER STEERING WILL GO OUT. WILL STOP CAR, AND SOMETIMES THIS STOPS. MOSTLY BAD ON HOT DAYS. OUT OF WARRANTY, RESEARCHING WILL COST ME 1,200 TO 2,000. UNDERSTAND THIS IS A KNOWN ISSUE. WHY ISN'T THERE A RECALL. I HAVE A 3 YEAR OLD AND BRAND NEW BABY GRAND DAUGHTER. I SHUDDER TO THINK WHAT WILL HAPPEN IF THIS GOES OUT WHILE THEY ARE IN MY CAR. THEY LIVE WITH ME. THIS IS HORRIBLY DANGEROUS. THEY WONT RECALL IT, BUT MAKE THE PART SO EXPENSIVE YOU CANT AFFORD IT. NO OTHER PART EVER COST THAT MUCH IN MY LIFE UNLESS I WAS REPLACING AN ENGINE. I AM ASKING THAT THEY RECALL THIS PART ASAP BEFORE SOMEONE GETS KILLED. YOU NEVER KNOW WHEN IT WILL JUST STOP WORKING, AND LOOSE POWER AND OR CONTROL OF YOUR CAR. I PRAY THAT MYSELF OR MY GRANDCHILDREN CAN LIVE THROUGH THIS LONG ENOUGH TO SAVE THE MONEY TO MAKE THIS RIDICULOUSLY EXPENSIVE REPAIR. I CANT JUST NOT DRIVE IT. IT IS OUR ONLY CAR. PLEASE PLEASE INVESTIGATE THIS PART IN THE COBALT AND FROM WHAT I HEAR A FEW OTHER CAR MAKES. IT IS THE SCARIEST THING IN THE WORLD TO LOOSE POWER WHILE DRIVING. AND EXTREMELY DANGEROUS. THANK YOU *TR
2005 CHEVROLET COBALT - POWER STEERING WARNING MESSAGE COMES ON AND EVENTUALLY CAUSED THE CAR TO STALL OR SHAKE. *TR
MY FAMILY WERE DRIVING IN OUR 2005 CHEVROLET COBALT. AS WE MADE A TURN OFF THE HIGHWAY THE POWER STEERING WENT OUT. MY CAR CAREENED OFF THE ROAD AND OFF INTO THE MEDIAN. MY ONE CHILD HAD A SMALL HEAD INJURY FROM THE ACCIDENT. LUCKILY WE WERE NOT TURNING INTO TRAFFIC AT THE TIME, SOME ONE WOULD HAVE BEEN KILLED. AFTER RESEARCHING…
Read full complaint
MY FAMILY WERE DRIVING IN OUR 2005 CHEVROLET COBALT. AS WE MADE A TURN OFF THE HIGHWAY THE POWER STEERING WENT OUT. MY CAR CAREENED OFF THE ROAD AND OFF INTO THE MEDIAN. MY ONE CHILD HAD A SMALL HEAD INJURY FROM THE ACCIDENT. LUCKILY WE WERE NOT TURNING INTO TRAFFIC AT THE TIME, SOME ONE WOULD HAVE BEEN KILLED. AFTER RESEARCHING THIS ISSUE I HAVE FOUND THE POWER STEERING ON THE CHEVROLET COBALT HAVE A HIGH RATE OF FAILURE. I WOULD LIKE TO KNOW HOW MANY PEOPLE HAVE TO BE SERIOUSLY INJURED BEFORE THIS ISSUE IS RESOLVED THROUGH A RECALL OF THE VEHICLES TO CORRECT THE PROBLEM. *TR
AIR BAG LIGHT IS ON CONTINUOUSLY AND NOW THE POWER STEERING LIGHT GOES ON AND YOU LOOSE STEERING AS YOU ARE DRIVING. THE AIR BAG LIGHT WAS FIXED 1 TIME BY DEALER AND NOW IT IS ON AGAIN AND THEY SAY THEY WILL NOT FIX IT BECAUSE IT HAS BEEN TAMPERED WITH BUT THEY ARE THE ONLY ONE'S TO WORK ON IT I HAVE MY REPAIR INVOICE. THE POWER…
Read full complaint
AIR BAG LIGHT IS ON CONTINUOUSLY AND NOW THE POWER STEERING LIGHT GOES ON AND YOU LOOSE STEERING AS YOU ARE DRIVING. THE AIR BAG LIGHT WAS FIXED 1 TIME BY DEALER AND NOW IT IS ON AGAIN AND THEY SAY THEY WILL NOT FIX IT BECAUSE IT HAS BEEN TAMPERED WITH BUT THEY ARE THE ONLY ONE'S TO WORK ON IT I HAVE MY REPAIR INVOICE. THE POWER STEERING LIGHT JUST STARTED COMING ON AND NOW YOU LOOSE STEERING AS SOON AS IT GOES ON. IT ALMOST CAUSED AN ACCIDENT THE FIRST TIME IT HAPPENED BECAUSE I WAS GOING AROUND A CURVE AND A CAR WAS COMING THE OTHER WAY AND I LOST MY STEERING. LUCKILY I DIDN'T HIT THE OTHER CAR BUT I THINK THIS IS A MAJOR SAFETY HAZARD. *TR
ON SATURDAY, AUGUST 16TH, 2008 I WAS DRIVING ON THE HIGHWAY GOING ABOUT 55-60 MPH AND AS I WAS SLOWING DOWN TO APPROACH A LEFT TURN, A CHIME NOISE SOUNDED AND THE "POWER STEERING" MESSAGE CAME ON AND AS I WAS IN MY LEFT TURN, THE POWER STEERING COMPLETELY WENT OUT AND MADE MY CAR ALMOST IMPOSSIBLE TO TURN THE WHEEL. I PULLED INT…
Read full complaint
ON SATURDAY, AUGUST 16TH, 2008 I WAS DRIVING ON THE HIGHWAY GOING ABOUT 55-60 MPH AND AS I WAS SLOWING DOWN TO APPROACH A LEFT TURN, A CHIME NOISE SOUNDED AND THE "POWER STEERING" MESSAGE CAME ON AND AS I WAS IN MY LEFT TURN, THE POWER STEERING COMPLETELY WENT OUT AND MADE MY CAR ALMOST IMPOSSIBLE TO TURN THE WHEEL. I PULLED INTO A SERVICE/GAS STATION RIGHT DOWN THE ROAD AND TRIED TURNING OFF MY CAR TO SEE IF THAT WOULD HELP. ONCE I RESTARTED MY CAR THE POWER STEERING MESSAGE WAS NO LONGER ON AND THE STEERING WHEEL WENT BACK TO NORMAL. THIS SAME PROBLEM OCCURRED ONCE THE NEXT DAY. AS THE DAYS WENT ON, THE PROBLEM GOT MORE AND MORE FREQUENT TO THE EXTENT OF NOW IT HAPPENS LIKE FOUR OR FIVE TIMES A DAY. TO GET THE POWER STEERING TO WORK ONCE IT GOES OUT, I HAVE TO EITHER RESTART MY CAR AT REDLIGHTS, STOP SIGNS, OR SOMETIMES EVEN IN THE MIDDLE OF THE ROAD. THIS IS A VERY DANGEROUS PROBLEM THAT NEEDS TO BE ADDRESSED BY GM. I TOOK MY CAR TO A GM DEALERSHIP LAST FRIDAY AND I WAS TOLD MY STEERING COLUMN NEEDED TO BE REPLACED. I HAVE RESEARCHED THIS ISSUE, AND I SEE IT IS AN ONGOING PROBLEM WITH GM. I HAVE NOTIFIED THE CUSTOMER SERVICE DEPARTMENT AT GM AND AM AWAITING A CALL BACK FROM THEM TO SEE HOW THEY CAN ACCOMMODATE ME WITH THIS SITUATION. *TR
MY 2005 COBALT HAS HAD ELECTRICAL AND POWER STEERING PROBLEMS EVER SINCE I LEASED IT. INTERMITTENTLY, WHILE DRIVING, THE INSTRUMENT MESSAGES START FLASHING (USUALLY "POWER STEERING"). THE CAR THEN BECOMES VERY HARD TO STEER AND BRAKE, THE ENGINE SURGES UP AND DOWN. ON AUG 3RD THE CAR WAS INVOLVED IN A MINOR ACCIDENT WHEN IT W…
Read full complaint
MY 2005 COBALT HAS HAD ELECTRICAL AND POWER STEERING PROBLEMS EVER SINCE I LEASED IT. INTERMITTENTLY, WHILE DRIVING, THE INSTRUMENT MESSAGES START FLASHING (USUALLY "POWER STEERING"). THE CAR THEN BECOMES VERY HARD TO STEER AND BRAKE, THE ENGINE SURGES UP AND DOWN. ON AUG 3RD THE CAR WAS INVOLVED IN A MINOR ACCIDENT WHEN IT WAS STEERED INTO A CURB, POSSIBLY CAUSED BY ANOTHER EQUIPMENT FAILURE. I TOOK THE CAR IN TO A CHEVROLET DEALER AGAIN, WHEN IT FAILED AGAIN TWO MORE TIMES AFTER THE ACCIDENT. BOTH TIMES THE DEALER FOUND ERROR CODES. HOWEVER, THEY SAID THEY HAD A "TSB" ON THIS PROBLEM, FROM CHEVROLET WHICH SAYS TO JUST CLEAR THE LOGS, GIVE THE CAR BACK TO THE CUSTOMER AND TO "PERFORM NO WORK". THEY ARE PUTTING LIVES IN DANGER BY FOLLOWING THIS PROCEDURE. I HAVE COPIES OF THE SERVICE ORDERS TO CONFIRM MY STATEMENT. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.