IllustrationTHE POWER STEERING CONTINUES TO FAIL WHILE DRIVING ON A 2005 CHEVY COBALT, THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS VEHICLE AND POWER STEERING. IT IS VERY UNSAFE TO DRIVE. THERE NEEDS TO BE A RECALL OF THIS COMPONENT. *TR
2005 Chevrolet Cobalt
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cobalt years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1780–25K
29325–50K
41350–75K
22775–100K
198100–150K
98150K+
1,407 reports with mileage · 242 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 1,143 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 323 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 99 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
97 crash reports12 fire reports57 injury reports
Steering complaints
1,143 reportsWHILE DRIVING THE CAR A "POWER STEERING" WARNING CAME ON AND THE POWER STEERING STOPPED WORKING. THE CAR BECAME VERY DIFFICULT TO STEER. THIS IS THE SECOND THE MESSAGE CAME ON IN THE LAST MONTH BUT THE FIRST TIME IT WENT OFF AND THERE WAS NO STEERING PROBLEMS. THE CAR WAS DIAGNOSED BY A LOCAL DEALER AS NEEDING A NEW ELECTRIC POW…
Read full complaint
WHILE DRIVING THE CAR A "POWER STEERING" WARNING CAME ON AND THE POWER STEERING STOPPED WORKING. THE CAR BECAME VERY DIFFICULT TO STEER. THIS IS THE SECOND THE MESSAGE CAME ON IN THE LAST MONTH BUT THE FIRST TIME IT WENT OFF AND THERE WAS NO STEERING PROBLEMS. THE CAR WAS DIAGNOSED BY A LOCAL DEALER AS NEEDING A NEW ELECTRIC POWER STEERING MOTOR. THE CAR IS SCHEDULED FOR REPAIR THIS WEEK. *TR
I WAS RECENTLY TRAVELING ON THE HIGHWAY WHEN THE STEERING WHEEL BECAME STIFF AND HARD TO MANEUVER. I LOOKED DOWN AT THE WARNING PANEL AND IT HAD LIGHTED UP "POWER STEERING". MY CAR IS A 2005 CHEVY COBALT WITH 45,000 MILES. I READ ON THE INTERNET ABOUT OTHER 2005 COBALT OWNERS HAVING THE SAME PROBLEM AROUND 40,000 MILES. I TO…
Read full complaint
I WAS RECENTLY TRAVELING ON THE HIGHWAY WHEN THE STEERING WHEEL BECAME STIFF AND HARD TO MANEUVER. I LOOKED DOWN AT THE WARNING PANEL AND IT HAD LIGHTED UP "POWER STEERING". MY CAR IS A 2005 CHEVY COBALT WITH 45,000 MILES. I READ ON THE INTERNET ABOUT OTHER 2005 COBALT OWNERS HAVING THE SAME PROBLEM AROUND 40,000 MILES. I TOOK IT IN TO A CHEVY DEALER TELLING THEM THAT IT APPEARS THAT THIS IS A FLAW WITH THE 2005 COBALT BUT THEY SAID THERE HAS BEEN NO RECALL ON THE ELECTRIC POWER STEERING SYSTEM AND THAT I WOULD HAVE TO PAY SEVERAL HUNDREDS OF DOLLARS TO HAVE THE EPS MODULE REPLACED. I FEEL THAT IT IS UNFAIR TO HAVE SOMETHING SO EXPENSIVE TO GO OUT ON YOUR VEHICLE WHEN IT IS STILL FAIRLY NEW AND HAVE THE SAME THING HAPPEN TO OTHERS BUT YET WE ARE LEFT TO PAY FOR AN APPARENTLY WELL KNOW FLAW IN THE CHEVY COBALT THAT GM DOES NOT WANT TO ADMIT EXITS. *TR
POWER STEER CUTS OUT AND DOES NOT COME BACK UNTIL CAR IS RESTARTED. HAPPENS RANDOM TIMING EVERY TRIP. CHEVY QUOTED 800.00 TO REPAIR STATING THAT THE STEERING COLUMN NEEDS TO BE REPLACED. *TR
THE INCIDENT DATE BELOW WAS THE FIFTH TIME THIS HAS OCCURRED. FIRST NOTICED TRACTION CONTROL AND POWER STEERING LIGHT COMING ON-THE CAR "BUCKS" AND POWER STEERING IS LOST-SEVERAL TIMES CAR WILL LOSE POWER AND HAVE TO BE RESTART. AFTER RESTART WARNING LIGHTS WILL GO AWAY AND POWER STEERING RETURNS. SEEMS TO COME BACK TO NORMAL …
Read full complaint
THE INCIDENT DATE BELOW WAS THE FIFTH TIME THIS HAS OCCURRED. FIRST NOTICED TRACTION CONTROL AND POWER STEERING LIGHT COMING ON-THE CAR "BUCKS" AND POWER STEERING IS LOST-SEVERAL TIMES CAR WILL LOSE POWER AND HAVE TO BE RESTART. AFTER RESTART WARNING LIGHTS WILL GO AWAY AND POWER STEERING RETURNS. SEEMS TO COME BACK TO NORMAL AFTER RESTART, RUNS OK UNTIL THE PROCESS STARTS AGAIN. THE CAR WAS PURCHASED MAY 08 AND FIRST INCIDENT WAS AUG 15 2008-TOOK TO DEALER AND THEY RESET THE COMPUTER, SECOND AND THIRD TIME THE CAR SEEMED OK UNTIL THE 4TH INCIDENT AND RETURNED TO DEALER AGAIN AND RESET AGAIN. I WAS TOLD THAT THE COMPUTER CODES WERE SHOWING U2105 AND U2100 U2107 AND CAR RETURNED. THIS LAST INCIDENT (12-11-08) THE CAR WAS DOING THE SAME THING AND DROVE RIGHT TO DEALER TO SHOW SERVICE WHAT THE CAR WAS DOING. THEY CLAIMED THE CAR IS EQUIPPED WITH ELECTRIC STEERING COLUMN AND IT DISENGAGES FROM THE COMPUTER AND THE STEERING COLUMN NEEDED TO BE REPLACED AND A COMPUTER MODULE. GAVE THEM PERMISSION TO CORRECT THIS BECAUSE I CAN'T LET MY SON DRIVE A CAR KNOWING AT ANYTIME HE WILL LOSE POWER STEERING. HE HAS BEEN LUCKY HE WAS TRAVELING AT LOW SPEEDS WHEN THIS OCCURS. IF HE WAS ON A HIGHWAY AND IN FRONT OF A TRACTOR TRAILER AND LOST POWER HE MIGHT BE KILLED BECAUSE HE WOULD LOSE PS AND STALL. THIS IS A SAFETY-RELATED DEFECT IN THE VEHICLE EQUIPMENT (ELECTRIC POWER STEERING COLUMN) WHEN AT ANY TIME WITH NO WARNING YOU CAN LOSE YOUR STEERING, STALL AND/OR BUCK. UPON FURTHER RESEARCH INTO THE 2005 COBALT, I HAVE FOUND 805 COMPLAINTS REGARDING THE STEERING COLUMN AND THE PROBLEMS OF CONTROLLING THE CAR WHEN THIS HAPPENS. UPON FURTHER RESEARCH THE MALIBU IS HAVING THE SAME ISSUES WITH STEERING. GUESS WHAT KIND OF STEERING IS IN THE MALIBU. CHECK "WWW.ABOUTAUTOMOBILE.COM" FOR COMPLAINTS REGARDING STEERING COLUMN. SEVERAL PEOPLE HAVE DESCRIBED INCIDENTS WHERE THEIR SAFETY WAS COMPROMISED. PLEASE HELP GM REP CLAIMS CAN'T RECALL COLUMN WITHOUT YOU. PLEASE HELP *TR
DRIVING THE CAR, AND THEN, NO POWER STEERING. CALLED MECHANIC TOLD "DIDN'T WANT TO TOUCH EPS SYSTEM. CALLED DEALER TOLD TO BRING IN TO LOOK AT. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 50 MPH, THE CONTACT CHANGED LANES QUICKLY TO AVOID ANOTHER VEHICLE AND THE STEERING LOCKED. THE CONTACT ATTEMPTED TO MAINTAIN CONTROL OF THE VEHICLE, BUT HE SPUN OUT TWICE AND EVENTUALLY PULLED OFF THE ROAD. THE DAY BEFORE THE FAILURE, THE POWER STEERING INDICATOR ILL…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 50 MPH, THE CONTACT CHANGED LANES QUICKLY TO AVOID ANOTHER VEHICLE AND THE STEERING LOCKED. THE CONTACT ATTEMPTED TO MAINTAIN CONTROL OF THE VEHICLE, BUT HE SPUN OUT TWICE AND EVENTUALLY PULLED OFF THE ROAD. THE DAY BEFORE THE FAILURE, THE POWER STEERING INDICATOR ILLUMINATED FOR TWO SECONDS ON THE INSTRUMENT PANEL. THE CONTACT FOUND NUMEROUS COMPLAINTS REGARDING THIS COMPONENT. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 35,300. UPDATED 12/30/08. *LJ UPDATED 01/05/09.*JB
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 25 MPH, THE CONTACT HEARD A CHIME FROM THE INSTRUMENT PANEL, WHICH INDICATED THAT THE POWER STEERING WAS FAILING AND THE STEERING WHEEL LOCKED. THE DEALER STATED THAT THE POWER STEERING SYSTEM WAS FAULTY. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE COST. SHE FELT TH…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 25 MPH, THE CONTACT HEARD A CHIME FROM THE INSTRUMENT PANEL, WHICH INDICATED THAT THE POWER STEERING WAS FAILING AND THE STEERING WHEEL LOCKED. THE DEALER STATED THAT THE POWER STEERING SYSTEM WAS FAULTY. THE VEHICLE HAS NOT BEEN REPAIRED DUE TO THE COST. SHE FELT THAT THE VEHICLE WAS VERY UNSAFE TO DRIVE BECAUSE THE POWER STEERING COULD LOCK AT ANY MOMENT WHILE DRIVING. THE CURRENT MILEAGE WAS 53,834 AND FAILURE MILEAGE WAS 46,000.
'05 COBALT: FAILURE OF ELECTRIC POWER STEERING WHILE DRIVING. CONDITION WILL CLEAR BY TURNING CAR OFF THEN RESTARTING, BUT FAILS AGAIN WHILE DRIVING. THIS APPEARS TO BE A COMMON PROBLEM WITH COBALTS, BUT GM WON'T ISSUE A RECALL. PLEASE DON'T WAIT FOR THIS TO BECOME AN ACCIDENT! *TR
WHILE DRIVING AT ANY SPEED, THE POWER STEERING INTERMITTENTLY SHUTS OFF. THE FAILURE PROGRESSIVELY WORSENED OVER TIME. THIS CAUSES EXTREME DIFFICULTY IN TURNING, ESPECIALLY SCARY IN URGENT SITUATIONS WITH CHILDREN IN THE VEHICLE. *TR
Official recalls
514V171000 · Electrical System:ignition
Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
14V047000 · Air Bags; Electrical System:ignition:switch
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
10V073000 · Steering:electric Power Assist System
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
07V014000 · Structure
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
04V560000 · Exterior Lighting:headlights
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE10005 · Electric Power Steering Failure
Opened Jan 27, 2010 · Closed Jul 19, 2010
Status: closed (inferred from source dates) · Steering:electric Power Assist System
In a March 1, 2010 letter, General Motors Corporation (GM) provided a defect information report to NHTSA regarding a problem that could result in sudden loss of power steering assist in certain model year (MY) 2005 through 2010 Chevrolet Cobalt and MY 2007 through 2010 Pontiac G5 vehicles equipped with electric power steering (EPS).The letter indicates that the loss of steering assist could occur at any time while driving and that, once assist is lost, a message is displayed on the Driver Information Center (DIC) and a chime sounds to inform the driver.The letter further states that steering control is maintained in manual mode, but would require greater driver effort at low vehicle speeds.In the next ignition cycle, power assist is typically regained and the DIC message is no longer displayed.GM's letter identifies the root cause of the EPS failure as the EPS motor and indicates that production of a new motor started in December 2009.GM's recall repair procedure instructs dealers to replace the EPS motor in all recalled vehicles. ODI's analysis of all information available related to sudden loss of EPS assist while driving in the MY 2005 through 2009 Chevrolet Cobalt vehicles shows current complaint and warranty rates of 323/100,000 vehicles and 0.4% respectively.In response to ODI's request for information, GM identified 81 complaints where a crash was claimed that may be related to loss of EPS assist.ODI's analysis of all crash claims was based on verifiable factors such as; whether a loss of EPS was indicated at the time of the crash by a chime or malfunction indicator lamp or if a EPS related component malfunction was identified after the crash occurred.With this method ODI identified 36 possible crashes related to EPS failure.GM assessed crash claims based on the available facts and excluded crash claims that indicated that the vehicle was travelling at speeds in the range of 30 mph or greater.GM said that it believes if power assist is lost while a vehicle is moving at speeds in the range of 30 mph or greater there is a small difference in steering efforts perceived in subjective evaluations at those speeds and it is unlikely to lead to loss of vehicle control. Based on GM's safety recall, this investigation is closed.