NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
69 reportsClear category filter173,450 miles · Aug 5, 2017
Electronic Stability Control (esc)EngineSteering
THE TRACTION CONTROL SYSTEM LIGHT ON MY CHEVROLET COBALT 2005 STAYS ON AND DOES NOT TURN OFF UNTIL I SHUT OFF THE ENGINE. THE CHECK ENGINE LIGHT ALSO STAYS ON AS WELL AT THE SAME TIME THE TRACTION CONTROL SYSTEM LIGHT IS ON, SO NOT SURE IF THESE TWO ISSUES ARE RELATED. I ALSO NOTICE THAT THE VEHICLE JERKS PERIODICALLY WHEN I A…
Read full complaint
THE TRACTION CONTROL SYSTEM LIGHT ON MY CHEVROLET COBALT 2005 STAYS ON AND DOES NOT TURN OFF UNTIL I SHUT OFF THE ENGINE. THE CHECK ENGINE LIGHT ALSO STAYS ON AS WELL AT THE SAME TIME THE TRACTION CONTROL SYSTEM LIGHT IS ON, SO NOT SURE IF THESE TWO ISSUES ARE RELATED. I ALSO NOTICE THAT THE VEHICLE JERKS PERIODICALLY WHEN I AM ON THE ROAD AND THERE IS ROUGH SHIFTING OF GEARS.
NHTSA ODI #11013021
80,000 miles · Jul 31, 2017
Electrical SystemEnginePower Train
VEHICLE WOULDN'T START. LIKE THE BATTERY WAS DEAD, WOULDN'T EVEN TRY TO TURN OVER. GO TO TURN THE KEY OFF AND POP MY TRUNK WHERE THE BATTERY IS LOCATED AND I CAN NOT GET MY KEY TO TURN ALL THE WAY BACK TO THE OFF POSITION, AS A RESULT I CANNOT REMOVE MY KEY. THE SPEEDOMETER READ 30MPH EVEN THOUGH THE VEHICLE NEVER STARTED AND WA…
Read full complaint
VEHICLE WOULDN'T START. LIKE THE BATTERY WAS DEAD, WOULDN'T EVEN TRY TO TURN OVER. GO TO TURN THE KEY OFF AND POP MY TRUNK WHERE THE BATTERY IS LOCATED AND I CAN NOT GET MY KEY TO TURN ALL THE WAY BACK TO THE OFF POSITION, AS A RESULT I CANNOT REMOVE MY KEY. THE SPEEDOMETER READ 30MPH EVEN THOUGH THE VEHICLE NEVER STARTED AND WASN'T MOVING. NON OF THE ELECTRONICS WERE WORKING SO I WAS UNABLE TO POP MY TRUNK. THIS HAS HAPPENED SEVERAL TIMES BEFORE AND EVENTUALLY THE VEHICLE WILL START AND WHEN IT DOES THE BATTERY LIGHT STAYS ON AND THE DASH READS; ENGINE PERFORMANCE LOW. THE TRANSMISSION WILL SURGE AS I AM DRIVING AND I CANNOT GO FASTER THAN 30MPH. I HAVE EVEN HAD THE CAR SHUT OFF COMPLETLY WHILE I WAS DRIVING DOWN THE ROAD. AFTER ANYWHERE BETWEEN A FEW HOURS TO A FEW WEEKS THE VEHICLE WILL STOP ACTING UP AND DRIVE NORMAL FOR A WHILE. AGIAN THE NORMAL LASTS ANYWHERE BETWEEN A FEW HOURS TO A FEW MONTHS AS WELL. THE POWER STERING ALSO FLASHES ON THE DASH AND SOMETIMES CUTS COMPLEATLY OUT.
NHTSA ODI #11011812
149,769 miles · Oct 24, 2016
EngineSteering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 15 MPH, THE VEHICLE STALLED AND THE STEERING WHEEL WAS UNABLE TO MOVE. THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER THREE MINUTES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 15 MPH, THE VEHICLE STALLED AND THE STEERING WHEEL WAS UNABLE TO MOVE. THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER THREE MINUTES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 149,769.
NHTSA ODI #10918627
140,000 miles · Oct 7, 2016
Engine
TIMING CHAIN TENSER BOLT AND GUIDE BRAKES AND DESTROYS THE MOTOR ON CHEVROLET COBALT 2005 CAUSING THE CAR TO NOT START ALSO TURNS ON THE CHECK ENGINE LIGHT AND GOES TO LOW POWER MODE ALSO THE TRANSMISSION HAS PROBLEM TOO
NHTSA ODI #10914396
158,000 miles · Sep 27, 2016
Electrical SystemEnginePower Train
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE THE VEHICLE WAS STATIONARY, THE IGNITION KEY BECAME STUCK IN THE VEHICLE. ON ANOTHER OCCASION, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO THE REVERSE GEAR. IN ADDITION, THE VEHICLE WOULD NOT START WHEN PROMPTED. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE THE VEHICLE WAS STATIONARY, THE IGNITION KEY BECAME STUCK IN THE VEHICLE. ON ANOTHER OCCASION, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT INTO THE REVERSE GEAR. IN ADDITION, THE VEHICLE WOULD NOT START WHEN PROMPTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10909902
184,089 miles · Aug 15, 2016
EngineSteering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL POWER AND THE ENGINE WARNING LIGHTS ILLUMINATED. IN ADDITION, THE VEHICLE STALLED, BUT WAS ABLE TO BE RESTARTED AFTER FIVE TO TEN MINUTES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL POWER AND THE ENGINE WARNING LIGHTS ILLUMINATED. IN ADDITION, THE VEHICLE STALLED, BUT WAS ABLE TO BE RESTARTED AFTER FIVE TO TEN MINUTES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 184,089.
NHTSA ODI #10896101
77,439 miles · May 24, 2016
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. IN ADDITION, THE VEHICLE STALLED AND WAS ABLE TO BE RESTARTED, AND ALL THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CAUSE OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 40 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING LIGHT ILLUMINATED. IN ADDITION, THE VEHICLE STALLED AND WAS ABLE TO BE RESTARTED, AND ALL THE INSTRUMENT PANEL LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CAUSE OF THE FAILURES COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 77,439. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10870573
51,000 miles · Apr 14, 2016
EngineSteeringVehicle Speed Control
THIS ISSUE SEEMS TO BE A COMMON PROBLEM WITH THE 2005 COBALT. PLEASE RESEARCH ANY CAR COMPLAINT WEBSITES ABOUT THIS CERTAIN VEHICLE. EVEN THOUGH ALL THE RECALLS HAVE BEEN TAKEN CARE OF, WHILE IN MOTION, AT ANY TIME AND ANY SPEED, THE DASH LIGHTS STARTS FLASHING AND YOU GET THE MESSAGE POWER STEERING ON …
Read full complaint
THIS ISSUE SEEMS TO BE A COMMON PROBLEM WITH THE 2005 COBALT. PLEASE RESEARCH ANY CAR COMPLAINT WEBSITES ABOUT THIS CERTAIN VEHICLE. EVEN THOUGH ALL THE RECALLS HAVE BEEN TAKEN CARE OF, WHILE IN MOTION, AT ANY TIME AND ANY SPEED, THE DASH LIGHTS STARTS FLASHING AND YOU GET THE MESSAGE POWER STEERING ON MESSAGE CENTER, TC LIGHT COMES ON, LIGHT THAT SHOWS PADLOCK SYMBOL COMES ON, RPM NEEDLE JUMPS UP AND DOWN, STEERING WHEEL LOCKS UP, MOTOR SURGES AND SHAKES, AND YOU HEAR ALL TYPES OF CLICKING SOUNDS BELOW GEAR SHIFTER. THIS IS A VERY DANGEROUS THING AND CHEVROLET/GM JUST CANNOT SEEM TO FIX THIS ISSUE OR EVEN FIND ANYTHING WRONG. THE 2005 COBALT NEEDS TO BE RECALLED AND ANY OTHER YEAR OF COBALT HAVING THIS ISSUE. I WILL GIVE YOU BELOW THE LAST DATE THIS HAS HAPPENED, BUT THIS HAS WENT ON SINCE WE GOT THE CAR IN 2008. MY DAUGHTER IS IN SCHOOL IN KANSAS CITY, AND THIS ISSUE HAS HAPPENED QUITE FREQUENTLY LATELY. THE ONLY REMEDY IS TO PULL TO SIDE OF ROAD, SHUT OFF VEHICLE AND RESTART AND HOPE IT DOES NOT ACT UP AGAIN. I JUST WONDER HOW MAY DEATHS HAVE HAPPENED ALREADY BECAUSE OF THIS FAULTY GM PRODUCT AND NO ONE KNEW IT WAS BECAUSE OF WHAT THE COBALT DID, LOCKED UP ON ITS DRIVER.
NHTSA ODI #10855444
80,000 miles · Apr 7, 2016
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE CONTACT NOTICED FUEL FUMES EMITTING FROM THE INNER PART OF THE VEHICLE. IN ADDITION, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SOME TIME. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STA…
Read full complaint
TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE CONTACT NOTICED FUEL FUMES EMITTING FROM THE INNER PART OF THE VEHICLE. IN ADDITION, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AFTER SOME TIME. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE EXHAUST, OXYGEN SENSOR, THERMOSTAT AND OTHER UNKNOWN PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE FAILURE PERSISTED AS THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE REAR OF THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10853969
249,000 miles · Jan 18, 2016
EngineUnknown Or Other
I WAS DRIVING DOWN THE INTERSTATE, WHEN MY WARNING LIGHT CAME ON, AND SAID "ENGN PWR REDUCED" IT IMMEDIATELY SLOWED FROM 70 MPH, TO 10 MPH AND WOULDN'T REV PAST 2000 RPM'S. THE SOURCE CANNOT BE FOUND AS TO WHY IT HAPPENED AND ALMOST COST ME MY LIFE ON THE INTERSTATE.
NHTSA ODI #10820791
Official recalls
5Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Mar 3, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence & remedy
Consequence: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jan 18, 2007
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Consequence & remedy
Consequence: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Nov 22, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BULB SHIELDS INSIDE OF THE HEADLAMPS CAN LOOSEN DUE TO VIBRATION.
Consequence & remedy
Consequence: THE BULB SHIELD CAN LOOSEN OR BREAK BECAUSE OF VIBRATION. IF THIS OCCURRED ON A HEADLAMP INSTALLED IN A VEHICLE, ONCOMING DRIVERS MAY NOTICE ADDITIONAL GLARE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL TWO NEW HEADLAMP ASSEMBLIES. THE RECALL BEGAN ON NOVEMBER 17, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration