IllustrationON SUNNY DAYS THERE IS A GLARE THAT COMES FROM THE DASHBOARD TO WINDSHIELD, OBSTRUCTING DRIVERS VIEW. DEALER HAS BEEN NOTIFIED.*AK CONSUMER STATED DASHBOARD SHOULD BE DARK TO REDUCE REFLECTION. *YD
2000 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 2000 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2125–50K
3050–75K
2375–100K
16100–150K
8150K+
120 reports with mileage · 195 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports8 fire reports13 injury reports
What owners actually said
315 reportsTHE PLASTIC STRIP NEAR FRONT WINDOW ON DASH BOARD IS CRACKED IN TWO DIFFERENT PLACES. THERE WAS NO DAMAGE DONE TO THE VEHICLE TO CAUSE THIS TYPE OF DAMAGE. THE PLASTIC PIECE CRACKED ALL THE WAY UP TO THE WINDSHIELD.
WHILE DRIVING ENGINE CHECK LIGHT CAME ON. TOOK TO DEALER, AND THEY REPLACED OXYGEN SENSOR. IN MARCH OF 2001, PROBLEM REOCCURRED, AND DEALER REPLACED OXYGEN SENSOR AGAIN. ON SEPTEMBER 11, 2001, PROBLEM OCCURRED AGAIN, AND DEALER DID NOT HAVE A SOLUTION FOR PROBLEM. ON OCTOBER 22, 2001 PROBLEM REOCCURRED. A DEALER TOLD …
Read full complaint
WHILE DRIVING ENGINE CHECK LIGHT CAME ON. TOOK TO DEALER, AND THEY REPLACED OXYGEN SENSOR. IN MARCH OF 2001, PROBLEM REOCCURRED, AND DEALER REPLACED OXYGEN SENSOR AGAIN. ON SEPTEMBER 11, 2001, PROBLEM OCCURRED AGAIN, AND DEALER DID NOT HAVE A SOLUTION FOR PROBLEM. ON OCTOBER 22, 2001 PROBLEM REOCCURRED. A DEALER TOLD CONSUMER IT WAS OKAY TO DRIVE WITH ENGINE LIGHT ON. FINALLY, ON NOVEMBER 14, 200 ENGINE LIGHT CAME BACK ON. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
ENGINE CHECK LIGHT WOULD STAY UP TO TWO OR THREE DAYS AT A TIME. CONTACTED DEALER, AND DEALER STATED REASON FOR ENGINE CHECK LIGHT BEING ON WAS BECAUSE CONSUMER DID NOT DRIVE VEHICLE LONG ENOUGH.*AK
FRONT ROTORS WARP AND CAUSE A GREAT AMOUNT OF VIBRATION AND LOSS OF CONTROL. THIS HAS HAPPENED 5 TIMES IN 21000 MILES. CHEVY CAN NOT FIX.*AK
CONSUMER HAS CONTACTED DEALERSHIP FOR VARIOUS SUSPENSION PROBLEMS, BUT WAS TOLD THAT CAVALIER CONVERTIBLE WAS NO LONGER BEING MANUFACTURED BECAUSE IT WILL BUCKLE AND WILL FALL APART.*AK CONSUMER STATED THAT WINDOWS, DOORS AND ROOF ARE MAKING NOISE.*SLC
CONSUMER HAS A COLOR FILM ON FRONT WINDSHIELD WHICH OSTRUCTS VISION WHEN SUN IS SHINNING. HAS NOT HAD ANY ACCIDENTS YET. DEALERS SAYS THEY CANNOT HELP CONSUMER BECAUSE VEHICLE CAME FROM FACTORY LIKE THAT. *AK
MY CAR HAS STALLED 4 DIFFERNT TIMES W/OUT ANY WARNING,THE 2 OR 3 TIMES I WAS TOLD TO PUT GAS TREATMENT IN MY TANK . THEY THOUGHT I HAD WATER IN MY TANK. FINALLY AFTER ALMOST HITTING AN 18 WHEELER IN THE REAR W/MY 3 YEAR OLD DAUGHTER IN THE CAR, THE DEALER SAID THE FUEL FILTER WAS DEFECTIVE,& THE FUEL MODULAR REGULATOR WAS SHOR…
Read full complaint
MY CAR HAS STALLED 4 DIFFERNT TIMES W/OUT ANY WARNING,THE 2 OR 3 TIMES I WAS TOLD TO PUT GAS TREATMENT IN MY TANK . THEY THOUGHT I HAD WATER IN MY TANK. FINALLY AFTER ALMOST HITTING AN 18 WHEELER IN THE REAR W/MY 3 YEAR OLD DAUGHTER IN THE CAR, THE DEALER SAID THE FUEL FILTER WAS DEFECTIVE,& THE FUEL MODULAR REGULATOR WAS SHORTING OUT.I TRIED TO GET GM TO DO A BUY -BACK ON MY CAR THE REFUSED.THIS IS ONLY ONE OF MANY REPEATED PROBLEMS W/MY Z24. I AM GOING TO FILE THE LEMON LAW ON THIS CAR.*AK
VEHICLE STALLS WHEN A/C TURNED OFF. THIS HAPPENS WHEN VEHICLE IS IN PARK AND/OR DRIVE AND VEHICLE IS AT STAND STILL. DEALER HAS HAD THREE ATTEMPTS TO CORRECT DEFECT. DEALER STATES THAT THEY CAN'T ENGINEER A FIX FOR THE STALL. IN PROCESS OF HAVING VEHICLE CLASSIFIED A LEMON UNDER THE STATE OF FLORIDA'S "LEMON LAW".
THE WINDSHIELD HA A FAULTY DESIGN THAT CAUSES DISTORTING REFLACTIONS. *YH
Official recalls
204V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
00V201000 · Interior Lighting
Jul 20, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE BI-FUEL OPTION FAIL TO COMPLY WITH FMVSS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION." THE INSTRUMENT PANEL LIGHTS IN THESE VEHICLES ARE AT FULL ILLUMINATION LEVELS AND CANNOT BE ADJUSTED. THE STANDARD REQUIRES AT LEAST TWO LEVELS OF ILLUMINATION.
Consequence & remedy
Consequence: THIS COULD MAKE IT MORE DIFFICULT TO SEE OBJECTS OUTSIDE THE VEHICLE WHEN DRIVING AT NIGHT.
Remedy: DEALERS WILL REPLACE THE FUEL TYPE INDICATOR SWITCH ASSEMBLY, WHICH INCLUDES THE INSTRUMENT PANEL ILLUMINATION CONTROL.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available