I HEARD VIBRATION BY THE REAR DRIVERS SIDE WHEEL. I INSPECTED THE VEHICLE AND NOTICED I COULD ACTUALLY MOVE (WOBBLE) THE WHEEL, IT CAME LOOSE FROM THE FRAME ACCORDING TO 3 CAR SHOPS. I EVEN TOOK IT TO A CHEVY DEALERSHIP, IT WAS DEEMED UNSAFE TO DRIVE. ALSO THE FRAME IS COMPLETELY CORRODED, THERE ARE PARTS OF THE UNIBODY FRAME…
Read full complaint
I HEARD VIBRATION BY THE REAR DRIVERS SIDE WHEEL. I INSPECTED THE VEHICLE AND NOTICED I COULD ACTUALLY MOVE (WOBBLE) THE WHEEL, IT CAME LOOSE FROM THE FRAME ACCORDING TO 3 CAR SHOPS. I EVEN TOOK IT TO A CHEVY DEALERSHIP, IT WAS DEEMED UNSAFE TO DRIVE. ALSO THE FRAME IS COMPLETELY CORRODED, THERE ARE PARTS OF THE UNIBODY FRAME THAT ARE JUST MISSING DUE TO RUST AND CORROSION. THE REST OF THE CAR IS IN VERY GOOD SHAPE, BUT DUE TO THE FRAME ISSUE ITS NOW UNSAFE TO DRIVE AND WAY TOO EXPENSIVE TO REPAIR. ANY RECALLS ON THE 1998 CAVALIER?
NHTSA ODI #11020957
120,000 miles · Jul 1, 2013
Structure
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE TRAVELING 15 MPH, THE SUB FRAME FRACTURED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DETERMINED THAT THE SUB FRAME WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000. *TR
NHTSA ODI #10522588
155,000 miles · Dec 5, 2012
Structure
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT SHE EXPERIENCED DIFFICULTY STEERING THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DETERMINED THAT THE SUB FRAME FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 155,000 AND …
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT SHE EXPERIENCED DIFFICULTY STEERING THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DETERMINED THAT THE SUB FRAME FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS 155,000 AND THE CURRENT MILEAGE WAS 156,000.
NHTSA ODI #10487465
150,000 miles · Apr 16, 2012
Structure
TOOK VEHICLE FOR STATE INSPECTION. VEHICLE FAILED INSPECTION DUE TO FRAME BEING RUSTED. MECHANIC/INSPECTOR STATES THAT THIS IS VERY COMMON ON THE 1998 CHEVROLET CAVALIER. THERE ARE MFG. FRAME HOLES THAT THE SUBFRAME IS RUSTING NEAR THE REAR WHEELS. SUGGESTED THAT COULD HAVE A BODY SHOP WELD PLATES OVER THE MFG HOLES IN THE FRAME…
Read full complaint
TOOK VEHICLE FOR STATE INSPECTION. VEHICLE FAILED INSPECTION DUE TO FRAME BEING RUSTED. MECHANIC/INSPECTOR STATES THAT THIS IS VERY COMMON ON THE 1998 CHEVROLET CAVALIER. THERE ARE MFG. FRAME HOLES THAT THE SUBFRAME IS RUSTING NEAR THE REAR WHEELS. SUGGESTED THAT COULD HAVE A BODY SHOP WELD PLATES OVER THE MFG HOLES IN THE FRAME. *JS
NHTSA ODI #10455431
123,000 miles · Dec 12, 2011
Structure
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DRIVER WAS DRIVING APPROXIMATELY 35 MPH WHEN HE WAS PULLED OVER BY A POLICE OFFICER WHO INFORMED HIM THAT ONE OF THE WHEELS WAS PROTRUDING OUTWARD ABNORMALLY. THE VEHICLE WAS TOWED TO AN IMPOUND LOT WHERE THE CONTACT WAS INFORMED THAT THE SUB FRAME WAS S…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE DRIVER WAS DRIVING APPROXIMATELY 35 MPH WHEN HE WAS PULLED OVER BY A POLICE OFFICER WHO INFORMED HIM THAT ONE OF THE WHEELS WAS PROTRUDING OUTWARD ABNORMALLY. THE VEHICLE WAS TOWED TO AN IMPOUND LOT WHERE THE CONTACT WAS INFORMED THAT THE SUB FRAME WAS SEVERELY RUSTED AND CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10439418
131,000 miles · May 4, 2011
Structure
NO EVENTS EXCEPT THE SUB FRAME JUST SPLIT IN HALF ,CAUSING THE VEHICLE HAS VERY LITTLE CONTROL AND PULLS ERRATICALLY FROM ONE WAY TO ANOTHER, HAD TO REPLACE THE SUB FRAME. *TR
NHTSA ODI #10399097
170,000 miles · May 18, 2010
Structure
CHEVY CAVALIER RUSTED SUB FRAMES. CAR VIBRATES WILDLY AT A CERTAIN SPEEDS. CAR WAS PARKED. WAS TOLD VEHICLE WARRANTY HAD ALREADY EXPIRED AND THERE HAD BEEN NO OTHER CALLS RELATED TO THIS. WAS TOLD BY GM SERVICE DEPARTMENT CAR (IF DRIVEN) SHOULD BE DRIVEN CAUTIOUSLY (NO BUMPS, POTHOLES, LONG DISTANCE TRIPS) RECOMMENDED WE DON'T D…
Read full complaint
CHEVY CAVALIER RUSTED SUB FRAMES. CAR VIBRATES WILDLY AT A CERTAIN SPEEDS. CAR WAS PARKED. WAS TOLD VEHICLE WARRANTY HAD ALREADY EXPIRED AND THERE HAD BEEN NO OTHER CALLS RELATED TO THIS. WAS TOLD BY GM SERVICE DEPARTMENT CAR (IF DRIVEN) SHOULD BE DRIVEN CAUTIOUSLY (NO BUMPS, POTHOLES, LONG DISTANCE TRIPS) RECOMMENDED WE DON'T DRIVE. *TR
NHTSA ODI #10331065
143,600 miles · Dec 16, 2009
Structure
THE 1998 CHEVROLET CAVALIER STARTS TO SHAKE WHEN IT REACHES 60 MPH OR MORE. IT IS A HORRIBLE FEELING. *TR
NHTSA ODI #10296166
170,000 miles · Nov 30, 2009
Structure
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING 60 MPH THE VEHICLE WILL BEGIN TO VIBRATE. ALSO WHEN STRIKING A SMALL BUMP ON THE ROAD WAY, THE VEHICLE WILL FISH TAIL. DURING THE INSTALLATION OF NEW TIRES, SHE WAS ADVISED THAT THE VEHICLES SUB FRAME HAD CORROSION. IT COST $3500.00 TO REPAIR THE FRAME. NO REPAIRS …
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING 60 MPH THE VEHICLE WILL BEGIN TO VIBRATE. ALSO WHEN STRIKING A SMALL BUMP ON THE ROAD WAY, THE VEHICLE WILL FISH TAIL. DURING THE INSTALLATION OF NEW TIRES, SHE WAS ADVISED THAT THE VEHICLES SUB FRAME HAD CORROSION. IT COST $3500.00 TO REPAIR THE FRAME. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 170000. THE CURRENT MILEAGE WAS 172000.
NHTSA ODI #10294040
133,000 miles · Dec 15, 2008
Structure
I WAS STOPPED AT RED LIGHT AND WHEN THE LIGHT TURNED GREEN I TOOK OFF AND FELT A PULL TO THE PASSENGER SIDE. I HAD MY BROTHER IN LAW CHECK IT OUT AND THE SUB-FRAME WAS ROTTED. WE REPLACED IT BUT FEEL THIS NEEDED TO BE BROUGHT TO YOUR ATTENTION. *TR
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
Illustration