IN AUGUST OF 2002 I HAD THE FRONT RIGHT ANTI-LOCK SENSOR FOR MY 1998 CHEVY CAVALIER REPLACED. WITHIN NINE MONTHS, MAY 2003, I HAD TO HAVE THE SAME SENSOR REPLACED. NOW IT IS MAY OF 2004 AND MY DEALERSHIP IS TELLING ME THAT I NEED THE SAME SENSOR REPLACED. MY THINKING IS THAT THEY SHOULD OF FOUND SOMETHING AFTER THE SECOND TIM…
Read full complaint
IN AUGUST OF 2002 I HAD THE FRONT RIGHT ANTI-LOCK SENSOR FOR MY 1998 CHEVY CAVALIER REPLACED. WITHIN NINE MONTHS, MAY 2003, I HAD TO HAVE THE SAME SENSOR REPLACED. NOW IT IS MAY OF 2004 AND MY DEALERSHIP IS TELLING ME THAT I NEED THE SAME SENSOR REPLACED. MY THINKING IS THAT THEY SHOULD OF FOUND SOMETHING AFTER THE SECOND TIME I BROUGHT IT IN. SINCE THE 3 YEARS OR 36,000 MILE WARRANTY IS DONE I HAVE TO RELY ON THE PARTS WARRANTY, WHICH DOES NOT HELP ME IF I HAVE TO REPLACE IT EVERY YEAR. THREE SAME EXACT SENSORS REPLACED LESS THAT TWO YEARS IS SENSELESS. *AK
NHTSA ODI #10072694
Mileage unknown · Mar 29, 2002
Latches/locks/linkages
OJ REAR BACK DOOR CAME OPENED AND THE LOCK WAS ON AT THE TIME. THE DOOR WILL NOT CLOSE, REPLACE RT REAR DOOR LOCK ASSEMBLY. RUSTED/CORRODED LUBRICATED TO FREE UP, NEEDS REPLACEMENT, REMOVE AND REPLACE RT REAR DOOR LOCK ASSY.
EVER SINCE WE'VE BOUGHT THIS VEHICLE THERE'S BEEN NOTHING BUT PROBLEMS. WHILE BACKING OUT OF THE DRIVEWAY IT WILL STALL OUT AND SHUT OFF. IN FEB OF 2000 THE SPARK PLUGS NEEDED TO BE REPLACED. THE GAS GAUGE FLUCUATES. IT WILL SHOW 1/4 TANK OF GAS LEFT AND TEN MINUTES LATER THE CHECK GAS LIGHT COMES ON AND THE GAUGE DROPS. SO…
Read full complaint
EVER SINCE WE'VE BOUGHT THIS VEHICLE THERE'S BEEN NOTHING BUT PROBLEMS. WHILE BACKING OUT OF THE DRIVEWAY IT WILL STALL OUT AND SHUT OFF. IN FEB OF 2000 THE SPARK PLUGS NEEDED TO BE REPLACED. THE GAS GAUGE FLUCUATES. IT WILL SHOW 1/4 TANK OF GAS LEFT AND TEN MINUTES LATER THE CHECK GAS LIGHT COMES ON AND THE GAUGE DROPS. SOME KIND OF ELECTRICAL WIRE ON THE FRONT DRIVERS SIDE WENT BAD. THE DRIVER'S SIDE DOOR WON'T SHUT ANY MORE, THE LATCH NEEDS TO BE REPLACED. IT'S LIKE EVERY 3 OT 4 MONTHS SOMETHING WITHER MINOR OR SIGNIFICANT GOES WRONG WITH IT AND PERSOANLLY I AM SICK OF IT. I BELIEVE THAT MY CAR IS A LEMON AND I WANT TO DO SOMETHING ABOUT IT.*AK
NHTSA ODI #747074
Mileage unknown · Nov 28, 2000
Latches/locks/linkagesPower TrainStructure
THE TRANSMISSION FAILED PREMATURELY, CONSUMER IS REQUESTING WARRANTY REIMBURSEMENT FROM THE DEALERSHIP. *MJS
NHTSA ODI #558140
Mileage unknown · Jul 7, 2000
Latches/locks/linkagesInjury
CONSUMER SHUT THE REAR PASSENGER SIDE DOOR ON THE OCCUPANT'S FINGER WHICH CAUSED THE DOOR LATCH TO JAM, AND OCCUPANT COULD NOT OPEN THE DOOR TO TAKE HER FINGER OUT. THE OCCUPANT HAD SQUEEZED HER FINGER OUT, AND SUSTAINED INJURIES. WHEN THE FINGER WAS OUT OF THE DOOR MECHANISM, THE DOOR WAS ABLE TO OPEN AND CLOSE. PLEASE PROV…
Read full complaint
CONSUMER SHUT THE REAR PASSENGER SIDE DOOR ON THE OCCUPANT'S FINGER WHICH CAUSED THE DOOR LATCH TO JAM, AND OCCUPANT COULD NOT OPEN THE DOOR TO TAKE HER FINGER OUT. THE OCCUPANT HAD SQUEEZED HER FINGER OUT, AND SUSTAINED INJURIES. WHEN THE FINGER WAS OUT OF THE DOOR MECHANISM, THE DOOR WAS ABLE TO OPEN AND CLOSE. PLEASE PROVIDE FURTHER INFORMATION.*AK
NHTSA ODI #865039
Mileage unknown · Mar 1, 2000
Latches/locks/linkages
WHEN TURNING A CORNER AT APPROXIMATELY 20 MPH, PASSENGER'S SIDE DOOR FLEW OPEN AND WOULD NOT CLOSE. DEALER HAD VEHICLE FOR 2 WEEKS, AND STILL COULD NOT FIX THE DEFECT PROPERLY, LOCK IS NOT WORKING CORRECTLY. *AK *ML
NHTSA ODI #857701
Mileage unknown · Sep 8, 1999
Latches/locks/linkages
TRUNK LOCK--TRUNK WOULD NOT OPEN.
NHTSA ODI #609185
Mileage unknown · Jul 26, 1999
Latches/locks/linkagesInjury
THE DESIGN OF VEHICLE HAS AN LATCH ON THE DRIVER'S SIDE TO RELEASE THE HATCHBACK, BUT DOES NOT HAVE A RELEASE BUTTON / LATCH TO OPEN ON THE INSIDE WHICH CAUSED TWO CHILDREN TO BE STUCK INSIDE VEHICLE ALMOST RESULTING IN DEATH, INJURY TO HAND DUE TO FAILURE. *YC
NHTSA ODI #547526
Mileage unknown · Feb 1, 1999
Latches/locks/linkages
CHILD SAFTEY LOCKS OUT OF ORDER, DOOR DOES NOT OPEN FROM INSIDE AT ALL. YH
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
Illustration