IllustrationHEADLAMPS FAILED ON INTERSTATE,CAME BACK ON BUT WOULD FLICKER, DEALER FOUND 4 WIRES WITH CORROSION. DEALER UNABLE TO FIND NOISE IN SUSPENSION. *AK
1998 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 1998 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 83 of 345 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports10 fire reports23 injury reports
Exterior Lighting complaints
17 reportsHEAD LIGHT SWITCH FAILED AT NIGHT WHILE DRIVING CAUSING POOR VISIBILITY. NLM
#1, THE FRONT BRAKE ROTORS WARPED AND THE PADS WERE WORN. DEALER REFUSED TO REPLACE UNDER WARRANTY SO I PAID OUT OF POCKET. NOW SECOND SET OF ROTORS AND PADS IS IN NEED OF REPLACEMENT. #2 TRUNK LID LATCH COULD NOT BE OPENED WITH KEY, DEALER REFUSED TO REPAIR/REPLACE UNDER WARRANTY, SO I PAID OUT OF POCKET. #3 REVERSE LIGHT S…
Read full complaint
#1, THE FRONT BRAKE ROTORS WARPED AND THE PADS WERE WORN. DEALER REFUSED TO REPLACE UNDER WARRANTY SO I PAID OUT OF POCKET. NOW SECOND SET OF ROTORS AND PADS IS IN NEED OF REPLACEMENT. #2 TRUNK LID LATCH COULD NOT BE OPENED WITH KEY, DEALER REFUSED TO REPAIR/REPLACE UNDER WARRANTY, SO I PAID OUT OF POCKET. #3 REVERSE LIGHT SWITCH FAILED, AGAIN DEALER REFUSED TO REPLACE UNDER WARRANTY, I PAID OUT OF POCKET. SWITCH HAS GONE BAD AGAIN AND I PAID TO HAVE IT REPLACE A SECOND TIME. #4 DRIVER'S DOOR HINGES WERE BENT AND DOOR DID NOT ALWAYS CLOSE TIGHTLY, DEALER REPAIRED AT NO CHARGE. #5 DRIVER'S SIDE SIDE HAD A METAL BAR STICKING THROUGH THE UPHOLSTERY INTO MY BACK. DEALER REPAIRED AT NO CHARGE.
TURN SIGNALS FAILED.
THERE HAS BEEN ONE THING WRONG AFTER THE OTHER EVER SINCE I BOUGHT THIS CAR AND I BELIEVE IT A PIECE OF CRAP BUT I GUESS THAT I AM STUCK UP IT SINCE CHEVROLET DECLINED MY BUYBACK REQUEST.
WHEN APPLYING THE BRAKES CONSUMER CAN SMELL THE BRAKES BURNING. CONSUMER HAD PROBLEMS WITH THE ROTORS/HOOD LATCH AND CALIPERS STICKING. ALSO, HAD THREE MUFFLERS REPLACED. THE HEADLIGHTS WENT OUT WHILE DRIVING, AND THE PARKING BRAKE WON'T WORK. IN ADDITION, WAS HAVING PROBLEMS WITH ENGINE ROCHER ARM GASKET, AND THE BRAKE…
Read full complaint
WHEN APPLYING THE BRAKES CONSUMER CAN SMELL THE BRAKES BURNING. CONSUMER HAD PROBLEMS WITH THE ROTORS/HOOD LATCH AND CALIPERS STICKING. ALSO, HAD THREE MUFFLERS REPLACED. THE HEADLIGHTS WENT OUT WHILE DRIVING, AND THE PARKING BRAKE WON'T WORK. IN ADDITION, WAS HAVING PROBLEMS WITH ENGINE ROCHER ARM GASKET, AND THE BRAKE LIGHT KEPT COMING ON. DEALER CAN'T FIND THE PROBLEM. *AK
UNEVEN AMOUNT OF PAINT ON THE RIM OF THE TRUNK. DEFECTIVE DOOR GASKET. INOPERATIVE BRAKE LIGHTS.
Official recalls
404V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
00V053000 · Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
Feb 28, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
97V219000 · Wheels:lugs/nuts/bolts/studs
Nov 24, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.
Consequence & remedy
Consequence: THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.