Engine And Engine CoolingPower TrainService Brakes, Air
THIS CAR HAS BEEN TAKEN TO THE DEALER AND THE DEALER RECOGNIZES THE PROBLEM BUT CONSISTANTLY REFUSES TO TAKE ANY RSPONSIBILITIES FOR THE JUNK THAT THEY SOLD ME. THIS CAR HAS BEEN TO THE BODY SHOP FOR REPAIRS ON THE MANUFACTURER GROUND EFFECTS PACKAGE THE TRANSMISSION THAT DOESN'T WORK PROPERLY THE BRAKE SYSTEM THE I HAVE HAD TO…
Read full complaint
THIS CAR HAS BEEN TAKEN TO THE DEALER AND THE DEALER RECOGNIZES THE PROBLEM BUT CONSISTANTLY REFUSES TO TAKE ANY RSPONSIBILITIES FOR THE JUNK THAT THEY SOLD ME. THIS CAR HAS BEEN TO THE BODY SHOP FOR REPAIRS ON THE MANUFACTURER GROUND EFFECTS PACKAGE THE TRANSMISSION THAT DOESN'T WORK PROPERLY THE BRAKE SYSTEM THE I HAVE HAD TO HAVE ROTORS TURNED AND WITHIN FOUR MONTHS HAVE BRAND NEW ROTORS BUT ON. THE SUNROOF DOESN'T OPEN PROPERLY, THE TRUNK LID HITS THE BUMPER WHEN YOU CLOSE IT,THE ENGINE MAKES A WEIRD RATTLE NOISE WHEN YOU GO OVER A BUMP,THE DOORS DO NOT CLOSE ALL THE WAY, THER IS TONS OF RUST ON THE INSIDE WALLS OF MY TRUNK, I WAS ALSO NOTIFIED OF A RECALL ON THE OIL CONSUMPTION VALVE TWO WEEKS AFTER ALL THE OIL IN MY CAR HAD LEAKED OUT CAUSING MY ENGINE TO KNOCK ON MY WAY HOME FROM WORK (HAD TO PUT FOUR QUARTS OF OIL IN IT THREE DAYS FROM HAVING AN OIL CHANGE, I NEVER RECEIVED THE AIRBAG RECALL FOR MY VEHICLE. TO WRAP THIS UP IN A NUTSHELL I WILL NEVER BUY A CHEVROLET PRODUCT AGAIN I WILL RESULT TO A FORIEGN CAR MAKER (HONDA) TO PURCHASE MY NEXT VEHICLE. NK
NHTSA ODI #706089
Mileage unknown · Mar 5, 1999
Electrical SystemEngine And Engine CoolingVisibility
WHILE DRIVING AND WITH THE AIR CONDITIONER ON OR THE DEFOGGER ON, THE VEHICLE WILL STALL UNEXPECTEDLY WHICH MAY CAUSE AN ACCIDENT. BEEN TO DEALER SEVERAL TIMES. DEALER REPLACED THE CRANK CASE POSITION SENSOR AND A COMPUTER CHIP, BUT THE PROBLEM WOULD REOCCUR. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #835504
Mileage unknown · Feb 1, 1999
Engine And Engine Cooling
POSSIBLE ENGINE FAILURE CAUSING VEHICLE TO OVER HEAT. YH
NHTSA ODI #608930
Mileage unknown · Feb 1, 1999
Engine And Engine Cooling
RADIATOR FAN FAILED. YH
NHTSA ODI #608831
Mileage unknown · Feb 1, 1999
Engine And Engine Cooling
RADIATOR HOSE FAILED. MJS
NHTSA ODI #607998
Mileage unknown · Feb 1, 1999
Engine And Engine Cooling
RADIATOR HOSE PROTECTOR FAILED. MJS
NHTSA ODI #607816
Mileage unknown · Feb 1, 1999
Engine And Engine Cooling
SERPENTINE BELT FAILED. *YC
NHTSA ODI #607411
Mileage unknown · Jan 27, 1999
Engine And Engine CoolingVehicle Speed Control
ACCELERATED PAD WIGGLES ALL THE TIME, AND THE MOTOR MOUNTS ARE NOT TIGHT WHICH MAKES THE PAD MOVE ALL THE TIME. *AK
NHTSA ODI #834041
Mileage unknown · Jan 22, 1999
Engine And Engine CoolingService Brakes, Hydraulic
EXPERIENCING ONGOING PROBLEM WITH VEHICLE STALLING WHENEVER TRAVELLING 25 MPH WITH THE RIGHT TURN SIGNAL ON. ALSO, FRONT PADS AND ROTORS HAD TO BE REPLACED AT 11,000 MILES, AND WAS INFORMED BY DEALER THAT CONDITION WAS NORMAL AT 11,000 MILES OF WEAR. PROBLEM STILL EXISTS. *AK *ML
NHTSA ODI #833913
Mileage unknown · Jan 18, 1999
Engine And Engine CoolingStructure
AT 8 MILES BEFORE PURCHASE OF CAR WATER PUMP, GASKET, THERMOSTAT AND SEAL REPLACED BECAUSE OF COOLANT LEAK, AT 14,000 MILES WATER SENSOR REPLACE BECAUSE COOLANT LIGHT CONTINUED TO COME ON, AT 15,000 MILES COOLANT COMING ON AGAIN AND HEAD GASKET REPLACED. CLAIMS NO DAMAGE TO ENGINE BUT A MECHANIC TOLD ME THEY COULD NOT TELL UNLE…
Read full complaint
AT 8 MILES BEFORE PURCHASE OF CAR WATER PUMP, GASKET, THERMOSTAT AND SEAL REPLACED BECAUSE OF COOLANT LEAK, AT 14,000 MILES WATER SENSOR REPLACE BECAUSE COOLANT LIGHT CONTINUED TO COME ON, AT 15,000 MILES COOLANT COMING ON AGAIN AND HEAD GASKET REPLACED. CLAIMS NO DAMAGE TO ENGINE BUT A MECHANIC TOLD ME THEY COULD NOT TELL UNLESS THEY TEAR ENGINE DOWN AND MIC IT. AT 5,000 MILES TRUNK LEAKED AT 15,000 MILES IN FOR CONTINUED TRUNK LEAK. FRONT PASSENGER DOOR STICKS. REAR PASSENGER DOOR HANDLE STICKS OUT FURTHER THAN REST. CONTINUE TO HAVE PROBLEMS WITH CAR. ALSO HAD TO HAVE MUD FLAPS INSTALLED AFTER PURCHASE, THEY WHERE SUPPOSE TO COME WITH IT. HAD TO HAVE FRONT PASSENGER SEAT FIXED BECAUSE IT WOULD NOT MOVE. CAR IS IN WILLIAM M FOWLER AND BARBARA A FOWLER
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
Illustration