IllustrationTHE GAS GAUGE IS GOING HAYWIRE. IT PEGS TO THE "F", AND THEN IMMEDIATELY PEGS TO THE "E", EVEN THOUGH THE TANK IS HALF FULL. THE GAUGE THEN JUMPS AROUND THE MIDDLE FORM ONE SIDE TO THE OTHER SIDE. IT IS IMPOSSIBLE TO TELL HOW MUCH IS IN THE TANK. THIS HAPPENS WHILE DRIVING AND ALSO WHILE SITTING AT LIGHTS OR STOP SIGNS.
1998 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 1998 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 83 of 345 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports10 fire reports23 injury reports
Electrical System complaints
66 reportsTL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 189,467.
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING AT 35 MPH, THERE WAS AN ODOR OF SMOKE INSIDE THE VEHICLE. THE CONTACT COASTED OVER TO THE SIDE OF THE ROAD, LIFTED THE HOOD, AND NOTICED THAT THE WIRES FROM THE ALTERNATOR WERE ON FIRE. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENC…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. WHILE DRIVING AT 35 MPH, THERE WAS AN ODOR OF SMOKE INSIDE THE VEHICLE. THE CONTACT COASTED OVER TO THE SIDE OF THE ROAD, LIFTED THE HOOD, AND NOTICED THAT THE WIRES FROM THE ALTERNATOR WERE ON FIRE. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 169,000.
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE KEY COULD NOT BE INSERTED ALL THE WAY IN THE IGNITION. ALSO, THE CONTACT STATED THAT IN ORDER TO TURN ON THE VEHICLE THE KEY NEEDED TO BE SLIGHTLY OUT OF THE IGNITION SWITCH. THE VEHICLE HAD NOT BEEN DIAGNOSED OR RE…
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE KEY COULD NOT BE INSERTED ALL THE WAY IN THE IGNITION. ALSO, THE CONTACT STATED THAT IN ORDER TO TURN ON THE VEHICLE THE KEY NEEDED TO BE SLIGHTLY OUT OF THE IGNITION SWITCH. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THE ANTI-THEFT SYSTEM FAILED. WHEN THE THEFT SYSTEM FAILED THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER AND WAS TOLD THAT THE PASS LOCK SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 142,000. …
Read full complaint
TL* THE CONTACT OWNS A 1998 CHEVROLET CAVALIER. THE CONTACT STATED THE ANTI-THEFT SYSTEM FAILED. WHEN THE THEFT SYSTEM FAILED THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER AND WAS TOLD THAT THE PASS LOCK SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 142,000.
IGNITION SWITCH, OR ANTI THEFT SYSTEM, CAUSES FUEL PUMP TO NOT WORK PROPERLY AND ALSO FUEL INJECTORS, BEEN IN GARAGE 3 TIMES AND FINALLY WAS TOLD THE PROBLEM AFTER SPENDING HUNDREDS OF DOLLARS, WAS TOLD GM HAD A RECALL ON THIS PART. *TR
THIS CAR HAS BEEN IN THE FAMILY FOR MOST OF ITS LIFE. WHEN MY SISTER BOUGHT IT. SHE WOULD HAVE TROUBLE WITH IT STARTING UP. SHE WOULD HAVE TO TRY SEVERAL TIMES BEFORE IT WOULD FINALLY START UP. IM NOT SURE OF THE PROBLEM. I WAS TOLD IT COULD BE THE IGNITION SWITCH. BUT THIS HAS BEEN REPLACED TWICE. THIS GETS EXPENSIVE WHEN YOU D…
Read full complaint
THIS CAR HAS BEEN IN THE FAMILY FOR MOST OF ITS LIFE. WHEN MY SISTER BOUGHT IT. SHE WOULD HAVE TROUBLE WITH IT STARTING UP. SHE WOULD HAVE TO TRY SEVERAL TIMES BEFORE IT WOULD FINALLY START UP. IM NOT SURE OF THE PROBLEM. I WAS TOLD IT COULD BE THE IGNITION SWITCH. BUT THIS HAS BEEN REPLACED TWICE. THIS GETS EXPENSIVE WHEN YOU DO THIS? I WAS WONDERING IF THERE WAS ANY OTHER COMPLAINTS WITH THIS. *TR
ALL I HAVE TO SAY ABOUT THIS CAR IS IT IS A PIECE OF JUNK. I HAVE HAD MINE FOR ALMOST TWO YEARS NOW AND IN THIS TWO YEARS I HAVE HAD TO PUT ABOUT 7,000 DOLLARS OF WORK INTO IT. AS OF RIGHT NOW MY CAR IS SITTING 200 HUNDRED MILES AWAY ON THE SIDE OF THE HIGHWAY BECAUSE THE WIRING TO MY STARTER KEEPS BLOWING MY STARTERS UP. AND AS…
Read full complaint
ALL I HAVE TO SAY ABOUT THIS CAR IS IT IS A PIECE OF JUNK. I HAVE HAD MINE FOR ALMOST TWO YEARS NOW AND IN THIS TWO YEARS I HAVE HAD TO PUT ABOUT 7,000 DOLLARS OF WORK INTO IT. AS OF RIGHT NOW MY CAR IS SITTING 200 HUNDRED MILES AWAY ON THE SIDE OF THE HIGHWAY BECAUSE THE WIRING TO MY STARTER KEEPS BLOWING MY STARTERS UP. AND AS FAR AS IM CONCERNED THE CAR CAN STAY THERE. I'M NOT EVEN GOING TO BOTHER GOING TO GET IT. SOMEONE ELSE CAN BAR THE BURDEN THAT COMES WITH THAT CAR! IM DONE! *TR
NO WARNING OF ANYTHING WRONG, HAD DRIVEN LESS THAN 1 MILE WHEN TRUNK CAUGHT ON FIRE DUE TO DEFECTIVE WIRING. *NM
WIRING HARNESS SHORTED OUT AND STARTED TRUNK FIRE. *NM
Official recalls
404V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
00V053000 · Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
Feb 28, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
97V219000 · Wheels:lugs/nuts/bolts/studs
Nov 24, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.
Consequence & remedy
Consequence: THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.