Illustration"TAKATA RECALL" I HAVE TRIED TO COONTACT DEALSHIPS, AND AM BEING TOLD MY VEHICLE DOESN'T "SHOW UP"? YET MY CAR IS VERIFIED FROM WWW.NHTSA.GOV ( MANUFACTURER RECALL NUMBERN040002 NHTSA RECALL NUMBER04V036.
1998 Chevrolet Cavalier
Owner reports · Recalls · Investigations
More warning signs than most Cavalier years
Owner complaints for the 1998 Chevrolet Cavalier are substantially higher than the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 83 of 345 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
36 crash reports10 fire reports23 injury reports
Air Bags complaints
34 reportsTL* THE CONTACT OWNED A 1998 CHEVROLET CAVALIER. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED ON ICE. AS A RESULT, THE CONTACT CRASHED INTO THE GUARDRAIL. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A FRACTURED SPINE THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE…
Read full complaint
TL* THE CONTACT OWNED A 1998 CHEVROLET CAVALIER. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED ON ICE. AS A RESULT, THE CONTACT CRASHED INTO THE GUARDRAIL. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A FRACTURED SPINE THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.
I REAR ENDED SOMEONE GOING 45 MPH AND MY AIR BAGS DID NOT DEPLOY AND I DO NOT UNDERSTAND WHY. THIS WAS A FRONTAL CRASH AND FROM ALL THE LITERATURE I HAVE READ, IT INDICATES THAT THE AIRBAGS SHOULD HAVE DEPLOYED. *NM
(1) MY COUSIN WAS DRIVING HER 1998 CAVALIER WHEN SHE WAS STRUCK HEAD ON BY AN ONCOMING VEHICLE (2) HER DRIVER'S SIDE CHAIR BROKE LOSE AND HER SEAT BELT CAME OUT OF ITS FASTENER AND THE METAL "HOOK" STRIKING HER BODY RESULTING IN A LACERATION. HER BODY WAS THEN THROW FORWARD WITH SUCH GREAT FORCE THAT SHE HIT THE WINDSHIELD WIT…
Read full complaint
(1) MY COUSIN WAS DRIVING HER 1998 CAVALIER WHEN SHE WAS STRUCK HEAD ON BY AN ONCOMING VEHICLE (2) HER DRIVER'S SIDE CHAIR BROKE LOSE AND HER SEAT BELT CAME OUT OF ITS FASTENER AND THE METAL "HOOK" STRIKING HER BODY RESULTING IN A LACERATION. HER BODY WAS THEN THROW FORWARD WITH SUCH GREAT FORCE THAT SHE HIT THE WINDSHIELD WITH HER HEAD TWICE RESULTING IN A CONCUSSION, BLACK EYE, SWOLLEN FOREHEAD AND OTHER CUTS AND BRUISES. ADDITIONALLY, AT THE POINT OF IMPACT, DESPITE THE FORCE WITH WHICH SHE WAS STRUCK, HER AIRBAG FAILED TO DEPLOY WHICH COULD HAVE FURTHER PREVENTED HER STRIKING THE WINDSHIELD. EVERY SAFETY DEVICE IN THIS VEHICLE FAILED MISERABLY RESULTING IN SERIOUS INJURY.
WHILE SLOWING FROM A SPEED OF 45 MPH THE VEHICLE'S AIR BAGS DEPLOYED. *NM THE CONSUMER TRIED TO CONTROL THE VEHICLE AS THE AIR BAG WAS BLOCKING HER VIEW. THE VEHICLE CAME TO A STOP IN A DITCH. TWO WITNESSES ASSISTED THE CONSUMER. THE CONSUMER STATED THAT THERE WAS NO COLLISION UNTIL THE AIR BAG DEPLOYED. *TC
THE FRONT AIR BAGS INADVERTENTLY DEPLOYED. *AK. NO COLLISION PRIOR TO AIR BAG DEPLOYMENT, SLOWED TO STOP, APPROXIMATELY FROM STOP SIGN. AIR BAG DEPLOYED, VEHICLE SKIDDED INTO A DITCH. *AK
THE CONSUMER WAS SITTING AT AN INTERSECTION AND WITHOUT WARNING, ANOTHER DRIVER RAN A RED LIGHT AND HIT THE DRIVER HEAD ON AT THE INTERSECTION. THE FRONTAL AIR BAGS DID NOT DEPLOY. THE CONSUMER AND PASSENGER SUSTAINED HEAD A NECK INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. THE VEHICLE WAS TOWED AND TOTALED BY …
Read full complaint
THE CONSUMER WAS SITTING AT AN INTERSECTION AND WITHOUT WARNING, ANOTHER DRIVER RAN A RED LIGHT AND HIT THE DRIVER HEAD ON AT THE INTERSECTION. THE FRONTAL AIR BAGS DID NOT DEPLOY. THE CONSUMER AND PASSENGER SUSTAINED HEAD A NECK INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. THE VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
VEHICLE WAS TAKEN TO THE DEALER FOR A ROUTINE INSPECTION, AND MECHANIC DETERMINED THAT BOTH FRONTAL AIR BAGS WERE FAULTY AND NEEDED TO BE REPLACED. *AK
VEHICLE'S AIR BAG LIGHT KEEPS ILLUMINATING ON THE DASHBOARD.*MR THE CONSUMER IS VERY CONCERNED ABOUT THE AIR BAG LIGHT. THIS IS A VERY HARZARDOUS AND SAFETY PROBLEM. THE CONSUMER IS SUGGESTING THAT RESEARCH BE FOUND OUT ABOUT THE VEHICLE OR WHETHER OR NOT A RECALL NEEDS TO BE DONE. *CB *JB
THE VEHICLE HIT A POT HOLE AND THE DRIVER AND PASSENGER AIR BAGS DEPLOYED. *JB
Official recalls
404V036000 · Electrical System:ignition:switch
Jan 27, 2004
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
00V053000 · Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
Feb 28, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH BI-FUEL COMPRESSED NATURAL GAS (CNG) VEHICLES. THE CNG FUEL LINE AND THE CNG HIGH PRESSURE REGULATOR COOLANT LINES CAN CONTACT OTHER FUEL (GASOLINE) AND BRAKE LINES ON THE VEHICLE. ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH.
Consequence & remedy
Consequence: ABRASION FROM CONTACT CAN CAUSE A LEAK IN THE BRAKE PIPE, FUEL PIPE, OR BOTH. A BRAKE FLUID LEAK COULD DISABLE A PORTION OF THE BRAKE SYSTEM, CAUSING LONGER STOPPING DISTANCES. GASOLINE LEAKING FROM A FUEL PIPE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND REPOSITION THE CNG FUEL AND COOLANT PIPES AND REPOSITION/REPAIR ANY DAMAGED FUEL OR BRAKE PIPES AS NECESSARY.
97V219000 · Wheels:lugs/nuts/bolts/studs
Nov 24, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.
Consequence & remedy
Consequence: THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.