TL* THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON THE FIRST ATTEMPT. THE CONTACT ALSO STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED. THE CONTACT WAS NOT AWARE OF ALL THE DETAILS INVOL…
Read full complaint
TL* THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON THE FIRST ATTEMPT. THE CONTACT ALSO STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED. THE CONTACT WAS NOT AWARE OF ALL THE DETAILS INVOLVING THE REPAIR AND THE CAUSE OF THE FAILURE WAS NOT DISCLOSED TO THE CONTACT. THE CONTACT WAS NOTIFIED OF NHTSA CAMPAIGN NUMBER: 02V286000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
NHTSA ODI #10680964
185,747 miles · Apr 22, 2011
Electrical SystemSteeringFire
1997 CHEVY CAVALIER STEERING COLUMN AND DASHBOARD CAUGHT ON FIRE ON MARCH 10, 2011. CAR HAD NO MECHANICAL OR ELECTRICAL ISSUES PRIOR TO THE FIRE. CAR WAS IN EXCELLENT WORKING CONDITION. CAR HAD BEEN PARKED FOR APPROXIMATELY ONE HOUR AFTER BEING USED FOR A SHORT DRIVE. THE CAVALIER WAS PARKED OUTSIDE IN FRONT OF THE HOUSE NO …
Read full complaint
1997 CHEVY CAVALIER STEERING COLUMN AND DASHBOARD CAUGHT ON FIRE ON MARCH 10, 2011. CAR HAD NO MECHANICAL OR ELECTRICAL ISSUES PRIOR TO THE FIRE. CAR WAS IN EXCELLENT WORKING CONDITION. CAR HAD BEEN PARKED FOR APPROXIMATELY ONE HOUR AFTER BEING USED FOR A SHORT DRIVE. THE CAVALIER WAS PARKED OUTSIDE IN FRONT OF THE HOUSE NO ONE WAS IN THE VEHICLE. FIRE DEPARTMENT HAD TO BE CALLED TO EXTINGUISH THE FIRE FROM THE CAR. NO PRIOR KNOWLEDGE OF THE RECALL FOR THE ELECTRICAL SYSTEM IGNITION SWITCH DEFECT. *TR
NHTSA ODI #10397150
116,000 miles · Mar 16, 2011
SteeringCrashInjury
TL*THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. THE CONTACT WAS DRIVING 10 MPH WHEN THE STEERING WHEEL BECAME RESISTANT AND LOCKED. WITHOUT STEERING CAPABILITY, THE CONTACT WAS UNABLE TO CONTROL THE VEHICLE AND CRASHED INTO A BUILDING. THE CONTACT SUSTAINED HEAD INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. …
Read full complaint
TL*THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. THE CONTACT WAS DRIVING 10 MPH WHEN THE STEERING WHEEL BECAME RESISTANT AND LOCKED. WITHOUT STEERING CAPABILITY, THE CONTACT WAS UNABLE TO CONTROL THE VEHICLE AND CRASHED INTO A BUILDING. THE CONTACT SUSTAINED HEAD INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER SENT AN INVESTIGATOR TO INSPECT THE VEHICLE FOR THE FAILURE AND CONCLUDED THAT THE CRASH WAS NOT DUE TO ANY TYPE OF DEFECT. THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 116,000. UPDATED 05/04/11 *BF UPDATED 1/5/12 *CN
NHTSA ODI #10390397
Mileage unknown · Jan 29, 2008
SteeringCrashInjury
1997 CHEVROLET CAVALIER WITH A STEERING COLUMN RECALL. CONSUMER STATES THAT THEY NEVER RECEIVED THE FIRST RECALL AND BY THE TIME THEY RECEIVED THE SECOND ONE THEIR DAUGHTER HAD DIED IN THAT VEHICLE DUE TO AN ACCIDENT. *KB
NHTSA ODI #10217148
61,000 miles · Oct 9, 2007
Steering
TL*THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. WHILE ATTEMPTING TO MAKE A LEFT TURN FROM A STOP, THE POWER STEERING FAILED. THE POWER STEERING WORKS WHEN DRIVING FORWARD AND MAKING A RIGHT TURN, BUT FAILS ONLY WHEN TURNING LEFT. GMC STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V286000 (STEERING:RACK …
Read full complaint
TL*THE CONTACT OWNS A 1997 CHEVROLET CAVALIER. WHILE ATTEMPTING TO MAKE A LEFT TURN FROM A STOP, THE POWER STEERING FAILED. THE POWER STEERING WORKS WHEN DRIVING FORWARD AND MAKING A RIGHT TURN, BUT FAILS ONLY WHEN TURNING LEFT. GMC STATED THAT HIS VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 02V286000 (STEERING:RACK AND PINION). THE VEHICLE IS CURRENTLY AT A CHEVROLET DEALER AWAITING REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 61,000. * UPDATED 12/12/07 *BF UPDATED 12/12/07 *TR
NHTSA ODI #10205267
120,000 miles · Sep 8, 2006
Steering
DT*: THE CONTACT STATED THE POWER STEERING WAS NOT WORKING PROPERLY MAKING THE VEHICLE VERY DIFFICULT TO STEER. A NHTSA RECALL, # 02V286000 WAS PERFORMED ON THE VEHICLE CONCERNING, THE STEERING:RACK AND PINION HOWEVER, THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR UNDER THE RECALL.
NHTSA ODI #10167687
84,005 miles · Apr 24, 2006
Steering
DT*: THE CONTACT STATED WHILE TURNING AT VARIOUS SPEEDS THE POWER STEERING FAILED INTERMITTENTLY. THE VEHICLE HAS NOT BEEN SEEN BY A MECHANIC. THERE IS A NHTSA RECALL, # 02V286000, REGARDING THE RACK AND PINION; HOWEVER, IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10155995
Mileage unknown · Feb 24, 2006
Steering
THE STEERING COLUMN IN THE CONSUMER'S 1997 CHEVROLET CAVALIER LOCKED UP. THE POWER STEERING PUMP HAD TO BE REPLACED. *TS THE CONSUMER RECEIVED A RECALL FOR THE PROBLEM IN JANUARY 2003. *NM
NHTSA ODI #10151945
125,000 miles · Jul 26, 2005
Steering
RACK AND PINION STEERING FAILURE. CAR FAILS TO STEER LEFT AND ALMOST CAUSES A CRASH DUE TO LACK OF BEING ABLE TO STEER. ABILITY TO STEER TO THE RIGHT IS FINE. MAKING LEFT HAND TURNS NOW WORRIES ME WHEN DRIVING. DURING MY COMMUTE I AM CONSTANTLY WORRIED WHETHER OR NOT I CAN MAKE A LEFT-HAND TURN. THIS HAS ALMOST CAUSED THREE…
Read full complaint
RACK AND PINION STEERING FAILURE. CAR FAILS TO STEER LEFT AND ALMOST CAUSES A CRASH DUE TO LACK OF BEING ABLE TO STEER. ABILITY TO STEER TO THE RIGHT IS FINE. MAKING LEFT HAND TURNS NOW WORRIES ME WHEN DRIVING. DURING MY COMMUTE I AM CONSTANTLY WORRIED WHETHER OR NOT I CAN MAKE A LEFT-HAND TURN. THIS HAS ALMOST CAUSED THREE ACCIDENTS. WHY WASN'T THIS RECALLED CONSIDERING ALL THE THE PROBLEMS WITH THIS LISTED WITH THE NHTSA? PLENTY OF GM MODELS HAVE HAD THIS PROBLEM. WHY SHOULD CONSUMERS TAKE THE FALL WHEN IT STEMS BACK TO THE MANUFACTURER?
NHTSA ODI #10130116
8 miles · Apr 6, 2005
Steering
TAKING A LEFT TURN IN A 1997 CHEVROLET CAVALIER, THE STEERING WHEEL LOCKED, CAUSING THE CAR TO VEER LEFT WITHOUT ABILITY TO CORRECT UNTIL EXPLICIT FORCE WAS APPLIED. THE INCIDENTS LEFT THE STEERING WHEEL WITH SLUGGISH CONTROL AND THEREFORE UNSAFE FOR DRIVING. THE CAR WAS TAKEN TO THE DEALERSHIP WHICH ASKED FOR 800$ FOR THE REPAI…
Read full complaint
TAKING A LEFT TURN IN A 1997 CHEVROLET CAVALIER, THE STEERING WHEEL LOCKED, CAUSING THE CAR TO VEER LEFT WITHOUT ABILITY TO CORRECT UNTIL EXPLICIT FORCE WAS APPLIED. THE INCIDENTS LEFT THE STEERING WHEEL WITH SLUGGISH CONTROL AND THEREFORE UNSAFE FOR DRIVING. THE CAR WAS TAKEN TO THE DEALERSHIP WHICH ASKED FOR 800$ FOR THE REPAIR OF THE STEERING WHEEL. INFORMATION ABOUT THIS DEFECT IN GM CARS HAS BEEN SEEN THROUGHOUT THE INTERNET, AND A COMPLAINT IS MORE THAN NECESSARY.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence & remedy
Consequence: THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1997 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration