NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
58 reportsClear category filterMileage unknown · Oct 18, 2001
Service Brakes, Hydraulic
THE CAR JERKS WHEN THE BRAKES ARE APPLIED. THE DEALER REPLACED THE ROTORS AT AROUND 25,000 MILES. THE NEXT TIME IT HAPPENED, IT WAS AT AROUND 40,000 MILES. THE DEALER WOULD NOT REPLACE THE ROTORS. AT AROUND 64,000 MILES IT HAS STARTED AGAIN. THE FIRST TIME I HAD TO TAKE THIS TO THE DEALER, THEY KNEW WITH OUT LOOKING AT THE CAR W…
Read full complaint
THE CAR JERKS WHEN THE BRAKES ARE APPLIED. THE DEALER REPLACED THE ROTORS AT AROUND 25,000 MILES. THE NEXT TIME IT HAPPENED, IT WAS AT AROUND 40,000 MILES. THE DEALER WOULD NOT REPLACE THE ROTORS. AT AROUND 64,000 MILES IT HAS STARTED AGAIN. THE FIRST TIME I HAD TO TAKE THIS TO THE DEALER, THEY KNEW WITH OUT LOOKING AT THE CAR WHAT IT WAS. I FEEL THAT THIS IS A SAFETY ISSUE AND THESE ROTORS ARE DEFECTIVE AND THE COMPANY SHOULD HAVE TO REPLACE THEM. *AK
NHTSA ODI #753372
Mileage unknown · Jul 17, 2001
Service Brakes, Hydraulic
THE FRONT ROTORS HAVE BEEN TURNED AND REPLACED ON NUMEROUS OCCASIONS, RIGHT AND LEFT REAR DRUM HAVE BEEN REPLACED AS WELL AS THE CYLINDER.*JB
NHTSA ODI #562114
Mileage unknown · Jun 12, 2001
Service Brakes, Hydraulic
FRONT BRAKE PULSATE WHEN USED. ROTORS ARE OUT OF ROUND. THIS IS THE SECOND TIME. WE HAD NEW BRAKES AND THE ROTORS TURNED AT 30,000 MILES FOR THE SAME PROBLEM.*AK
NHTSA ODI #746716
Mileage unknown · Feb 26, 2001
Service Brakes, HydraulicCrash
WHILE TRAVELING AND WITHOUT ANY INDICATION CONSUMER LOST CONTROL OF VEHICLE AS A RESULT OF AN ACCIDENT. TECHNICIAN STATED FRONT BRAKE DISC HAD FAILED. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #881383
Mileage unknown · Jan 28, 2001
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
DEFECT 1: ABS LIGHT WOULD COME ON WHEN MAKING A LEFT HAND TURN. ABS WOULD NO LONGER ACTIVATE WHILE LIGHT WAS ON. DEFECT 2: ALTERNATOR--WENT OUT WHILE DRIVING IN CITY TRAFFIC, RUSH HOUR. HAD PREVIOUSLY ASKED DEALER TO CHECK, BUT THEY CLAIMED IT WAS FUNCTIONING PROPERLY. DEFECT 3: RACK AND PINION STEERING ASSEMBLY--WENT OUT…
Read full complaint
DEFECT 1: ABS LIGHT WOULD COME ON WHEN MAKING A LEFT HAND TURN. ABS WOULD NO LONGER ACTIVATE WHILE LIGHT WAS ON. DEFECT 2: ALTERNATOR--WENT OUT WHILE DRIVING IN CITY TRAFFIC, RUSH HOUR. HAD PREVIOUSLY ASKED DEALER TO CHECK, BUT THEY CLAIMED IT WAS FUNCTIONING PROPERLY. DEFECT 3: RACK AND PINION STEERING ASSEMBLY--WENT OUT SHORTLY AFTER ALTERNATOR, WHILE DRIVING IN THE DEALERSHIP PARKING LOT. DEFECT 4: TIMING CHAIN TENSIONER--TECHNICIAN SAID THIS CAUSED MAJOR ENGINE DAMAGE--GEARS, HEAD, ETC. DEFECT 5: HORN--HAS WORKED SPORADICALLY, AT BEST, FOR THE LAST YEAR AND A HALF. SEEMED LIKE A SHORT.
NHTSA ODI #740034
Mileage unknown · Jul 29, 2000
Engine And Engine CoolingEquipmentService Brakes, HydraulicCrashInjury
MY CONCERN IS THE CAR IS ONLY 3 YRS OLD AND WE ARE CONTINUEING TO HAVE PROBLEMS OCCUR, THE CIGARETTE LIGHTER HAS A SHORT IN IT AS WELL. *AK
NHTSA ODI #726197
Mileage unknown · Jul 28, 2000
Service Brakes, Hydraulic
BRAKES LOCK WHEN STOPPING RELEASE AND STOP RELEASE AND FINALLY STOP. DISTANCE TRAVELED UNTIL COMPLETE STOP IS ABOUT 10 TO 12 FEET. MY DAUGHTER HAS A 97 CAVALIER AND IT DOES THE SAME THING. THIS IS A VERY SERIOUS SAFETY PROBLEM AND MUST BE FIXED. THE DEALER PERSON SAID THAT IT IS NORMAL ADS ENGAGEMENT. BUT THAT DOESN'T PREVE…
Read full complaint
BRAKES LOCK WHEN STOPPING RELEASE AND STOP RELEASE AND FINALLY STOP. DISTANCE TRAVELED UNTIL COMPLETE STOP IS ABOUT 10 TO 12 FEET. MY DAUGHTER HAS A 97 CAVALIER AND IT DOES THE SAME THING. THIS IS A VERY SERIOUS SAFETY PROBLEM AND MUST BE FIXED. THE DEALER PERSON SAID THAT IT IS NORMAL ADS ENGAGEMENT. BUT THAT DOESN'T PREVENT A CRASH. HE SAID THAT WHEN ONE WHEEL IS NOT ON THE SAME SURFACE AS THE OTHER A DIFFERENT SIGNAL IS SENT TO EACH WHEEL AND THUS THE PROBLEM OF LOCKING AND RELEASING BRAKES. IT SEEMS TO ME THAT THIS IS A SYSTEMIC PROBLEM WITH ANTI LOCK BREAKS THAT ARE PLACING DRIVERS IN A PRECARIOUS POSITION. LUCKY FOR ME THERE WERE NOT VEHICLES IN FRONT OF ME WHEN THE BRAKES ACTED AS THEY DID. OTHERWISE I WOULD HAVE REAR ENDED THE VEHICLE IN FRONT OF ME WITH DAMAGE AND POSSIBLE INJURY TO BOTH OF US. *AK
NHTSA ODI #726145
Mileage unknown · Mar 20, 2000
Service Brakes, Hydraulic
AT ANY TIME WHEN VEHICLE WOULD SIT OVER NIGHT IN RAIN, THE NEXT DAY WHILE TRAVELING AND WHEN DEPRESSING THE BRAKE PEDAL, VEHICLE WOULD GO INTO EXTENDED STOPPING DISTANCE, AND WHEELS WOULD LOCK UP. DEALER HAS BEEN NOTIFIED. HAS YET OT BE REPAIRED. *AK *ML
NHTSA ODI #858792
Mileage unknown · Jan 14, 2000
Service Brakes, Hydraulic
ABS BRAKING SYSTEM MALFUNCTIONED, CAUSING EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. *AK
NHTSA ODI #855007
Mileage unknown · Nov 4, 1999
Service Brakes, Hydraulic
THIS IS AN ONGOING PROBLEM WITH THE FRONT ROTORS BECOMING WARPED AFTER ABOUT 15,000 TO 20,000 MILES OF USE. I WENT TO THE DEALER TWICE UNDER WARRENTY AND BOTH TIMES THEY TURNED THE ROTERS. I HAVE SINCE REPLACED THE ROTERS AND BRAKE PADS THREE TIMES. I THINK THIS IS HIGHLY UNUSUAL. I FEAR SOMEDAY THE BRAKING SYSTEM WILL COMPLETLY…
Read full complaint
THIS IS AN ONGOING PROBLEM WITH THE FRONT ROTORS BECOMING WARPED AFTER ABOUT 15,000 TO 20,000 MILES OF USE. I WENT TO THE DEALER TWICE UNDER WARRENTY AND BOTH TIMES THEY TURNED THE ROTERS. I HAVE SINCE REPLACED THE ROTERS AND BRAKE PADS THREE TIMES. I THINK THIS IS HIGHLY UNUSUAL. I FEAR SOMEDAY THE BRAKING SYSTEM WILL COMPLETLY FAIL.
NHTSA ODI #714333
Official recalls
7Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 6, 2002
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. ONE OF THE REAR SUSPENSION TRAILING ARM BOLTS CAN FATIGUE AND BREAK.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A LOSS OF VEHICLE CONTROL CAN OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR SUSPENSION TRAILING ARM FASTENERS.
Jun 29, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
Feb 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
Jun 28, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
Aug 29, 1996
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence & remedy
Consequence: THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
Illustration