THE PASSENGER SIDE SEAT STARTING MOVING WHEN SITTING ON IT 5 MONTHS AFTER CAR WITH PURCHASED BRAND NEW-- THE DEALER FIXED THE PROBLEM-- ENTIRE COMPONENT UNDERNEATH SEAT WAS REPLACED. 11 MONTHS LATER SAME PROBLEM-- DEALER FIXED AGAIN AT NO CHARGE-- THEN 2 YEARS LATER AFTER WARRANTY RAN OUT IT HAPPENED AGAIN-- ITS SLIDES SLIGHTLY…
Read full complaint
THE PASSENGER SIDE SEAT STARTING MOVING WHEN SITTING ON IT 5 MONTHS AFTER CAR WITH PURCHASED BRAND NEW-- THE DEALER FIXED THE PROBLEM-- ENTIRE COMPONENT UNDERNEATH SEAT WAS REPLACED. 11 MONTHS LATER SAME PROBLEM-- DEALER FIXED AGAIN AT NO CHARGE-- THEN 2 YEARS LATER AFTER WARRANTY RAN OUT IT HAPPENED AGAIN-- ITS SLIDES SLIGHTLY WHEN BRAKING. I HAVE NOT HAD THE MONEY TO TRY TO FIX THE PROBLEM AGAIN-- I KNOW THE DEALER WILL CHARGE ME NOW SINCE IT IS OUT OF WARRANTY A LONG TIME AGO.*AK
NHTSA ODI #758959
Mileage unknown · Aug 16, 2001
SeatsCrashInjury
VEHICLE WAS REAR ENDED IN A STOPPED POSITION BY OTHER AUTO AT 20+ MPH, DRIVERS' SEAT BACK COLLAPSED, CAUSING HUSBAND TO RECEIVE A BAD WHIP LASH INQUIRY.
NHTSA ODI #9004373
Mileage unknown · May 10, 2001
SeatsCrashInjury
CONSUMER WAS AT A STOP WHEN SHE WAS REARENDED WITH 40 MPH IMPACT. UPON IMPACT, DRIVER'S AND PASSENGER'S SEATS WENT FLYING BACK INTO A RECLINING POSITION, CAUSING INJURIES TO DRIVER. *AK
NHTSA ODI #887932
Mileage unknown · Mar 21, 2001
SeatsCrash
WHILE STOPPING AT A RED SIGNAL WAS REAR ENDED BY ANOTHER VEHICLE. UPON IMPACT, DRIVER'S SEAT COLLAPSED BACKWARD, LEAVING CONSUMER FLAT ON HIS. DEALER COULD NOT EXPLAIN CAUSE OF COLLAPSE.*AK
NHTSA ODI #883707
Mileage unknown · Jun 30, 2000
Seats
WHILE MAKING AN EMERGENCY STOP REAR FOLDING SEAT CAME OUT OF THE METAL BRACKETS. PROBLEM HAS NOT BEEN REPORTED TO DEALERSHIP. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #864589
Mileage unknown · Jan 7, 2000
SeatsCrashInjury
I WAS A PASSENGER IN MY CAR THAT WAS REAR-ENDED ON 12/26/99 AT APPROX 55-60 MPH WHILE WAITING FOR ONCOMING TRAFFIC TO MAKE A LEFT-HAND TURN. THIS PUSHED US INTO THE ONCOMING TRAFFIC LANE STOPPING WITHING 2-3 INCHES FRONT A FRONT END COLLISION. THE PASSENGER FRONT SEAT SLID FORWARD TO THE DASHBOAD,CAUSING MY LEGS AND WRISTS TO H…
Read full complaint
I WAS A PASSENGER IN MY CAR THAT WAS REAR-ENDED ON 12/26/99 AT APPROX 55-60 MPH WHILE WAITING FOR ONCOMING TRAFFIC TO MAKE A LEFT-HAND TURN. THIS PUSHED US INTO THE ONCOMING TRAFFIC LANE STOPPING WITHING 2-3 INCHES FRONT A FRONT END COLLISION. THE PASSENGER FRONT SEAT SLID FORWARD TO THE DASHBOAD,CAUSING MY LEGS AND WRISTS TO HIT THE DASHBOARD. THIS CAUSED SEVERE BRUISING AND CONTUSIONS TO MY SHINS (THE WORST BEING MY RIGHT LEG), MY WRISTS WERE SPRAINED FROM DASHBOARD, NECK WHIPLASHED BOTH SIDES AND SPINAL/LOW BACK PAIN FROM PELVIS BEING PUSHED UP, CAUSING COMPRESSION ON LOWER SPINE, LOWER RIGHT ABDOMINAL PAIN WITH NAUSEA, DIARREAH AND LOW GRADE FEVERS. SAYING MAYBE APPENDIX OR MUSCULAR.I REMEMBER SLAMMING INTO DASHBOARD EVEN WITH SEATBELT ON. MY SEAT WAS COMPLETELY AGAIN THE DASH WITH EXCEPTION OF ROOM NEEDED FOR LEGS TO HIT IT.THE SEAT MUST HAVE OR I COULD HAVE PUSHED SEAT BACK AFTERIMPACT. THE SEAT IS NOW NOT MOVING AT ALL. GMC SAYS SINCE AN ADJUSTER PAID PARTIAL SETTLEMENT TO BODY SHOP THEY WILL NOT DO ANYTHING ABOUT IT... I HAVE LIMITED TORT INSURANCE, 2 KIDS AND NOW NOT WORKING, AND IN NEED OF MONEY UNTIL INSURANCE PAYS ME MONTHLY WHAT I WOULD BE MAKING AT WORK. WHAT DO I DO? *AK
NHTSA ODI #717009
Mileage unknown · Aug 5, 1999
Seats
FRONT DRIVER'S SEAT FAILED TO LATCH IN PLACE; CAUSING SEAT TO FREELY MOVE;SEEKING HELP FROM NHTSA IN THIS MATTER. *AK
NHTSA ODI #844462
Mileage unknown · Aug 2, 1999
SeatsVisibility
DRIVER SEAT LOCKING MECHANISM DOES NOT LOCK THE DRIVER SEAT IN PLACE IN CERTAIN POSITION. THIS MAY CAUSE THE OCCUPANT TO LOSE CONTROL OF THE VEHICLE. ALSO THE WINDSHIELD WIPERS, WHEN TURNED OFF STAY IN THE UPRIGHT POSITION, OBSTRUCTING THE VIEW THE DRIVER. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #844069
Mileage unknown · Aug 7, 1998
Air BagsSeatsCrash
VEHICLE WAS REARENDED AT ABOUT 70MPH. UPON IMPACT, THE FRONT SEATBACKS COLLAPSED, AND THE AIRBAGS DID NOT DEPLOY. MANUFACTURER WILL BE NOTIFIED. *AK
NHTSA ODI #826403
Mileage unknown · Jul 31, 1998
SeatsInjury
DURING A COLLISION, THE DRIVER SUSTAINED A SERIOUS PERMANENT INJURY TO LEGS DUE TO DRIVER'S SEAT PUSHING HER LOWER BODY UP UNDER THE INSTRUMENT PANEL AND INTO STEERING COLUMN. DRIVER ALSO INJURED WRIST.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH MIS-LOCATED WELDS AT THE JOINT BETWEEN THE LEFT ROCKER PANEL INNER REINFORCEMENT AND THE BODY SIDE RING. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 214, "SIDE DOOR STRENGTH."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SHEET METAL STRUCTURE WOULD NOT PERFORM AS DESIRED INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSPECT THE WELDS AND, IF NECESSARY, PLACE FIVE WELDS BETWEEN THE INVOLVED PANELS AND APPLY PRIMER AND TOPCOAT FINISH MATERIALS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE COMPACT SPARE TIRE ASSEMBLIES WERE ASSEMBLED WITH INCORRECT RIMS. IF THE SPARE TIRE IS UNDERINFLATED, THE BEAD CAN SEPARATE FROM THE RIM CAUSING A RAPID LOSS OF AIR. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: A RAPID LOSS OF AIR CAN INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE RIM ON THE COMPACT SPARE TIRE ASSEMBLY. OWNERS ARE REQUESTED NOT TO USE THE SPARE TIRE UNTIL THE RIM HAS BEEN REPLACED.
THESE VEHICLES WERE BUILT WITH AN INCORRECT WIPER BLADE ASSEMBLY (17" LONG INSTEAD OF 22" LONG) ON THE DRIVER'S SIDE. THIS DOES NOT COMPLY WITH FMVSS NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS."
Consequence & remedy
Consequence: THE AREA AND PATTERN WIPED ON THE WINDSHIELD WILL BE REDUCED AND COULD AFFECT THE DRIVER'S VIEW IN WET WEATHER INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT FOR THE CORRECT WIPER BLADE ASSEMBLY AND INSTALL A CORRECT LENGTH WIPER BLADE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1997 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration