Electrical SystemEngine And Engine CoolingEquipment
DRIVING DOWN THE ROAD, MOTOR STOPS RUNNING AND I LOST ALL POWER BOTH STEERING AND ELECTRICAL. GOT IT TO THE SIDE OF THE ROAD. WAITED 2 MINUTES AND STARTED IT BACK UP IT WAS FINE. ONLY DID THIS 2 TIMES WITHIN A WEEK PERIOD. ENGINE IDLE ROUGH SINCE I PURCHASED IT IN 1998. TOOK IT IN AND THEY SAID THEY COULD NOT FIND ANYTHING. …
Read full complaint
DRIVING DOWN THE ROAD, MOTOR STOPS RUNNING AND I LOST ALL POWER BOTH STEERING AND ELECTRICAL. GOT IT TO THE SIDE OF THE ROAD. WAITED 2 MINUTES AND STARTED IT BACK UP IT WAS FINE. ONLY DID THIS 2 TIMES WITHIN A WEEK PERIOD. ENGINE IDLE ROUGH SINCE I PURCHASED IT IN 1998. TOOK IT IN AND THEY SAID THEY COULD NOT FIND ANYTHING. CAME BACK SEVERAL TIMES THEY ESSENTIALLY SAID THAY COULD DO NOTHING THATS JUST HOW THEY RUN. MOTOR SURGES AND LAGS AFTER START UP. REGARDLESS OF TEMPERATURE. PUSH PEDAL MOTOR BOGS DOWN AND THEN IT WILL TAKE OFF. REPLACED ALMOST EVERY SENSOR UNDER THE HOOD PROBLEM IS STILL PRESENT. BATTERY TOOK A DUMP AT ALMOST 4 YEARS. ENGINE SPUN #3 AND #4 BEARINGS ON A COLD START UP. THEY ADVISED ME THAT I NEEDED A WATER PUMP AT THE SAME TIME.PASS POWER WINDOW WAS ALWAYS SLOW. REPLACED APPROX MID 2002 REAR SUSPENSION CLUNKS AND SOUNDS LIKE IT HAS LUMBER IN THE TRUNK. WHEEL STUDS SNAP EASILY AS I HAVE REPLACE APPROXIMATELY 10. REAR BRAKES DRAG AND GRAB EVEN AFTER REPLACEMENT. FRONT BRAKES WEAR EXCESSIVELY. RUBBER MUFFLER HANGER WEARS OUT. REPLACED 2 TIMES.
NHTSA ODI #10069950
39,500 miles · Jun 29, 2003
Air BagsElectrical SystemEngine And Engine Cooling
FUEL PUMP SEAL DISINTEGRATED. COST $1,081.00 (INCLUDING 3 DAY CAR RENTAL). EARLIER THIS YEAR THERE WAS A RECALL ON THE STEERING COLUMN AND I WOUND UP PAYING AN ADDITIONAL $600 FOR OTHER DEFECTS NOT COVERED BY THE RECALL. THINK THAT THIS AND MANY ADDITIONAL PROBLEMS ON THIS CAR CONSTITUTE IT BEING A LEMON. MORE THAN 5 RECALLS IN…
Read full complaint
FUEL PUMP SEAL DISINTEGRATED. COST $1,081.00 (INCLUDING 3 DAY CAR RENTAL). EARLIER THIS YEAR THERE WAS A RECALL ON THE STEERING COLUMN AND I WOUND UP PAYING AN ADDITIONAL $600 FOR OTHER DEFECTS NOT COVERED BY THE RECALL. THINK THAT THIS AND MANY ADDITIONAL PROBLEMS ON THIS CAR CONSTITUTE IT BEING A LEMON. MORE THAN 5 RECALLS IN 7 YEARS. *NLM
NHTSA ODI #10023976
Mileage unknown · Jul 25, 2002
Wheels
APPROX. 1 MONTH AGO, THE CAR BEGAN TO "KNOCK" AND SHAKE VERY BADLY. I DROVE IT TO A REPAIR SHOP NEAR MY HOME, WHERE IT WAS DIAGNOSED WITH 5 BROKEN BOLTS IN THE FRONT DRIVER'S SIDE WHEEL. THIS WAS FIXED. YESTERDAY (7/24/02), AT APPROX. 12:00 NOON, I WAS DRIVING WITH MY CHILDREN NORTHBOUND ON ROUTE 18 IN EAST BRUNSWICK, NJ, WHEN…
Read full complaint
APPROX. 1 MONTH AGO, THE CAR BEGAN TO "KNOCK" AND SHAKE VERY BADLY. I DROVE IT TO A REPAIR SHOP NEAR MY HOME, WHERE IT WAS DIAGNOSED WITH 5 BROKEN BOLTS IN THE FRONT DRIVER'S SIDE WHEEL. THIS WAS FIXED. YESTERDAY (7/24/02), AT APPROX. 12:00 NOON, I WAS DRIVING WITH MY CHILDREN NORTHBOUND ON ROUTE 18 IN EAST BRUNSWICK, NJ, WHEN THE CAR BEGAN TO KNOCK AND SHAKE AGAIN, AND MY FRONT PASSENGER SIDE WHEEL JUST FELL OFF. LUCKILY, DUE TO TRAFFIC CONDITIONS, I WAS IN THE RIGHT LANE AND NOT TRAVELLING VERY FAST (@ 20-25 MPH). LUCKILY, I WAS RIGHT AT THE ENTRANCE TO A MOBIL STATION WHEN IT HAPPENED, AND THE WHEEL ROLLED INTO THEIR PARKING LOT; I FOUND THE PIECES OF THE BOLTS THAT WERE BROKEN ALL AROUND THE PARKING LOT. THE WHEEL CAUSED A SMALL AMOUNT OF DAMAGE TO THE BACK OF A CAR (A BACKUP SENSOR WAS BROKEN) THAT WAS IN THE LOT. THIS DAMAGE WAS AROUND $200; THE COST TO PUT MY WHEEL BACK ON, AND FOR ALL NEW BOLTS ON THAT WHEEL WAS ABOUT $100. THERE IS ALSO DAMAGE TO MY PASSENGER SIDE FENDER, FOR WHICH I HAVE NOT GOTTEN AN ESTIMATE FOR, MY HUSBAND IS GUESSING ABOUT $700; COULD I FURNISH YOU WITH AN EXACT ESTIMATE AT A LATER DATE? ADDITIONALLY, UPON PUTTINGTHE WHEEL BACK ON, THEY DISCOVERED DAMAGE TO THE "U-JOINT". WE TRANSFERED THE CAR TO OUR OWN MECHANIC TO HAVE THIS PROBLEM ADDRESSED; I WILL HAVE MORE RECEIPTS, PROBABLY TOMORROW. I AM ALSO HAVING THE MECHANIC REPLACE THE BOLTS AND LUGNUTS ON BOTH REAR WHEELS - I STRONGLY FEEL THAT THERE MUST BE SOMETHING WRONG WITH THESE BOLTS FOR THEM TO KEEP BREAKING LIKE THIS.*JB
NHTSA ODI #764746
Mileage unknown · Jan 5, 2000
WheelsCrashInjury
THE LEFT REAR WHEEL CAME OFF OF THE CAR WITHOUT WARNING WHILE TRAVELING. DRIVER LOST CONTROL OF VEHICLE AND THE VEHICLE OVERTURNED SEVERAL TIMES AND WAS TOTALLED. DRIVER WAS INJURED. NO OTHER PASSENGERS IN CAR. *AK
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. BECAUSE OF CERTAIN CALIBRATIONS IN THE AIR BAG'S SENSING AND DIAGNOSTIC MODULE, AN INADVERTENT AIR BAG DEPLOYMENT COULD OCCUR IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.
Consequence & remedy
Consequence: AIR BAGS DEPLOY WITH GREAT FORCE AND CAN SERIOUSLY INJURE UNRESTRAINED OCCUPANTS WHO ARE TOO CLOSE TO THEM.
Remedy: DEALERS WILL RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
THE ACCELERATOR CONTROL CABLE COULD HAVE BEEN KINKED DURING ASSEMBLY CAUSING HIGH ACCELERATOR PEDAL EFFORT, STICKING ACCELERATOR CONTROL CABLE, OR A BROKEN ACCELERATOR CONTROL CABLE.
Consequence & remedy
Consequence: IF THE ACCELERATOR CONTROL CABLE STICKS OR BREAKS, UNWANTED ACCELERATION AND/OR LOSS OF THROTTLE CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CONTROL CABLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03007 · Unintended Vehicle Acceleration
Opened Oct 14, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Fuel System, Other:delivery
ON SEPTEMBER 23, 2003, THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) RECEIVED A LETTER DATED SEPTEMBER 8, 2003 FROM MR. DONALD FRIEDMAN, PETITIONING THE AGENCY TO OPEN A DEFECT INVESTIGATION INTO UNINTENDED ACCELERATION INVOLVING [MODEL YEAR] 1996 AND 1997 GENERAL MOTORS J-CARS.IN SUPPORT OF HIS PETITION, MR. FRIEDMAN CITED A REPORT HE RECEIVED FOR GM SHOWING IT HAD RECEIVED FAR MORE REPORTS OF ALLEGED UNINTENDED ACCELERATION FOR THESE MODELS THAN FOR OTHERS.AFTER ASSESSING THE DATA CLAIMED BY THE PETITIONER TO JUSTIFY HIS REQUEST, ODI FOUND NO INDICATION THAT DEFECT TREND RELATED TO THE PETITIONER'S ALLEGATIONS EXISTS AT THIS TIME.THEREFORE, THERE IS NO REASONABLE POSIBILITY THAT AN ORDER CONCERNING THE NOTIFICATION AND REMEDY OF A SAFETY-RELATED DEFECT WOULD BE ISSUED AS A RESULT OF GRANTING MR. FRIEDMAN'S PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE ATTACHED FEDERAL REGISTER NOTICE.
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
EA98001 · Oversensitive Air Bag Deployments
Opened Jan 23, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
PE97041 · Inadvertent Air Bag Deployments
Opened Sep 9, 1997 · Closed Jan 23, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
1996 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration