TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE DRIVING 65MPH, THE GAS GAUGE IDLED BACK AND FORTH UNCONTROLLABLY. WHEN THE FUEL TANK IS FULL THE GAUGE IDLED FROM FULL TO A QUARTER THEN BACK TO FULL. IT ALSO IDLED FROM A HALF TANK, QUARTER TANK THEN TO EMPTY. WHEN ATTEMPTING TO CLOSE THE TRUNK, IT FAILED TO CLOSE DUE …
Read full complaint
TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE DRIVING 65MPH, THE GAS GAUGE IDLED BACK AND FORTH UNCONTROLLABLY. WHEN THE FUEL TANK IS FULL THE GAUGE IDLED FROM FULL TO A QUARTER THEN BACK TO FULL. IT ALSO IDLED FROM A HALF TANK, QUARTER TANK THEN TO EMPTY. WHEN ATTEMPTING TO CLOSE THE TRUNK, IT FAILED TO CLOSE DUE TO THE LINK AND LATCH MOVING OUT OF PLACE (NOT ALIGNED). THIS FAILURE ALSO CAUSED HER TRUNK TO OPEN RANDOMLY. WHILE DRIVING 65 MILES PER HOUR, THE VEHICLE BEGAN SHAKING UNCONTROLLABLY. THE DEALER STATED THAT THE FAILURE IS DUE TO THE STRUTS. THE STRUTS WERE REPLACED THREE TO FOUR TIMES AND THE PROBLEM CONTINUED TO OCCUR. THE FAILURE AND CURRENT MILEAGE WERE 179850.
NHTSA ODI #10191386
Mileage unknown · Apr 12, 2002
Latches/locks/linkages
KEYS TO CONSUMER'S FRIENDS LEBARON CAN UNLOCK CHEVROLET. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8007520
Mileage unknown · Aug 18, 1997
Latches/locks/linkages
PARKED VEHICLE, LOCKED ALL DOORS, MANUAL LOCKS, ABOUT 1 HOUR LATER, REAR DOOR OPENED WITHOUT UNLOCKING IT. OWNER HAD TO TIE DOOR SHUT BECAUSE DOOR WOULD NOT LATCH CLOSE/LOCK. ACCORDING TO DEALER, INTERNAL MECHANISM OF LOCK BROKE, REPLACING DOOR LOCK ASSEMBLY. *AK
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
1995 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration