I WAS TRAVELING ABOUT 60 MPH ON A HIGHWAY WHEN THE PANEL LIGHTS CAME ON AND THE CAR QUIT. I TRAVELED ABOUT 10FT WHEN THE CAR CAME TO A HALT AND WOULD NOT GO ANY MORE. AFTER ABOUT 15 MINUTES, I TRIED TURNED THE KEY AND THE CAR STARTED. I TRAVELED ABOUT 15 MILES WITH THE CAR ALMOST STALLING 2 TO 3 TIMES ALONG THE WAY. IT STAR…
Read full complaint
I WAS TRAVELING ABOUT 60 MPH ON A HIGHWAY WHEN THE PANEL LIGHTS CAME ON AND THE CAR QUIT. I TRAVELED ABOUT 10FT WHEN THE CAR CAME TO A HALT AND WOULD NOT GO ANY MORE. AFTER ABOUT 15 MINUTES, I TRIED TURNED THE KEY AND THE CAR STARTED. I TRAVELED ABOUT 15 MILES WITH THE CAR ALMOST STALLING 2 TO 3 TIMES ALONG THE WAY. IT STARTED FINE FOR THE NEXT 4 DAYS AND ALMOST STALLED ANOTHER 5 TIMES. DURING THIS TIME THE ENGINE LIGHT WOULD FLICKER. AFTER 5 DAYS THE CAR WOULDN'T START, AT ALL. IT HAD TO BE TOWED AND FIXED. THIS IS RELATED TO THE MODULATOR AND CRANK SENSOR. IN REGARDS TO THE SERPENTINE TENSIONERS AND BELT, THE FIRST BELT WAS REPLACED AFTER IT WAS SQUEKING. WHILE DRIVING, AT ABOUT 40 MPH, I FORGET WHICH LIGHT CAME ON, BUT I HAD TO PULL INTO A MIDAS STATION AND THEY DIAGNOSED THAT THE TENSIONERS HAD TO BE REPLACED. THIS PREVIOUS BELT WAS ALSO SQUEEKING BEFORE THE TENSIONER WAS REPLACED.*AK
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02001 · Fire In Steering Column Area
Opened Jan 3, 2002 · Closed Mar 15, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
1995 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration