NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
82 reportsClear category filter48,000 miles · Oct 31, 2008
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHEN THE VEHICLE WAS STARTED, THE BATTERY LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED. LATER THAT DAY, THE CONTACT DROVE TO THE DEALER AND THEY STATED THAT THE THERMOSTAT WAS DEFECTIVE. THE MECHANIC CLAIMED THAT THE VEHICLE …
Read full complaint
TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHEN THE VEHICLE WAS STARTED, THE BATTERY LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED. LATER THAT DAY, THE CONTACT DROVE TO THE DEALER AND THEY STATED THAT THE THERMOSTAT WAS DEFECTIVE. THE MECHANIC CLAIMED THAT THE VEHICLE WAS REPAIRED, BUT IMMEDIATELY FOLLOWING, THE BATTERY LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP AND THE MECHANIC STATED THAT THE BATTERY WAS DEFECTIVE AND MADE THE REPLACEMENT. THE FOLLOWING DAY, THE CONTACT RETURNED TO THE DEALER DUE TO THE SAME FAILURE, BUT THEY COULD NOT DETERMINE THE CAUSE. THE VEHICLE HAS NOT BEEN REPAIRED SINCE THE MOST RECENT FAILURE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 50,000 AND FAILURE MILEAGE WAS 48,000.
NHTSA ODI #10247351
60,000 miles · Apr 7, 2008
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE TURNING THE VEHICLE AT VARIOUS SPEEDS, THE IGNITION AND ENGINE COMPLETELY FAILED. THE VEHICLE TAKES SEVERAL MINUTES BEFORE IT CAN BE RESTARTED. THE CONTACT CALLED THE DEALER AND THEY STATED THAT THE VEHICLE WAS NOT UNDER A RECALL. THE CURRENT MILEAGE WAS 78,340 AND FAILURE…
Read full complaint
TL*THE CONTACT OWNS A 1995 CHEVROLET CAVALIER. WHILE TURNING THE VEHICLE AT VARIOUS SPEEDS, THE IGNITION AND ENGINE COMPLETELY FAILED. THE VEHICLE TAKES SEVERAL MINUTES BEFORE IT CAN BE RESTARTED. THE CONTACT CALLED THE DEALER AND THEY STATED THAT THE VEHICLE WAS NOT UNDER A RECALL. THE CURRENT MILEAGE WAS 78,340 AND FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10223589
72,012 miles · Jul 12, 2007
Engine And Engine CoolingService Brakes, HydraulicStructure
I BOUGHT A 1995 CHEVROLET CAVALIER NEW, IN JULY 1995. I HAD THE FOLLOWING MAJOR REPAIRS DONE ON THE CAR. ON 8/97 -ENTIRE EXHAUST FROM CONVERTER BACK BAD BAFFLED UNDER WARRANTY. ON 10/97-SERPENTINE BELT/ROTORS/ALTERNATOR & RECALL ON HAZARD LIGHTS UNDER WARRANTY. 4/00-HEAD GASKET,SEAL,OIL,FILTER,COOLANT;RECALL ON COVER,SHIELD…
Read full complaint
I BOUGHT A 1995 CHEVROLET CAVALIER NEW, IN JULY 1995. I HAD THE FOLLOWING MAJOR REPAIRS DONE ON THE CAR. ON 8/97 -ENTIRE EXHAUST FROM CONVERTER BACK BAD BAFFLED UNDER WARRANTY. ON 10/97-SERPENTINE BELT/ROTORS/ALTERNATOR & RECALL ON HAZARD LIGHTS UNDER WARRANTY. 4/00-HEAD GASKET,SEAL,OIL,FILTER,COOLANT;RECALL ON COVER,SHIELD,RETAINER,SEALANT (DEALER COVERED COSTS UNDER A SPECIAL POLICY ADJUSTMENT. 4/00-EGR VALVE 10/00-ADJUST SERPENTINE BELT;REPLACE SERPENTINE BELT 10/01-REPLACE BACK BRAKE PADS,CLEAN FRONT PADS 05/02-REPLACE FAN BELT & TENSIONER;RECALL ON IGNITION SWITCH 06/02-BROKEN FORWARD CLUTCH HOUSING,CLUTCH,GASKETS,FLUID,LEFT FRONT AXLE ASSEMBLY 07/02-REPLACE BATTERY,BAD CELL DUE TO CAR SITTING FOR SO LONG DURING PREVIOUS REPAIR 12/03-WATER PUMP, HEAD GASKET, THERMOSTAT,OIL,FILTER,COOLANT $461.79-50% OF BILL REIMBURSED BY CHEVROLET UPON WRITTEN REQUEST 07/03-REAR BRAKES; 08/04-RESISTOR (BLOWER MOTOR, 09/04-ALTERNATOR 07/05-FRONT ROTORS & PADS; 06/06-REAR BRAKE LINE 06/07-WON'T PASS STATE INSPECTION-FRAME RUSTING OUT. REAR BUMPER SUPPORT FRAME MUST BE REPLACED TO PASS INSPECTION, MORE FRAME REPAIR WILL LIKELY BE NEEDED FOR NEXT INSPECTION;HEAD GASKET IS STARTING TO SEEP AGAIN THIRD HEAD GASKET. I CONTACTED CHEVROLET TWICE BY THEIR E-MAIL SITE IN THE PAST 2 WEEKS AND HAVE HAD NO RESPONSE. SITE CLAIMS RESPONSE WILL BE WITHIN 48 HOURS. I ASKED FOR REPAIR COSTS FOR REAR FRAME SUPPORT, HEAD GASKET OR A VOUCHER FOR CREDIT TOWARD A NEW/NEWER VEHICLE. POINTED OUT THE PROBLEM OF THE THIRD HEAD GASKET, THAT FRAME RUSTED ON A CAR ONLY 12 YEARS OLD THAT JUST LAST MONTH TURNED 72,000 MILES. ALSO, POINTED OUT THAT WHEN I BOUGHT THE CAR THE DEALER RECOMMENDED A PROTECTIVE UNDERCOUNTS WHICH I AGREED TO. WHEN I READ THE OWNER'S MANUAL IT STATED NOT APPLY *AK
NHTSA ODI #10196202
Mileage unknown · Jun 7, 2006
Engine And Engine Cooling
CONSUMER REQUESTED RECALL INFORMATION ON A 1995 CHEVROLET CAVALIER. *KB. NAR NO ADDRESS PROVIDED. THE CONSUMER HAD VALVE WORK DONE ON THE VEHICLE. THE CONSUMER BELIEVES THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THIS REPAIR. *NM
NHTSA ODI #10160507
149,000 miles · Apr 17, 2006
Engine And Engine Cooling
MASSIVE LEAKS OF COOLANT DUE TO FAULTY GASKET CHECK ENGINE LIGHT REMAINS CONSTANT RUNNING THROUGH A BOTTLE OF ANTIFREEZE A DAY B/C OF SAID LEAK. *NM
NHTSA ODI #10155499
Mileage unknown · Jan 13, 2006
Engine And Engine CoolingFire
1995 CHEVROLET CAVALIER LOST POWER, WHEN COMING TO A STOP. VEHICLE CAUGHT ON FIRE. *TS *JB
NHTSA ODI #10148638
Mileage unknown · Feb 7, 2005
Engine And Engine Cooling
CHECK ENGINE LIGHT WAS TURNING ON AND OFF INTERMITTENTLY, INFORMING THE OWNER THAT VEHICLE NEEDED COOLANT. TAKEN VEHICLE TO DEALER FOR REPAIRS AND RESULTS SHOWED THAT THE VEHICLE NEEDED A NEW HEAD GASKET. THEN, VEHICLE EXPERIENCED THE SAME PROBLEM TWICE WITHIN THE LAST FEW MONTHS. *AK
NHTSA ODI #10110949
82,500 miles · May 7, 2004
Engine And Engine Cooling
IN JANUARY 2004 THE CHECK COOLANT GUAGE WOULD LIGHT INTERMITTENTLY, THEN ON A DAILY BASIS, AND VEHICLE WAS TAKEN TO MECHANIC FOR INSPECTION. MECHANIC HAD FOUND THAT THERE WAS COOLANT LEAKAGE FROM THE RADIATOR AND HAD ADVISED THAT THE CYLINDER HEAD GASKET BE REPLACED.*AK
NHTSA ODI #10068463
60,000 miles · Aug 4, 2003
Engine And Engine Cooling
AS DESCRIBED IN PRIOR DEFECT REPORTS, E.G. 98054A, MY CAVALIER HAS A LEAKING HEAD GASKET. HOWEVER, SINCE IT WAS DISCOVERED AFTER THE WARRANTY EXPIRED, THE DEALER & MFR HAVE REFUSED TO REPAIR IT. I'M FACED WITH A HEFTY REPAIR BILL FOR A KNOWN MFR'S DEFECT.*AK
NHTSA ODI #10030736
Mileage unknown · Jul 7, 2003
Engine And Engine Cooling
CONSUMER STATES THEY STILL HAVING THE SAME PROBLEMS AFTER THE RECALL ON HEAD GASKET HAS BEEN PERFORM ON VEHICLE. RECALL NUMBER UNKNOWN. KYLE CHEVROLET 860-872-6530. *AK
NHTSA ODI #10026593
Official recalls
4Mar 6, 2002
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Dec 17, 1996
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Jul 26, 1995
SOME WELDS WERE OMITTED FROM THE BODY LOCK PILLAR, OR "B" PILLAR. THIS DOES NOT COMPLY WITH FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF A VEHICLE CRASH SHOULD OCCUR, OCCUPANT PROTECTION LEVELS COULD BE REDUCED.
Remedy: ALL VEHICLES IN THIS RECALL CAMPAIGN HAVE BEEN REPURCHASED AND REPLACED WITH A COMPARABLE VEHICLE.
Feb 16, 1995
THESE VEHICLES HAVE BEEN BUILT WITH WELDS MISSING FROM THE FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES CAUSING EXCESSIVE LOADS ON THE EXISTING WELDS.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN SEPARATION OF THE FRONTBUSHING SLEEVE SUBASSEMBLY FROM THE CONTROL ARM INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT BOTH LEFT-HAND AND RIGHT-HAND FRONT SUSPENSION LOWER CONTROL ARM ASSEMBLIES AND REPLACE ALL CONTROL ARM ASSEMBLIES FOUND WITH OMITTED WELDS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration