IllustrationPASSENGER'S SEAT DOES NOT LOCK AND FALLS FORWARD WHEN STOPPING SUDDENLY. VERY DANGEROUS
1994 Chevrolet Cavalier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Chevrolet Cavalier do not stand out strongly from the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 212 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 56 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 23 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports3 fire reports13 injury reports
What owners actually said
212 reportsDRIVER'S SEAT DOES NOT LOCK AND FALL FORWARD WHEN STOPPING SUDDENLY. VERY DANGEROUS.
DRIVER'S SIDE DOOR DOESN'T UNLOCK WHEN POWER LOCK IS PRESSED. MUST BE MANUALLY UNLOCKED. OCCURS EVERY TIME THE DOOR IS ATTEMPTED TO UNLOCK.
HORN PAD AND INTERNAL ASSEMBLY FALL OFF OCCASIONALLY AND CONTINUE TO BE LOOSE. AWAITING NEXT DEFECT....
WINDSHIELD LEAKS FROM THE AREA ABOVE THE REARVIEW MIRROR. WATER COLLECTS AND EVENTUALLY DRIPS ONTO THE GEARSHIFT.
WIPERS DO NOT WORK ON DELAY OR LOW SPEEDS. ONLY ON HIGH. WASHER WILL NOT SPRAY FLUID UNLESS WIPERS ARE ON HIGH. OCCASIONALLY WIPERS WILL WORK ON LOW OR DELAY, HOWEVER; THEY WILL STICK.
FAILURE OF ORIGNAL, AND 2 FOLLOWING ALTERNATORS.
A BLOWN ENGINE HEAD GASKET.SEEKING HELP FROM NHTSA IN THIS MATTER. DEALER/MANUFACTURER NOTIFED, AND INFORMED CONSUMER THAT NOTHING COULD BE DONE UNLESS CONSUMER PICKS UP FULL COST FOR REPAIRS. *AK
SCREWS WERE MISSING FROM THE MOLDING RUNNING FROM THE DASHBOARD TO THE HEADLINER ON THE PASSENGER SIDE. NLM
ABS FAILS EVERY TIME ACTIVATED, SYSTEM CYCLES SLOWLY, WITH UNCONTROLLABLE LOCK AND RELEASE OF WHEELS. THIS HAS OCCURED ON A FEW OCCASIONS. 1 OCCASION RESULTED IN AN ACCIDENT. ENGINE/VEHICLE VIBRATES HEAVILY WHEN IDLING IN GEAR. HAS DONE SO SINCE PURCHASE, BUT HAS GOTTEN PROGRESSIVELY WORSE. HORN PAD HAS DISLOGED AND FALLEN …
Read full complaint
ABS FAILS EVERY TIME ACTIVATED, SYSTEM CYCLES SLOWLY, WITH UNCONTROLLABLE LOCK AND RELEASE OF WHEELS. THIS HAS OCCURED ON A FEW OCCASIONS. 1 OCCASION RESULTED IN AN ACCIDENT. ENGINE/VEHICLE VIBRATES HEAVILY WHEN IDLING IN GEAR. HAS DONE SO SINCE PURCHASE, BUT HAS GOTTEN PROGRESSIVELY WORSE. HORN PAD HAS DISLOGED AND FALLEN BETWEEN STEERING WHEEL SPOKES ON SEVERAL OCCASIONS, NEARLY RESULTING IN ACCIDENTS. DRIVER'S SIDE SEAT LATCH DOES NOT RETAIN SEATBACK FROM TRAVELLING FORWARD. IT HAS ALWAYS BEEN THIS WAY. SAFETY ISSUE. AIR CONDITIONER FAILED AFTER ABOUT 9 MONTHS, WITH NO PRIOR USE. AFTER REPAIR, IT FAILED AGAIN WITHIN 3 MONTHS.
Official recalls
194V115000 · Steering:linkages:knuckle:spindle:arm
Jun 24, 1994
THESE VEHICLES WERE BUILT WITH OVERTORQUED DRIVE AXLE SPINDLE NUTS. THIS CONDITION CAN CAUSE EXCESSIVE LOADS ON THE SPINDLE NUT AND DRIVE AXLE RESULTING IN FAILURE OF THE DRIVE AXLE OR THE SPINDLE NUT. FAILURE OF EITHER OF THESE COMPONENTS CAN RESULT IN SEPARATION OF THE STEERING KNUCKLE TIRE-WHEEL ASSEMBLY FROM THE DRIVE AXLE.
Consequence & remedy
Consequence: THIS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES. CORRECTIVE ACTION: DEALERS WILL REPLACE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA94033 · Horn Pad Falls Off
Opened Sep 29, 1994 · Closed Mar 29, 1996
Status: closed (inferred from source dates) · Electrical System:horn
THIS INVESTIGATION IS CLOSED.GM WILL CONDUCT A SAFETY IMPROVEMENT CAMPAIGN TO ADDRESS THE CONCERNS RAISED BY THE DETACHMENT OF THE HORN PAD FROM THE STEERING WHEEL IN THE SUBJECT VEHICLES.FOR A TECHNICAL ANALYSIS OF THE PROBLEM SEE EA94-033 ENGINEERING TECHNICAL REPORT.
PE94042 · Horn Button Falling Off
Opened May 23, 1994 · Closed Sep 29, 1994
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available