Electrical SystemEngine And Engine CoolingEquipment
CONSUMER STATED WHEN APPLYING THE BRAKES, IT FELT LIKE THE VEHICLE WAS TRYING TO STOP ON WET LEAVES, IT WAS SOON DISCOVERED THAT THE BRAKES WERE INSTALLED WRONG BY THE DEALER ON JUNE 14, 2000, THE DEALER OFFERED CONSUMER A 50 PERCENT SPLIT ON THE BRAKE WORK, HOWEVER CONSUMER BELIEVES THAT THE DEALER SHOULD PAY FOR THE ENTIRE BRA…
Read full complaint
CONSUMER STATED WHEN APPLYING THE BRAKES, IT FELT LIKE THE VEHICLE WAS TRYING TO STOP ON WET LEAVES, IT WAS SOON DISCOVERED THAT THE BRAKES WERE INSTALLED WRONG BY THE DEALER ON JUNE 14, 2000, THE DEALER OFFERED CONSUMER A 50 PERCENT SPLIT ON THE BRAKE WORK, HOWEVER CONSUMER BELIEVES THAT THE DEALER SHOULD PAY FOR THE ENTIRE BRAKE JOB SINCE THEY INSTALLED THE REAR BRAKES ON THE FRONT AND VICE VERSA. *JB
NHTSA ODI #564993
Mileage unknown · Aug 3, 1999
Electrical SystemEngine And Engine CoolingEquipment
SCREWS WERE MISSING FROM THE MOLDING RUNNING FROM THE DASHBOARD TO THE HEADLINER ON THE PASSENGER SIDE. NLM
NHTSA ODI #547740
Mileage unknown · Jul 28, 1999
Electrical SystemEngine And Engine CoolingEquipmentCrashInjury
ABS FAILS EVERY TIME ACTIVATED, SYSTEM CYCLES SLOWLY, WITH UNCONTROLLABLE LOCK AND RELEASE OF WHEELS. THIS HAS OCCURED ON A FEW OCCASIONS. 1 OCCASION RESULTED IN AN ACCIDENT. ENGINE/VEHICLE VIBRATES HEAVILY WHEN IDLING IN GEAR. HAS DONE SO SINCE PURCHASE, BUT HAS GOTTEN PROGRESSIVELY WORSE. HORN PAD HAS DISLOGED AND FALLEN …
Read full complaint
ABS FAILS EVERY TIME ACTIVATED, SYSTEM CYCLES SLOWLY, WITH UNCONTROLLABLE LOCK AND RELEASE OF WHEELS. THIS HAS OCCURED ON A FEW OCCASIONS. 1 OCCASION RESULTED IN AN ACCIDENT. ENGINE/VEHICLE VIBRATES HEAVILY WHEN IDLING IN GEAR. HAS DONE SO SINCE PURCHASE, BUT HAS GOTTEN PROGRESSIVELY WORSE. HORN PAD HAS DISLOGED AND FALLEN BETWEEN STEERING WHEEL SPOKES ON SEVERAL OCCASIONS, NEARLY RESULTING IN ACCIDENTS. DRIVER'S SIDE SEAT LATCH DOES NOT RETAIN SEATBACK FROM TRAVELLING FORWARD. IT HAS ALWAYS BEEN THIS WAY. SAFETY ISSUE. AIR CONDITIONER FAILED AFTER ABOUT 9 MONTHS, WITH NO PRIOR USE. AFTER REPAIR, IT FAILED AGAIN WITHIN 3 MONTHS.
NHTSA ODI #709339
Mileage unknown · Nov 5, 1995
EquipmentStructureSuspension
BOTH DOOR WINDOWS FELL DOWN/BROKE.
NHTSA ODI #487345
Mileage unknown · Nov 2, 1995
Equipment
AIR COMPRESSOR FAILURE IN VEHICLE. TT
NHTSA ODI #974473
Mileage unknown · Apr 3, 1995
Engine And Engine CoolingEquipmentPower Train
LUGGAGE RACK ENDS ARE RUSTED AND NOT SEATED PROPERLY, CAUSING RACK CORNERS TO LOOSEN.
THESE VEHICLES WERE BUILT WITH OVERTORQUED DRIVE AXLE SPINDLE NUTS. THIS CONDITION CAN CAUSE EXCESSIVE LOADS ON THE SPINDLE NUT AND DRIVE AXLE RESULTING IN FAILURE OF THE DRIVE AXLE OR THE SPINDLE NUT. FAILURE OF EITHER OF THESE COMPONENTS CAN RESULT IN SEPARATION OF THE STEERING KNUCKLE TIRE-WHEEL ASSEMBLY FROM THE DRIVE AXLE.
Consequence & remedy
Consequence: THIS CAN RESULT IN LOSS OF VEHICLE CONTROL AND A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES. CORRECTIVE ACTION: DEALERS WILL REPLACE LEFT-HAND AND RIGHT-HAND DRIVE AXLES, BEARING-HUB ASSEMBLIES, SPINDLE NUTS, AND WASHERS ON ALL INVOLVED VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA94033 · Horn Pad Falls Off
Opened Sep 29, 1994 · Closed Mar 29, 1996
Status: closed (inferred from source dates) · Electrical System:horn
THIS INVESTIGATION IS CLOSED.GM WILL CONDUCT A SAFETY IMPROVEMENT CAMPAIGN TO ADDRESS THE CONCERNS RAISED BY THE DETACHMENT OF THE HORN PAD FROM THE STEERING WHEEL IN THE SUBJECT VEHICLES.FOR A TECHNICAL ANALYSIS OF THE PROBLEM SEE EA94-033 ENGINEERING TECHNICAL REPORT.
PE94042 · Horn Button Falling Off
Opened May 23, 1994 · Closed Sep 29, 1994
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
1994 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration