IllustrationWHEN APPLYING THE BRAKES THERE CAN HEAR AIR HAS TO PRESS HARD ON THE BRAKES, TOOK TO MECHANIC WHO SAID THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED . *AK
1992 Chevrolet Cavalier
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1992 Chevrolet Cavalier do not stand out strongly from the model-year median of 140.
About this comparison →How this year compares
Owner complaints by model year
Compare all Cavalier years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 134 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 48 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports8 fire reports9 injury reports
What owners actually said
134 reportsFRONT HYDRAULIC HOSE BROKE CAUSE VEHICLE TO HAVE NOT BRAKING (ABS) ABILITY.
SEAT BELT BROKE DURING REAR END COLLISION RESULTING IN NECK AND BACK INJURY.
TIE ROD FAILED RESULTING IN LOSS OF CONTROL.
AFTER PUTTING VEHICLE INTO REVERSE, THE ACCELERATOR STUCK, CAUSING THE VEHICLE TO SUDDENLY ACCELERATE OUT OF CONTROL, RESULTING IN AN ACCIDENT. *AK
ABS LIGHT COME ON, NOW IT WORKS FINE, BUT THE PEDAL FADES TO THE FLOOR.
CYLINDER HEAD CRACKED.
SET CRUISE CONTROL AT 65 MPH, WILL HOLD SET SPEED AT 10 TO 20 MINUTES, THEN WILL SUDDENLY ACCELERATE VERY RAPIDLY, WITHIN 20 SECONDS, GOES FROM 65 TO 85 MPH, TURNING OFF CRUISE CONTROL DOES NOT CONTROL SPEED, ONLY DISENGAGES BY BRAKING.*AK
ABS, BRAKES INTERMITTENTLY FAILED, REPLACEMENT OF THE DISC PADS AND ROTORS WHEN BRAKES ARE APPLIED, EXPERIENCED EXTENDED STOPPING DISTANCE. *AK
SLAVE CYLINDER OF CLUTCH ASSEMBLY IS MADE OF PLASTIC FAILED WITH CLUTCH ENGAGED, RESULTING IN VEHICLE CONTINUOUSLY GOING, ALMOST HITTING A CHILD IN PARKING LOT. OWNER HAD NO WARNING THAT PLASTIC CYLINDER WAS GOING TO FAIL. PLEASE DESCRIBE DETAILS.*AK
Official recalls
191V166000 · Latches/locks/linkages:hood:latch
Sep 23, 1991
THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.
Consequence & remedy
Consequence: IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.
Remedy: INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.