Electrical SystemEngine And Engine CoolingLatches/locks/linkages
I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HA…
Read full complaint
I OWN A 1992 CHEV CAVALIER Z-24 AND HAVE BEEN READING HORROR STORIES ABOOT THE EXACT WOES I HAVE BEEN SUFFERING SINCE BUYING IT USED IN 1998 WITH ONLY 15K MI ON IT; IT ONLY HAS 30000 ON IT NOW. THE FIRST TO GO WAS THE HEATER CORE AND BELT TENSIONER AND THEN THE COOLANT LEAKS THAT HAS REQUIRED SEVERAL DAYS OF SHOP TIME. I HAVE HAD THE INTAKE REMOVED TWICE, THE HEADS ONCE - THEY ACCUSED ME OF OVERHEATING AND WARPING THEM - THE WATER PUMP REPLACED, 2 WINDOW MOTORS INSTALLED AND THE ALTENATOR REPLACED. I HAVEN'T EVEN GOTTEN TO THE BRAKES - THE ABS SYSTEM ON THIS BUCKET OF JUNK SEEM TO WORK FINE MOST OF THE TIME BUT LOVE TO CHATTER INTERNAL TO THE ELECTRONIC/HYDRAULIC SYSTEM AS IF IT CAN'T MAKE UP ITS MIND. I HAVE DISABLED THE SYSTEM IN DIAGNOSING IT MYSELF AND FOUND THAT THE BRAKES WORK BETTER WITHOUT THE SYSTEM CONTROLLING YOUR BRAKING. THE SYSTEM IS INTACT AS I DON'T WANT TO FOOL AROUND TOO MUCH BUT THIS SHOULD HAVE BEEN A SWITCH ON THE DASH - ABS ON - ABS OFF. I AM IN POOR HEALTH AND HAVEN'T BEEN ABLE TO TAKE THE JALOPY TO OURISMAN CHEVROLET AGAIN - I BOUGHT IT AT OURISMAN'S ROCKVILLE STORE - TO SHOW THEM THE COOLANT IN THE OIL THAT I FOUND RECENTLY. I HAVE USED SYNTHETIC OIL IN IT SINCE I BOUGHT IT BUT I CAN'T VOUCH FOR THE SERVICE DEPT AT OURISMAN. THEY PROBABLY USE GOODWRENCH 5-30 AS IT CAME FROM THE FACTORY. IF THERE ARE THIS MANY REPORTS OF THIS PIECE OF JUNK, WOULDN'T CHEVY BE MORE CONCERNED ABOOT IT? I AM LUCKY TO HAVE GOTTEN A 4 YEAR EXTENDED WARRANTY AS I WOULD NEVER HAVE BEEN ABLE TO AFFORD IT; I WOULD HAVE JUST LEFT THE CAR WITH OURISMAN AND LET THEM DEAL WITH IT. AK
NHTSA ODI #10075338
Mileage unknown · Dec 8, 2001
Electrical SystemFire
VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STR…
Read full complaint
VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STRONG ORDOR OF BURNT PLASTIC AND ELECTRICAL FIRE SMELL.*AK
NHTSA ODI #755433
Mileage unknown · Dec 8, 2001
Electrical SystemFire
VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STR…
Read full complaint
VEHICLE WAS SITTING IN ATTACHED GARAGE FOR THREE HOURS WHEN NOISE WAS HEARD IN GARAGE. WHEN LOOKED IN GARAGE WAS FILLED WITH SMOKE AND FIRE WAS COMING OUT OF BOTH SIDES OF WINDSHIELD ON PASSENGER SIDE. PUT OUT FIRE WITH FIRE EXTINGUISHER AND PUSHED OUT OF GARAGE. LARGE HOLE IN DASH ON PASSENGER SIDE WHERE FIRE CAME OUT, STRONG ORDOR OF BURNT PLASTIC AND ELECTRICAL FIRE SMELL.*AK
NHTSA ODI #755432
Mileage unknown · Apr 22, 2001
Electrical SystemFire
THIS IS A PROBLEM IN THE FUEL MANAGEMENT SYSTEM,CAUSING THE ENGINE TO SURGE THEN MISS.I HAD THE CAR IN THE SHOP 6 WEEKS EARLIER,IT RAN FINE TILL TODAY,THIS TIME IT RESULTED IN A FIRE .THE CAR IS A TOTAL LOSS.*AK
NHTSA ODI #744362
Mileage unknown · Sep 12, 2000
Electrical System
THE FUSE MARKED "ACC" HAS BEEN CHANGED OUT 3 TIMES AND IT KEEPS BLOWING. ABOUT THE SAME TIME THE A/C QUIT WORKING AS WELL AS THE POWER LOCKS. (SAME SIZE FUSE USED EACH TIME) WHEN I GO TO PUT THE FUSE IN IT SPARKS, I ALSO AM ABLE TO HEAR THE CHIME FOR THE KEY (IF IN THE IGNITION), *AK
NHTSA ODI #731154
Mileage unknown · Aug 25, 1999
Electrical SystemEngine And Engine CoolingSeats
WINDSHIELD GETS FOGGY RESIDUE MAKES POOR VISION; SEAT LATCHES DON'T LATCH FIRST ADJUSTMENT; THEY LATCH WHILE DRIVING;
NHTSA ODI #710487
Mileage unknown · Aug 25, 1999
Electrical SystemEngine And Engine CoolingParking Brake
RADIATOR HOSE LEAK MADE CAR RUN HOT; REPLACED CATYLIC CONVERTER SO WOULD NOT RUN HOT; FUSE SHORTAGE ALMOST CAUGHT CAR ON FIRE; THE BODY SOUNDS SQUEEKY AND RUSTY WHEN GOES OVER BUMPS
NHTSA ODI #710485
Mileage unknown · Jan 15, 1999
Electrical System
NO SUMMARY
NHTSA ODI #702253
Mileage unknown · Mar 10, 1998
Electrical SystemFire
VEHICLE CAUGHT FIRE AND FIRE MELTED NUMEROUS PARTS, INCLUDING DASH, ETC. CAUSE OF FIRE UNKNOWN. *AK
NHTSA ODI #821495
Mileage unknown · May 30, 1997
Electrical SystemFire
ELECTRICAL: DRIVING APPROXIMATELY 55MPH AND VEHICLE STARTED TO MAKE A BEEPING SOUND AND THEN IT STOPPED. ENTERING NEXT TOWN AND IT STARTED MAKING THE SOUND AGAIN, PULLED VEHICLE OVER AND PUT VEHICLE IN NEUTRAL TOOK KEYS OUT, VEHICLE MADE AN EVEN LOUDER NOISE, SMOKE CAME FROM DASH, GOT OUT ,FIRE ENGINE HAPPENED TO BE PASSING BY,…
Read full complaint
ELECTRICAL: DRIVING APPROXIMATELY 55MPH AND VEHICLE STARTED TO MAKE A BEEPING SOUND AND THEN IT STOPPED. ENTERING NEXT TOWN AND IT STARTED MAKING THE SOUND AGAIN, PULLED VEHICLE OVER AND PUT VEHICLE IN NEUTRAL TOOK KEYS OUT, VEHICLE MADE AN EVEN LOUDER NOISE, SMOKE CAME FROM DASH, GOT OUT ,FIRE ENGINE HAPPENED TO BE PASSING BY, CAME AT TIME VEHICLE SEEMED LIKE IT WAS TRYING TO START ON IT'S OWN. ALSO, WINDSHIELD WIPERS WERE GOING/HORN BEEPING AND LIGHTS FLASHING ON AND OFF. VEHICLE WAS COVERED WITH SMOKE. FIREMAN SAID IT WAS ELECTRICAL. *AK
THE SECONDARY HOOD LATCH SPRING IS IMPROPERLY INSTALLED OR MISSING, LEADING TO A CONDITION WHERE THE SECONDARY HOOD LATCH DOES NOT ENGAGE THE SECONDARY STRIKER.
Consequence & remedy
Consequence: IF THE SECONDARY HOOD LATCH IS NOT ENGAGED, AND THEPRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IFTHIS OCCURS WHILE THE VEHICLE IS IN MOTION, THE HOOD MAY CONTACT THE WINDSHIELD,REDUCING THE FORWARD VISION AREA OF THE DRIVER AND A VEHICLE CRASH COULD OCCUR.
Remedy: INSPECT HOOD LATCH ASSEMBLIES AND, WHERE NECESSARY, INSTALL A NEW SECONDARY HOOD LATCH SPRING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1992 Chevrolet Cavalier Problems, Complaints & Recalls | Skip That Year
Illustration