Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 88 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports0 fire reports4 injury reports
What owners actually said
88 reports
Mileage unknown · Jul 18, 2002
Fuel System, Gasoline
FUEL LEAK AT TANK FIRST OCCURRED APRIL 22 THIS YEAR. FUEL LEVEL SENDER SEAL REPLACED. MAY !7 FUEL LEVEL SENDER DEFECTIVE, FUEL LEAK. REPLACED FUEL TANK, SENDING UNIT SEAL, FUEL PUMP. TODAY-JULY 18, MASSIVE FUEL LEAK AT TANK WITH GASOLINE PUDDLING UNDER CAR WHILE ENGINE IDLING. 20 MINUTES OF IDLING CAUSED OVER 1 GALLON OF FUEL…
Read full complaint
FUEL LEAK AT TANK FIRST OCCURRED APRIL 22 THIS YEAR. FUEL LEVEL SENDER SEAL REPLACED. MAY !7 FUEL LEVEL SENDER DEFECTIVE, FUEL LEAK. REPLACED FUEL TANK, SENDING UNIT SEAL, FUEL PUMP. TODAY-JULY 18, MASSIVE FUEL LEAK AT TANK WITH GASOLINE PUDDLING UNDER CAR WHILE ENGINE IDLING. 20 MINUTES OF IDLING CAUSED OVER 1 GALLON OF FUEL TO BE EXPELLED FROM TANK. INSPECTION SHOWS POSSIBLE DEFECT IN FUEL VAPOR RECOVERY SYSTEM CAUSING EXCESS FUEL TANK PRESSURE, SUFFICIENT TO CAUSE FUEL TANK SEAL FAILURE WHERE SENDING UNIT MOUNTS TO TANK. THIS IS A VERY SERIOUS PROBLEM. A DISCARDED CIGARETTE COULD CAUSE FUEL VAPORS TO IGNITE. THIS LEAK WILL CONTINUE TO OCCUR UNTIL SOURCE OF EXCESSIVE FUEL TANK PRESSURE CAN BE DETERMINED. IT MAY BE THE RESULT OF FAILURE TO MAINTAIN FUEL VAPOR RECOVERY SYSTEM OR A COMPONENT FAILURE. IF SO, WHY SHOULD A FAILURE RESULT IN MASSIVE FUEL LEAKAGE? THIS IS A PROBLEM WITH LIFE THREATENING POTENTIAL AND SHOULD RECEIVE YOUR HIGHEST PRIORITY IN FOLLOW UP.*AK
NHTSA ODI #764435
Mileage unknown · May 28, 2002
Air BagsElectrical SystemEngine And Engine Cooling
AIRBAG LIGHT STAYS ON WHILE DRIVING.*AK THE AIR BAG LIGHT IS CONSTANTLY ON. THE VEHICLE WAS SERVICED IN 1997, 1999 AND 2000. EACH TIME THE LIGHT ILLUMINATED AGAIN. THE AIR BAG WILL NOT DEPLOY IF THE LIGHT IS ILLUMINATED. THE HORN IS INOPERABLE. THE WIRING TO THE SIR SYSTEM WAS REPAIRED. THE ENGINE COOLING SYSTEM NEEDED SER…
Read full complaint
AIRBAG LIGHT STAYS ON WHILE DRIVING.*AK THE AIR BAG LIGHT IS CONSTANTLY ON. THE VEHICLE WAS SERVICED IN 1997, 1999 AND 2000. EACH TIME THE LIGHT ILLUMINATED AGAIN. THE AIR BAG WILL NOT DEPLOY IF THE LIGHT IS ILLUMINATED. THE HORN IS INOPERABLE. THE WIRING TO THE SIR SYSTEM WAS REPAIRED. THE ENGINE COOLING SYSTEM NEEDED SERVICING. ALSO THE BACK UP LIGHTS WERE OUT, DEALER HAD TO MAKE AN ADJUSTMENT TO THE NEUTRAL SAFETY SWITCH IN THE TRANSMISSION. JLG
NHTSA ODI #8010592
Mileage unknown · Apr 12, 2002
Electrical System
VEHICLE HAS PROBLEM WITH RESTARTING, DEALER NOTIFIED, AND INFORMED CONSUMER THAT IT WAS PASS KEY FAULT, NEEDED TO BE REPLACED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8007522
Mileage unknown · Mar 25, 2002
Fuel System, Gasoline
CONNECTOR IN FUEL TANK IS DETERIORATING, FUEL PUMP CONNECTOR FAILED, THE INSULATION ON THE WIRE MELTED, ARCING AT THE CONNECTOR LEAVING A CARBON TRAIL. *JG *AK
NHTSA ODI #8006317
Mileage unknown · Mar 11, 2002
Seats
BRACKET ON RIGHT SIDE OF SEAT BROKE WHILE DRIVING. DEALER REPAIRED IT, BUT PARTS WERE NOT AVAILABLE FOR CRACKED BRACKET ON LEFT SIDE. DEALER HAS ORDERED PART. DRIVER CLAIMED IT HAS BEEN 4 MONTHS AND PART WAS STILL NOT AVAILABLE.*AK
NHTSA ODI #8005323
Mileage unknown · Apr 23, 2001
Electrical System
ON NUMEROUS OCCASIONS CONSUMER WOULD EXPERIENCE TOTAL ENGINE FAILURE IN WHICH HEADLIGHTS, RADIO, HORN, AND THE UNDER HOOD CONVENIENCE LIGHT WOULD NOT WORK, AND AFTER ABOUT 45 MINUTES VEHICLE WOULD START UP AS IF THERE WAS NEVER ANYTHING WRONG, CONSUMER TOOK VEHICLE IN TO BE INSPECTED AND IT WAS DETERMINED THAT THE FUSE BLOCK THA…
Read full complaint
ON NUMEROUS OCCASIONS CONSUMER WOULD EXPERIENCE TOTAL ENGINE FAILURE IN WHICH HEADLIGHTS, RADIO, HORN, AND THE UNDER HOOD CONVENIENCE LIGHT WOULD NOT WORK, AND AFTER ABOUT 45 MINUTES VEHICLE WOULD START UP AS IF THERE WAS NEVER ANYTHING WRONG, CONSUMER TOOK VEHICLE IN TO BE INSPECTED AND IT WAS DETERMINED THAT THE FUSE BLOCK THAT RELAYS PLUG INTO HAS MELTED DOWN AND THE MAIN LUG, BUSS BARS AND HOUSING NEEDED TO BE REPLACED. CONSUMER WAS ADVISED BY DEALERSHIP THAT THERE IS SERIOUS DESIGN PROBLEM WITH THIS VEHICLES MOSTLY USED IN POLICE AND TAXI APPLICATION AND IN SOME CASES VEHICLES HAVE CAUGHT FIRE. *JB
NHTSA ODI #560906
Mileage unknown · Apr 20, 2001
Fuel System, Gasoline
FUEL PUMP FAILURE CAUSED STALL AT HIGHWAY SPEED, ALTHOUGH THE FUSE WAS BLOWN, WIRING HARNESS MELTED AT THE FUEL PUMP AND TANK SENDING UNIT SUGGESTING LETHAL CONCERNS FOR SAFETY. *AK
NHTSA ODI #744306
Mileage unknown · Apr 17, 2001
Suspension
IN A SHOPPING CENTER MAKING A RIGHT 90 DEGREE TURN AT ESTIMATED SPEED OF 15MPH WHEN LEFT FRONT OF CAR COLLAPSED DROPPING THE LEFT FRONT FENDER DOWN ON THE LEFT FRONT WHEEL. MECHANIC REPAIRING THE CAR STATED THAT THE LEFT LOWER BALL JOINT BROKE OFF. THIS REQUIRED REPLACEMENT OF THE LET LOWER BALL JOINT (PART #K6145) AND THE LEF…
Read full complaint
IN A SHOPPING CENTER MAKING A RIGHT 90 DEGREE TURN AT ESTIMATED SPEED OF 15MPH WHEN LEFT FRONT OF CAR COLLAPSED DROPPING THE LEFT FRONT FENDER DOWN ON THE LEFT FRONT WHEEL. MECHANIC REPAIRING THE CAR STATED THAT THE LEFT LOWER BALL JOINT BROKE OFF. THIS REQUIRED REPLACEMENT OF THE LET LOWER BALL JOINT (PART #K6145) AND THE LEFT OUTER TIEROD (PART# ES2019RL. THERE WAS NO POTHOLE OR OTHER ROUGH PLACE IN THE ROADWAY AND THE AUTOMOBILE HAD NO PREVIOUS HISTORY OF ACCIDENT. MY CONCERN FOR ENTERING THIS REPORT IS THAT I HAD NEVER HEARD OF THIS TYPE OF FAILURE BEFORE THOUGH THE MECHANIC SAYS IT OCCASIONALLY OCCURS. IN MY MIND THIS PRESENTS A VERY REAL SAFETY HAZARD. HAD THIS AUTOMBILE BEEN TRAVELING AT 60MPH ON AND OPEN ROAD AND THIS HAD OCCURED THERE IS NO DOUBT IN MY MIND THAT THIS WOULD HAVE RESULTED IN SUDDENLY FLIPPING AND ROLLING OF THE CAR WITH THE VERY REAL PROBABILITY OF LOSS OF LIFE.
NHTSA ODI #744195
Mileage unknown · Mar 16, 2001
Fuel System, Gasoline
WIRING HARNESS TO FUEL PUMP (INSIDE FUEL TANK)SOMEHOW SHORTED OUT CAUSING WIRING TO GET HOT ENOUGH TO MELT THE WIRE INSULATION AND PLASTIC CONNECTORS,WHICH ATTACH TO THE FUEL PUMP.*AK
NHTSA ODI #742554
Mileage unknown · Aug 28, 2000
Tires
PE200020; ORIGINAL EQUIPMENT ON A 1995 CHEVROLET CAPRISE. CONSUMER TOOK VEHICLE TO SHOP FOR VIBRATION OF A LEFT FRONT TIRE. MECHANIC SAID TIRES WERE BAD AND NEEDED TO BE REPLACED. TIRES COULD BLOWOUT AT ANYTIME. HAD 58866 MILES ON THEM. *AK THE TIRE DEALER OFFERED THE CUSTOMER NEW TIRE AT LOWER PRICE. *YH
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: THE LOWER CONTROL ARM BALL JOINT CAN LOOSEN, FATIGUE, AND SEPARATE FROM THE FRONT SUSPENSION KNUCKLE RESULTING IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.
Consequence & remedy
Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.
THESE VEHICLES WERE PRODUCED WITH AN IMPROPERLY ADJUSTED TRANSMISSION SHIFT CONTROL LINKAGE. THIS DOES NOT MEET WITH THE REQUIREMENTS OF FMVSS NO. 114, "THEFT PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IT MAY BE POSSIBLE TO SHIFT FROM THE "PARK" POSITION WITH THE IGNITION KEY REMOVED INCREASING THE RISK OF A VEHICLE ACCIDENT RESULTING FROM THE UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Remedy: DEALERS WILL ADJUST THE SHIFT CONTROL LINKAGE SYSTEM.
THESE VEHICLES WERE SHIPPED WITH BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT CAUTION LABEL AND A ROOF RACK CAUTION LABEL INSTALLED ON THE SAME SIDE OF THE SUN VISOR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO.208, "OCCUPANT CRASH PROTECTION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.
Remedy: A NEW ROOF RACK CAUTION LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.
THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA99003 · Coolant Fires
Opened Jan 13, 1999 · Closed Aug 17, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98049 · Coolant Fires
Opened Sep 4, 1998 · Closed Jan 13, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
EA96022 · Steering Wheel Breakage
Opened Sep 24, 1996 · Closed Apr 4, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA96007 · Rear Wheel Separation
Opened May 31, 1996 · Closed Dec 24, 1996
Status: closed (inferred from source dates) · Suspension
GM NOTIFIED ODI THAT THEY ARE CONDUCTING A RECALL TO RETORQUE THE WHEEL LUG NUTS ON VEHICLES BUILT BETWEEN AUGUST AND SEPTEMBER OF 1995.IT IS ANTICIPATED THAT MOST VEHICLES WILL REQUIRE THE WHEEL LUG NUTS TO BE RETORQUED TO 135 N.M(100 LB. FT.).CUSTOMERS WHO HAVE HAD ALL FOUR OF THEIR TIRES AND WHEELS ROTATED SHOULD HAVE PROPERLY TORQUED LUG NUTS.HOWEVER, GM IS OFFERING CUSTOMERS WHO HAVE HAD THEIR TIRES AND WHEELS ROTATED THE OPTION OF RETURNING TO THEIR DEALER FOR THIS REPAIR OR COMPLETING AND RETURNING AN OWNER REPLY CARD INCLUDED WITH THEIR RECALL NOTICE.THIS ENGINEERING ANALYSIS IS CLOSED.
PE96037 · Sterring Wheel Breakage
Opened May 16, 1996 · Closed Sep 24, 1996
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1995 Chevrolet Caprice Problems, Complaints & Recalls | Skip That Year
Illustration