Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 89 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports1 fire reports12 injury reports
What owners actually said
89 reports
Mileage unknown · Apr 17, 1998
Service Brakes, Hydraulic
RECALL WORK WAS COMPLETED. WENT TO PICK UP VEHICLE AND THE BRAKE LIGHTS WERE ON. TOOK VEHICLE TO ANOTHER DEALER AND THEY SAID THAT THE MODULATOR VALVE NEEDED TO BE REPLACED, AND THERE WOULD BE A CHARGE OF $1200 FOR THIS SERVICE. ANYWAY THE OWNER THINKS THAT THIS SHOULD HAD BEEN PART OF THE RECALL. CONSUMER BELIEVES THAT THIS W…
Read full complaint
RECALL WORK WAS COMPLETED. WENT TO PICK UP VEHICLE AND THE BRAKE LIGHTS WERE ON. TOOK VEHICLE TO ANOTHER DEALER AND THEY SAID THAT THE MODULATOR VALVE NEEDED TO BE REPLACED, AND THERE WOULD BE A CHARGE OF $1200 FOR THIS SERVICE. ANYWAY THE OWNER THINKS THAT THIS SHOULD HAD BEEN PART OF THE RECALL. CONSUMER BELIEVES THAT THIS WAS THE POOREST RECALL JOB DONE. THE ABS MODULATOR WAS REPLACED, WHY COULDN'T THEY JUST AS WELL REPLACED THE MODULATOR VALVE? HOW DIFFERENT ARE THE TWO PARTS . *AK
NHTSA ODI #822519
Mileage unknown · Apr 15, 1998
Service Brakes, HydraulicTires
THE ABS RELAY AND BRAKE PRESSURE MODULATOR VALVE FAILED PRIOR TO RECALL NOTICE, AFTER REPAIR FAILED AGAIN AND WAS NOT REPAIRED AS PART OF RECALL.
NHTSA ODI #534260
Mileage unknown · Mar 31, 1998
Service Brakes, Hydraulic
BRAKE ROTORS, PADS AND DRUMS FAILED.
NHTSA ODI #533487
Mileage unknown · Mar 4, 1998
Suspension
UNABLE TO HAVE RECALL REPAIR DONE BECAUSE OF DEALER PROBLEMS AND PARTS NOT AVAILABLE.
NHTSA ODI #531778
Mileage unknown · Nov 10, 1997
SteeringSuspension
BACKING OUT; STEERING WOULD NOT TURN LEFT/RIGHT. WENT UP ON CURB. ACCELERATED TO GET OFF. CALLED DEALER & SOMEONE PICKED VEHICLE UP. BALL JOINTS DISCONNECTED. BOLTS/NUTS MISSING THAT ARE ATTACHED TO BALL JOINTS. *AK
NHTSA ODI #819769
Mileage unknown · Nov 10, 1997
Electrical System
HEADLIGHTS WILL SUDDENLY COME ON IN DAYLIGHT AND INSTRUMENT PANEL LIGHTS WILL SUDDENLY GO OFF DUE TO FAILURE OF THE INSTRUMENT CLUSTER.
NHTSA ODI #524576
Mileage unknown · Oct 30, 1997
Service Brakes, HydraulicCrash
DRIVER APPLIED BRAKES, PEDAL WENT TO FLOOR, CAUSED REAREND COLLISION. PRIOR TO CRASH/WHEN COMING TO STOP, INSTEAD OF STOPPING, PICKED UP SPEED, DEALER FOUND NO PROBLEMS. *AK
NHTSA ODI #818041
Mileage unknown · Sep 30, 1997
Service Brakes, Hydraulic
FRONT BRAKE ROTORS FAILED.
NHTSA ODI #522716
Mileage unknown · Sep 3, 1997
Electrical System
DIFFICULTY ACCESSING HORN BUTTONS IN EMERGENCY SITUATIONS.
NHTSA ODI #521686
Mileage unknown · Aug 4, 1997
Steering
VEHICLE'S UPPER IDLER ARM BOLTS BROKE, CAUSING THE RIGHT FRONT END OF THE VEHICLE TO COLLAPSE. CONTACTED THE DEALER. *AK
THE REAR LOWER CONTROL ARM CAN CRACK AT THE REAR STABILIZER BAR ATTACHMENT.
Consequence & remedy
Consequence: THIS CONDITION CAN BE AGGRAVATED BY THE SEVERE DUTY CYCLE OF THESE VEHICLES AND EVENTUALLY CAUSE THE LOWER CONTROL ARM TO FRACTURE COMPLETELY CAUSING A LOSS OF VEHICLE CONTROL WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE BOTH REAR LOWER CONTROL ARMS AND REAR STABILIZER BAR ATTACHMENTS.
SYSTEM: ELECTRICAL.VEHICLE DESCRIPTION: SEQ 9C1 POLICE CARS IN CORROSION AREAS OF THE US AND CANADA ONLY. NOTE: VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEWJERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. A ELECTRICAL GROUND-OUT CONDITION MAY EXIST BETWEEN THE 12 VOLT JUNCTION BLOCK AND THE METAL INNER FENDER SKIRT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A MELTED JUNCTION BLOCK, SMOKE,AND BURNED UNDERHOOD WIRING RESULTING IN A DISABLED VEHICLE OR A VEHICLE FIRE.THIS CONDITION CAN OCCUR WHILE THE VEHICLE IS IN OPERATION OR WHILE THE VEHICLEIS PARKED AND THE IGNITION IS IN THE "OFF" POSITION.
Remedy: INSTALL A SHIELDING INSULATOR UNDER THE JUNCTION BLOCK.
THE ENGINE MOUNTED FUEL FEED AND RETURN PIPES MAY FRACTURE DUE TO CONTACT WITH THE ENGINE FRAME DURING OPERATION.
Consequence & remedy
Consequence: IF THE FUEL PIPE FRACTURES, GASOLINE WILL BE FORCED ATPRESSURE FROM THE FUEL PIPES INTO THE ENGINE COMPARTMENT, RESULTING IN ANUNDERHOOD FIRE IF THE GASOLINE IS EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE FUEL FEED AND RETURN PIPES USING NEW PIPE ASSEMBLIES.
THE STEEL WHEELS EXHIBIT FATIGUE CRACKING AROUND THE CIRCUMFERENCE OF THE WHEEL LUG NUT MOUNTING SURFACE DUE TO WHEEL BENDING CAUSED BY FREQUENT MISUSE OF TIRE MOUNTING EQUIPMENT, LUG NUT OVERTORQUING, AND THE UNUSUAL OPERATING CONDITIONS EXPERIENCED BY POLICE VEHICLES.
Consequence & remedy
Consequence: THE CRACKING CAN CAUSE WHEEL FRACTURING AND SUBSEQUENTSEPARATION FROM THE AXLE, WHICH COULD RESULT IN A VEHICLE ACCIDENT.
Remedy: REPLACE THE DEFECTIVE WHEELS WITH REDESIGNED STEEL WHEELS.
SECONDARY HOOD LATCH ASSEMBLIES CAN CORRODE, CAUSING A HIGH LATCH RELEASE EFFORT AND POSSIBLY PREVENTING THE HOOD FROM LATCHING PROPERLY WHEN IT IS CLOSED.
Consequence & remedy
Consequence: IF THE SECONDARY HOOD LATCH IS NOT PROPERLY ENGAGED, ANDTHE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN AND CONTACT THEWINDSHIELD WHILE THE VEHICLE WAS IN MOTION, REDUCING THE FORWARD VISION AREA OFTHE DRIVER AND RESULTING IN A POSSIBLE VEHICLE ACCIDENT WITHOUT PRIOR WARNING.
Remedy: INSTALL A NEW SECONDARY HOOD LATCH ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE93098 · Lwr Ball Joint Assem.fails
Opened Nov 30, 1993 · Closed Mar 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE92079 · R Seat Belt Webbing Length
Opened Sep 9, 1992 · Closed Jan 19, 1993
Status: closed (inferred from source dates) · Seat Belts:rear/other
There is no summary currently available
1992 Chevrolet Caprice Problems, Complaints & Recalls | Skip That Year
Illustration