IllustrationSteering not returning to center, when making a turn across the street you have to quickly center the vehicle to prevent going into on coming traffic. Very stiff to turn and make popping sounds when turning.
2017 Chevrolet Bolt Ev
Owner reports · Recalls · Investigations
More warning signs than most Bolt Ev years
Owner complaints for the 2017 Chevrolet Bolt Ev are substantially higher than the model-year median of 77.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bolt Ev years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 81 of 346 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports5 fire reports5 injury reports
Wheels complaints
5 reportsCreaking/popping noise from passenger rear side of vehicle at 24,574 miles along with a grinding noise coming from the front driver side wheel. Took to dealership twice and was told there is not a rear axle just independent struts and shocks. Very concerning and not sure if a wheel is gonna fall off. I've seen other forums that …
Read full complaint
Creaking/popping noise from passenger rear side of vehicle at 24,574 miles along with a grinding noise coming from the front driver side wheel. Took to dealership twice and was told there is not a rear axle just independent struts and shocks. Very concerning and not sure if a wheel is gonna fall off. I've seen other forums that have been having the same issue between the years 2017-2019. Please recall and fix because consumers shouldn't shell out more money for cheap parts.
WHILE DRIVING THE SPEED LIMIT OF 45 MILES PER HOUR, THE CAR JOLTED AND LIGHTS IN THE CAR WENT ON. TRANSMISSION LIGHT, BRAKE LIGHT, STABILITY TRACK LIGHT, SERVICE PARK ASSIST LIGHT, SERVICE STEERING LIGHT, ETC. THIS CAUSED ME A CHALLENGE IN DRIVING THE CAR ON A TWO LANE ROAD BECAUSE THE STEERING BECAME MORE DIFFICULT AND THERE …
Read full complaint
WHILE DRIVING THE SPEED LIMIT OF 45 MILES PER HOUR, THE CAR JOLTED AND LIGHTS IN THE CAR WENT ON. TRANSMISSION LIGHT, BRAKE LIGHT, STABILITY TRACK LIGHT, SERVICE PARK ASSIST LIGHT, SERVICE STEERING LIGHT, ETC. THIS CAUSED ME A CHALLENGE IN DRIVING THE CAR ON A TWO LANE ROAD BECAUSE THE STEERING BECAME MORE DIFFICULT AND THERE WAS NOT A BIG ENOUGH SHOULDER TO PULL ONTO THE SIDE OF THE ROAD. BRING CAR INTO DEALER AND FIND THAT THE FRONT WHEEL BEARING AND HUB NEED TO BE REPLACED, THE FIRST TIME THIS OCCURRED WAS WHEN THE BRAND NEW CAR WAS ABOUT A YEAR OLD (WE DID HAVE 18311 MILES ON THE VEHICLE). ABOUT A YEAR LATER (15 MONTHS LATER), THE SAME INCIDENT OCCURRED AND THE SAME PARTS NEEDED TO BE REPLACED AGAIN. HOWEVER, WE WERE OUTSIDE OF THE WARRANTY DUE TO MILEAGE AND THEY NO LONGER WANTED TO REPLACE THE BROKEN PARTS UNDER WARRANTY. THE SAME PARTS SHOULD NOT GO OUT YEAR AFTER YEAR ON A BRAND NEW CAR! WE ASKED IF THERE WAS A RECALL ON PARTS AND WERE TOLD NO. THE PART NUMBERS ON BOTH INVOICES - SL-N-WASHER (04710-C); SL-N- NUT (06056-BC); SL-N-WASHER (06056-C); SL-*-N- BEARING (060311-C)
TIRE RATED WHEN WE PURCHASED CAR TIRE WEAR WAS 60 ,000 MILES TUBE LESS TIRE WE HAVE LESS THAN 30,000 MILE ON CAR WHEN TOOK TO CHEV TO HAVE SERVICE AND WAS TOLD I WOULD NEED NEW TIRES SOON 3 OF THE TIES WERE AT3/32 & 4 TIRE WAS4/32 SO I DROVE HOME AND PARKED IT SINCE I CANT AFFORD NEW TIES YET AND THE RESPONSIBLE OF US DRIVE WI…
Read full complaint
TIRE RATED WHEN WE PURCHASED CAR TIRE WEAR WAS 60 ,000 MILES TUBE LESS TIRE WE HAVE LESS THAN 30,000 MILE ON CAR WHEN TOOK TO CHEV TO HAVE SERVICE AND WAS TOLD I WOULD NEED NEW TIRES SOON 3 OF THE TIES WERE AT3/32 & 4 TIRE WAS4/32 SO I DROVE HOME AND PARKED IT SINCE I CANT AFFORD NEW TIES YET AND THE RESPONSIBLE OF US DRIVE WITH 3 TIRE TREAD WEAR COULD HAVE 3 BLOW OUTSIDE AT ONE TI.E RISK OF ROLL OVER OR HIT OTHER CAR AND INJURED OTHERS IS NOT THE PEOPLE WERE ARE BUT I DIDNT PAY $45,685 ON A NEW GREEN VEHICLE TO HAVE REPLACE 4 [XXX] TIRES LESS THAN 2 YERS OLD THE CAR IS IVE HAVEN'T EVER HAD A CAR BIKE RV TIRES WEAR OUT SO FAST CHEAPEST DEFECTIVE TIRES I'VE EVER SEEN SO EVERYBODY PASS IT BACK TO US TO PAY FOR [XXX] I PAY 700 A MONTH FOR THAT CAR MY HUSBAND WANT TO COMMUTE IN TO SAVE FUEL AND I TOLD EVEN WITH US BUY EXTRA WARRANTIES ON IT [XXX] I COULD HA E SAVED MY SELF A LOT OF MONEY WE HAVE SO MANY PROBLEMS WITH IT. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
WHILE IN MOTION THE CAR BEGAN TO ERRATICALLY SPEED UP & SLOW DOWN WITHOUT THE DRIVER DEPRESSING EITHER THE ACCELERATION PEDAL OR THE BRAKE. THE RESULT WAS THE JUMPING & BUCKING OF THE CAR & PASSENGERS WITHIN. UPON TAKING THE CAR TO CHEVY REPAIR, IT WAS DISCOVERED THAT THE WHEEL SPEED SENSOR WAS DAMAGED BECAUSE OF A FAULTY WASHER…
Read full complaint
WHILE IN MOTION THE CAR BEGAN TO ERRATICALLY SPEED UP & SLOW DOWN WITHOUT THE DRIVER DEPRESSING EITHER THE ACCELERATION PEDAL OR THE BRAKE. THE RESULT WAS THE JUMPING & BUCKING OF THE CAR & PASSENGERS WITHIN. UPON TAKING THE CAR TO CHEVY REPAIR, IT WAS DISCOVERED THAT THE WHEEL SPEED SENSOR WAS DAMAGED BECAUSE OF A FAULTY WASHER IN THE AXLE THAT BROKE. THE BROKEN WASHER PARTS ENTERED THE WHEEL HUB, DAMAGING BOTH THE WHEEL HUB & THE SPEED SENSOR.
Official recalls
423V845000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 14, 2023
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
22V930000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 15, 2022
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
21V560000 · Electrical System:propulsion System:traction Battery
Jul 23, 2021
General Motors LLC (GM) is recalling certain 2017-2019 Chevrolet Bolt EV vehicles previously recalled under NHTSA recall number 20V-701. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Interim notification letters notifying owners of the safety risk were mailed on August 13, 2021. Owner notification letters were mailed on August 13, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N212343880.
20V701000 · Electrical System:propulsion System:traction Battery
Nov 13, 2020
General Motors LLC (GM) is recalling all 2017-2018 and certain 2019 Chevrolet Bolt EV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: This recall has been superseded by recall number 21V-560. Vehicles previously repaired under 20V-701 will still need to have the new remedy under recall 21V-560. GM will notify owners, and as an interim repair, beginning on November 17, 2020, dealers will reprogram the hybrid propulsion control module 2 (HPCM2) to limit the full charge to 90%, free of charge. Owners are advised to activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, or park outside, until the software update is completed. Owners were notified of the interim repair beginning November 17, 2020. The second notice was mailed on May 11, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N202311730.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE20016 · Electric Vehicle Battery Fires
Opened Oct 9, 2020 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Electrical System:propulsion System; Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Additional source detail variants (6)
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800