IllustrationSeal leaking in rear causing puddle in floor of storage area where the sub woofer and radio amplifier is mounted. Water has shorted out amp and needs replaced
2017 Chevrolet Bolt Ev
Owner reports · Recalls · Investigations
More warning signs than most Bolt Ev years
Owner complaints for the 2017 Chevrolet Bolt Ev are substantially higher than the model-year median of 77.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Bolt Ev years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 81 of 346 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 114 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports5 fire reports5 injury reports
Electrical System complaints
114 reportsMy vehicle, an a whole host of others according to other owners online, have an issue with defective sealing in the rear bumper and underbody of the vehicle which allows water to enter, flooding the trunk which fries the electrical harness and audio system. As a result, all warning systems including the Forward Collision Warning…
Read full complaint
My vehicle, an a whole host of others according to other owners online, have an issue with defective sealing in the rear bumper and underbody of the vehicle which allows water to enter, flooding the trunk which fries the electrical harness and audio system. As a result, all warning systems including the Forward Collision Warning, Lane Departure Warning, Parking Collision Warning, Rear Cross Traffic Warning, turn signals, emergency lights, door ajar warning, and vehicle status warning systems are inaudible. This is not just a nuisance of not having an audio system but posses great danger to the driver, their passengers and others on the road as warning systems cannot be heard. In addition, the wiring harness affects other critical components on the car and considering this is an all electric vehicle, this is of great concern. Chevrolet is well aware of the issue but either instructs dealerships to not cover the issue under warranty or has not sufficiently informed their dealerships that this is a known manufacturing defect that should be covered.
The contact owns a 2017 Chevrolet Bolt EV. The contact received notifications of NHTSA Campaign Numbers: 21V560000 (Electrical System) and 22V930000 (Structure, Seat Belts) and would like to be removed from the recall distribution list as he no longer owns the vehicle. The local dealer and manufacturer were contacted.
The contact owns a 2017 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware o…
Read full complaint
The contact owns a 2017 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. The contact stated that they were on a waitlist with the dealership but then suddenly taken off. The contact has been suggested to pay the shipping cost to send the vehicle outside of Alaska for repairs. The contact stated that they are still waiting for the recall repairs to be made and they have not heard back from GMC.
2017 CHEVROLET BOLT. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALLS 20V-701 AND 21V-560.
This car worked reliably until the battery recall battery was exchanged then this started happening about a month later. First the vehicle died upon slowing down, driver was exiting a highway ramp stopped the car and turned off the car and turned on again and drove home without further trouble. Happened again, same thing this wa…
Read full complaint
This car worked reliably until the battery recall battery was exchanged then this started happening about a month later. First the vehicle died upon slowing down, driver was exiting a highway ramp stopped the car and turned off the car and turned on again and drove home without further trouble. Happened again, same thing this was at night. Then myself as driver, Took car to dealership, stayed in right lane on highway then car failed to accelerate but maintained about 40mph then died as slowing down on exit. After much time turning off and on again, the car finally allowed it to be put in drive and I made it to the dealership. After a week the dealership couldn’t find anything wrong with the car and said no charge but they can’t diagnose. Driving the car again, it drove fine until it didn’t. This time died and wouldn’t allow it to be put into drive again. Said conditions not right to shift. Towed it to a different dealership, the one that changed the recalled battery and they got 77 code errors and cannot figure out anything after a month. Still keeping to drive to recreate the problem. The biggest safety issue was that the emergency blink lights turned off when I turned off the car to try and restart it.
The contact owns a 2017 Chevrolet Bolt EV. The contact stated that the vehicle was designed with One Pedal Driving mode that allowed the brakes to apply independently when releasing the accelerator pedal; however, while driving at various speeds with One Pedal Driving mode engaged, the accelerator pedal was released but the vehi…
Read full complaint
The contact owns a 2017 Chevrolet Bolt EV. The contact stated that the vehicle was designed with One Pedal Driving mode that allowed the brakes to apply independently when releasing the accelerator pedal; however, while driving at various speeds with One Pedal Driving mode engaged, the accelerator pedal was released but the vehicle continued to move forward. The contact depressed the brake pedal and the vehicle responded. Additionally, the contact stated that the electronic parking brake failed to respond when engaged. The contact stated that the failure had been reoccurring intermittently. There was no warning light illuminated. The vehicle was taken to an unknown dealer where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 38,000.
The car Battery caught fire!
The contact owns a 2017 Chevrolet Bolt EV. The contact stated that the propulsion system warning light illuminated. While the contact was driving approximately 10 MPH, the vehicle stalled and stopped inadvertently. The contact was able to get the vehicle safely to her residence. The vehicle was towed to the dealer. The vehicle w…
Read full complaint
The contact owns a 2017 Chevrolet Bolt EV. The contact stated that the propulsion system warning light illuminated. While the contact was driving approximately 10 MPH, the vehicle stalled and stopped inadvertently. The contact was able to get the vehicle safely to her residence. The vehicle was towed to the dealer. The vehicle was diagnosed with transmission harness failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 51,000.
The contact owns a 2017 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware o…
Read full complaint
The contact owns a 2017 Chevrolet Bolt EV. The contact received notification of NHTSA Campaign Number: 21V560000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect. Chevrolet is still refusing to do anything. They stated consumer is not eligible for a buyback because a replacement battery is available. They also stated they don't know when it can be replaced or what the battery status is because no battery is available.
Official recalls
423V845000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 14, 2023
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.
22V930000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 15, 2022
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence & remedy
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Additional source detail variants (2)
Seat Belts:pretensioner
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
Structure:body:roof And Pillars
General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.
Consequence: A vehicle fire can increase the risk of injury.
Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.
21V560000 · Electrical System:propulsion System:traction Battery
Jul 23, 2021
General Motors LLC (GM) is recalling certain 2017-2019 Chevrolet Bolt EV vehicles previously recalled under NHTSA recall number 20V-701. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: Owners are advised to take the following interim steps: Activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, charge their vehicle more frequently, avoid depleting the battery to 70 miles range remaining, park outside after charging, and do not charge the vehicle indoors overnight. Defective battery modules will be replaced by GM, free of charge. Interim notification letters notifying owners of the safety risk were mailed on August 13, 2021. Owner notification letters were mailed on August 13, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N212343880.
20V701000 · Electrical System:propulsion System:traction Battery
Nov 13, 2020
General Motors LLC (GM) is recalling all 2017-2018 and certain 2019 Chevrolet Bolt EV vehicles. The high voltage battery could catch fire when charged to full or nearly full capacity.
Consequence & remedy
Consequence: A battery fire increases the risk of injury.
Remedy: This recall has been superseded by recall number 21V-560. Vehicles previously repaired under 20V-701 will still need to have the new remedy under recall 21V-560. GM will notify owners, and as an interim repair, beginning on November 17, 2020, dealers will reprogram the hybrid propulsion control module 2 (HPCM2) to limit the full charge to 90%, free of charge. Owners are advised to activate either the Hill Top Reserve (2017 and 2018 models) or Target Charge Level (2019 models) feature in their vehicle to limit the charge level to 90%, or park outside, until the software update is completed. Owners were notified of the interim repair beginning November 17, 2020. The second notice was mailed on May 11, 2021. Owners may contact the Bolt EV Concierge Team at 1-833-382-4389. GM's number for this recall is N202311730.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE20016 · Electric Vehicle Battery Fires
Opened Oct 9, 2020 · Closed Feb 7, 2022
Status: closed (inferred from source dates) · Electrical System:propulsion System; Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Additional source detail variants (6)
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800
Electrical System:propulsion System:traction Battery
In October 2020, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE) on 2017-2020 Model Year (MY) Chevrolet Bolt vehicles based on complaints received alleging that the vehicles caught fire under the seating area while parked and unattended. At the time, ODI had received 2 Vehicle Owner Questionnaires (VOQs) and several field reports. All complaints alleged vehicles caught fire during or after electrical charging.ODI's review found vehicle thermal events occurred during and/or at the end of the battery module charging cycle. The information learned from NHTSA and General Motors joint vehicle inspections prompted General Motors to file Recall 20V-701 on April 29, 2021. The remedy for this recall included 1) performing diagnostic procedures to identify and replace potentially defective battery cell-module assemblies and 2) installing onboard diagnostic software, designed to detect and warn owners regarding potential issues related to changes in battery module performance over time. Until this interim remedy became available for all affected vehicles, General Motors instructed their customers to enable ?Hilltop Reserve or ?Target Charge Level, based on the vehicle-equipped technology. Enabling these technologies would limit charging capacity of the battery module to a maximum of 90 percent. General Motors then continued to investigate the root cause of these battery cell module thermal events, which would lead them to their long-term recall remedy solution. Utilizing the information obtained from the Recall 20V-701 software update, General Motors and LG Energy Solutions,the supplier of the battery cell module pack along with LG Electronics,determined the root cause of the thermal events to be the result of two simultaneous manufacturing defects occurring in the same battery cell. The defect condition appears to be aggravated by routinely charging the battery to a full or nearly full state of charge after it has been substantially depleted. The two defects, located within the same battery cell module, would cause an internal short within the battery pack, resulting in the thermal events. The manufacturing process was changed to prevent the occurrence of these two defect conditions.On July 24, 2021, General Motors filed a defect information report recalling all 2017-2018 Chevrolet Bolt and certain 2019 Chevrolet Bolt vehicles with design level N2.1 battery cell produced at the LG Ochang, Korea plant. This remedy replaces defective battery cell-modules and will prevent potential thermal events from occurring during and/or at the end of the charge cycle. The recall (21V-560) includes vehicles that were remedied under 20V-701.General Motors continued to review new data after Recall 21V-560 and learned of an incident that occurred outside of the scope of the recall population. Additional analysis led General Motors and LGES to determine that the manufacturing defects defined by Recall 21V-560 were not isolated to one battery manufacturing plant. On August 21, 2021, General Motors filed a defect information report to expand the scope of recall 21V-560. The recall (21V-650) includes all 2019-2022 Chevrolet Bolt EV and 2022 Chevrolet Bolt EUV vehicles. In view of the recall actions being taken by General Motors, ODI is closing this Preliminary Evaluation. NHTSA reserves the right to take additional action if warranted by future circumstances.The ODI reports cited above can be reviewed online at nhtsa.gov under the following identification numbers:11230072, 11425524, 11339878, 11365622, 11364692, 11427180, 11429891, 11374956, 11407212, 11372429, 11425225, 11415800