IllustrationCONSUMER WAS HEARING A NOISE WHEN TURNING RIGHT. CONSUMER TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC, WHO INDICATED THAT HE WAS UNABLE TO DIAGNOSE THE PROBLEM. *AK
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
Suspension complaints
40 reportsCONSUMER HEARD A NOISE IN THE FRONT OF VEHICLE. CONSUMER STATED HE HAD BEEN HEARING IT A LITTLE, BUT CURRENTLY THE NOISE BECAME MORE PRONOUNCED. CONSUMER HAD ALREADY REPLACED THE TRANSMISSION ONCE. *AK THE CONSUMER HAD TO FILL THE TIRES EVERY WEEK. THE TIRES LEAKED AIR SINCE PURCHASE. THE TIRE SERVICE DEALER SUGGESTED…
Read full complaint
CONSUMER HEARD A NOISE IN THE FRONT OF VEHICLE. CONSUMER STATED HE HAD BEEN HEARING IT A LITTLE, BUT CURRENTLY THE NOISE BECAME MORE PRONOUNCED. CONSUMER HAD ALREADY REPLACED THE TRANSMISSION ONCE. *AK THE CONSUMER HAD TO FILL THE TIRES EVERY WEEK. THE TIRES LEAKED AIR SINCE PURCHASE. THE TIRE SERVICE DEALER SUGGESTED THAT THERE WAS NO LEAK AND THAT CORROSION BUILT UP ON THE WHEELS IN WHICH AIR ESCAPED THROUGH THE RIM OF TIRES. THERE WAS A THUMPING NOISE IN THE FRONT END AND SEEMS LIKE IT HAPPENS WORST ON RIGHT TURNS, THE LEFT WHEEL BEARING WAS LOOSE IN THE HUB BEARING ASSEMBLY, THE HOOD HINGES RATTLING EXCESSIVE CLEARENCE, THERE WAS EXCESSIVE SLIPPAGE AND THE CLUTCH BURNT. (LAREDO TIRES) *SC
BOTH FRONT WHEEL HUB ASSEMBLY FAILED AT THE SAME TIME.*AK
WHILE DRIVING AT ANY SPEED CONSUMER CONTINUED TO HEAR A THUMPING SOUND COMING FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR AN EXAMINATION, AND DEALER DETERMINED THAT LOWER BALL JOINTS NEEDED REPLACEMENT. *AK *MR
WHILE DRIVING THE CONSUMER HEARD A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE MECHANIC REPLACED THE WHEEL BEARINGS ON THE RIGHT SIDE. *AK THE HUB ASSEMBLY WAS ALSO REPLACED. *SC
RATTLE IN FRONT END OF VEHICLE COMING FROM SUSPENSION, OR WHEELS, CAN BE FELT IN STEERING WHEEL. ALSO AFTER COMING TO A STOP AFTER TRAVELING ON INTERSTATE VEHICLE SHAKES/VIBRATES IN TRANSMISSION/REAR DRIVETRAIN AREA WHEN STARTING. BOTH HAVE BEEN GOING ON FOR A COUPLE YEARS, AND I HAVE HAD VEHICLE AT DEALER SHIP TO RE…
Read full complaint
RATTLE IN FRONT END OF VEHICLE COMING FROM SUSPENSION, OR WHEELS, CAN BE FELT IN STEERING WHEEL. ALSO AFTER COMING TO A STOP AFTER TRAVELING ON INTERSTATE VEHICLE SHAKES/VIBRATES IN TRANSMISSION/REAR DRIVETRAIN AREA WHEN STARTING. BOTH HAVE BEEN GOING ON FOR A COUPLE YEARS, AND I HAVE HAD VEHICLE AT DEALER SHIP TO REPAIR/LOCATE PROBLEM, BUT PROBLEM CONTINUES
THE AC COMPRESSOR HAS BEEN REPLACED 3 TIMES - THE LAST TIME WAS ON 9/2003. THE EXHAUST PIPE SEAL HAS BEEN REPLACED, THE MUFFLER HAS BEEN REPLACED, CLUSTER DASH WENT OUT AND REPLACED, FRONT SUSPENSION REPLACED, BRAKE LIGHTS WENT OUT AND REPLACED. THE BACK WINDOW WAS NOT ALIGNED PROPERLY AND HAD TO BE FIXED. THE FRONT PASSENGER…
Read full complaint
THE AC COMPRESSOR HAS BEEN REPLACED 3 TIMES - THE LAST TIME WAS ON 9/2003. THE EXHAUST PIPE SEAL HAS BEEN REPLACED, THE MUFFLER HAS BEEN REPLACED, CLUSTER DASH WENT OUT AND REPLACED, FRONT SUSPENSION REPLACED, BRAKE LIGHTS WENT OUT AND REPLACED. THE BACK WINDOW WAS NOT ALIGNED PROPERLY AND HAD TO BE FIXED. THE FRONT PASSENGER DOOR HAD TO BE REALIGNED AND THE DOOR SILL REPLACED.
TRANSMISSION DROPPED OUT @44000 MILES. 12/02 HAD TO REPLACE BOTH FRONT BALL JOINTS. SUMMER OF '03 STARTED MAKING LOUD POPPING NOISES WHICH CAME FROM FRONT RIGHT AREA, IT WOULD PULL UNEXPECTEDLY TO EITHER SIDE - MAINLY TO THE RIGHT AND SERVICE 4WD LIGHT WOULD COME ON. 10/03 HAD TO HAVE RIGHT FRONT WHEEL BEARING REPLACED. COULD…
Read full complaint
TRANSMISSION DROPPED OUT @44000 MILES. 12/02 HAD TO REPLACE BOTH FRONT BALL JOINTS. SUMMER OF '03 STARTED MAKING LOUD POPPING NOISES WHICH CAME FROM FRONT RIGHT AREA, IT WOULD PULL UNEXPECTEDLY TO EITHER SIDE - MAINLY TO THE RIGHT AND SERVICE 4WD LIGHT WOULD COME ON. 10/03 HAD TO HAVE RIGHT FRONT WHEEL BEARING REPLACED. COULD FIND NOTHING WRONG WITH 4WD-DON'T KNOW WHY LIGHT KEEPS COMING ON. NOW 01/04, RIGHT FRONT WHEEL BEARING NEEDS REPLACED AGAIN. I'M TOLD PART UNDER WARRANTY AS LONG AS I OWN VEHICLE CAUSE GM HAS RECEIVED SO MANY COMPLAINTS. WHAT IS GM DOING TO CORRECT THE ROOT CAUSE OF THIS? I SEE I AM NOT THE ONLY ONE WITH THIS PROBLEM. THANK GOD I HAVE NOT HAD ANY ACCIDENTS, BUT HAVE HAD A FEW NEAR MISSES BECAUSE THE IT WOULD "JERK INSTANTLY" AND IT CAUGHT ME OFF GUARD. DOES AN ACCIDENT / INJURY / FATALITY HAVE TO HAPPEN BEFORE CORRECTIVE ACTION IS TAKEN? *CB
HUB AND BEARING ASSEMBLY, ONLY TO FIND THAT IT IS A COMMON PROBLEM, THIS CAR HAS LITTLE LESS THAN 40,000 MILES ON IT, PAYING UP THE YANG YANG JUST BUYING IT, AND ALREADY HAVING A PROBLEM WITH IT, PLEASE NOTE, THAT MUCH OF THIS IS LONG DISTANCE DRIVING, IS IT CHEAP ASSEMBLY PARTS, OR JUST BAD WORKMANSHIP? SAID WEAR AND TEAR, IF I…
Read full complaint
HUB AND BEARING ASSEMBLY, ONLY TO FIND THAT IT IS A COMMON PROBLEM, THIS CAR HAS LITTLE LESS THAN 40,000 MILES ON IT, PAYING UP THE YANG YANG JUST BUYING IT, AND ALREADY HAVING A PROBLEM WITH IT, PLEASE NOTE, THAT MUCH OF THIS IS LONG DISTANCE DRIVING, IS IT CHEAP ASSEMBLY PARTS, OR JUST BAD WORKMANSHIP? SAID WEAR AND TEAR, IF IT IS A COMMON PROBLEM, MUST NOT BE WEAR AND TEAR, MUST HAVE A CHEAP PART. *NLM
I HAVE REVIEWED OTHER OWNERS COMPLAINTS REGARDING THEIR FRONT SUSPENSION, FUEL PUMP WITH RANDOM SHUT OFFS. MY VEHICLE IS EXPERIENCING THE SAME AND SIMILAR PROBLEMS. AS OF TODAY MY VEHICLE IS IN THE SHOP;I WAS DOING 35-40 MPH WHEN VEHICLE JUST UN EXPECTEDLY SHUT OFF. I WAS STRANDED ON A MAJOR ROAD WHICH CAUSE A SIGNIFICANT TRAFFI…
Read full complaint
I HAVE REVIEWED OTHER OWNERS COMPLAINTS REGARDING THEIR FRONT SUSPENSION, FUEL PUMP WITH RANDOM SHUT OFFS. MY VEHICLE IS EXPERIENCING THE SAME AND SIMILAR PROBLEMS. AS OF TODAY MY VEHICLE IS IN THE SHOP;I WAS DOING 35-40 MPH WHEN VEHICLE JUST UN EXPECTEDLY SHUT OFF. I WAS STRANDED ON A MAJOR ROAD WHICH CAUSE A SIGNIFICANT TRAFFIC DELAY. I HAVE AN OIL LEAK FROM THE HOSE LEADING TO MY OIL FILTER AND THE VEHICLE PULL TO THE RIGHT SHARPLY IF I RELEASE THE STEERING WHEEL. THE VEHICLE MAKES A POPPING SOUND WHEN TURNING. THESE PROBLEMS ARE HARD TO FIND JUST AN ISOLATED INCIDENT WHEN SO MANY CONSUMERS ARE HAVING THE SAME PROBLEMS. *NLM
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.