IllustrationAPPLIED BRAKES TO STOP QUICKLY DUE TO STOPPING TRAFFIC. THE ABS SYSTEM SEEM TO HARDLY STOP THE VEHICLE AT ALL. IT JUST SEEMED TO KEEP GOING. VEHICLE STOPS FINE WHEN ABS NOT INVOLVED. *AK
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
Service Brakes, Hydraulic complaints
36 reportsON THE 10 OF JULY I TOOK MY 2001 CHEVY BLAZER IN FOR ROUTINE BRAKE SERVICE, I WAS THEN TOLD BY MY MECHANIC(SATCH WHITT) THAT I HAD 4 DEFECTIVE ROTORS THAT NEEDED TO BE REPLACED, THAT THEY APPEARED TO BE DEFECTIVE. HE STATED THAT THE METAL WAS JUST FLAKING OFF AND TO HIM IT APPEARED THAT THEY HAD BEEN MADE FROM REPROCESSED METAL.…
Read full complaint
ON THE 10 OF JULY I TOOK MY 2001 CHEVY BLAZER IN FOR ROUTINE BRAKE SERVICE, I WAS THEN TOLD BY MY MECHANIC(SATCH WHITT) THAT I HAD 4 DEFECTIVE ROTORS THAT NEEDED TO BE REPLACED, THAT THEY APPEARED TO BE DEFECTIVE. HE STATED THAT THE METAL WAS JUST FLAKING OFF AND TO HIM IT APPEARED THAT THEY HAD BEEN MADE FROM REPROCESSED METAL. HE ALSO STATED THAT HE HAD SEEN ALOT OF THIS IN THE NEWER CHEVY PRODUCTS RECENTLY. ALTHOUGH I WAS LUCKY AND DID NOT HAVE AN ACCIDENT I FEEL THAT THIS IS A VERY REAL SAFETY CONCERN FOR AMERICAN FAMILIES. I HAVE KEPT THE ROTORS IN HOPES THAT CHEVROLET WOULD STAND BEHIND THIER PRODUCT. THANK YOU FOR YOUR TIME AND CONSIDERATION IN THIS SAFETY MATTER, MARK WILEY. *AK
WHEN UTILIZING THE BRAKES, NORMALLY OR IN AN EMERGENCY, THE MECHANISM LOCK CAUSES THE VEHICLE TO CONTINUE TO MOVE. THE BRAKES REGULARLY CLICK WHEN STEPPED ON. A 'MANAGER' AT THE OFFICE OF THE PRESIDENT AT CHEVROLET NA STATED THERE IS NO PROBLEM WITH THE WAY THE VEHICLE STOPS. WHEN I INSISTED, HE STATED NEXT TIME PERHAPS I 'SHOUL…
Read full complaint
WHEN UTILIZING THE BRAKES, NORMALLY OR IN AN EMERGENCY, THE MECHANISM LOCK CAUSES THE VEHICLE TO CONTINUE TO MOVE. THE BRAKES REGULARLY CLICK WHEN STEPPED ON. A 'MANAGER' AT THE OFFICE OF THE PRESIDENT AT CHEVROLET NA STATED THERE IS NO PROBLEM WITH THE WAY THE VEHICLE STOPS. WHEN I INSISTED, HE STATED NEXT TIME PERHAPS I 'SHOULD BUY A TOYOTA". I AM AFRAID TO DRIVE THE VEHICLE EXCEPT FOR VERY SHORT TRIPS AND NOT ON ANY MAIN STREET OR HIGHWAY. THIS HAPPENS REPEATEDLY. THE LATEST DATE IS REFLECTED BELOW. *JB
WHEN THE BRAKES WERE APPLIED, THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. *JB . DEALER REPLACED BRAKES, AS WELL AS MASTER CYLINDER. *AK
THE ABS LIGHT ILLUMINATED, WHICH CAUSED LOSS OF BRAKING.*JB
AFTER APPLYING BRAKES VEHICLE GOES INTO EXTENDED STOPPING DISTANCE. DEALER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION.*AK
I PURCHASED MY VEHICLE IN 4/01 AND SEVEN MONTHS LATER I BEGAN EXPERIENCING A HOST OF PROBLEMS WITH MY VEHICLE, STARTING WITH MULTIFUNCTION SWITCH WORN, THEN HOOD HINGES WORN, EXHAUST (MUFFLER BROKEN) RIGHT SPEAKER INOPERABLE, LEFT FRONT SEAT ADJUSTER BROKEN, GRILL ASSEMBLY LOOSE, BRAKE PEDAL BROKEN AND FINALLY TRANSMISSION FAIL…
Read full complaint
I PURCHASED MY VEHICLE IN 4/01 AND SEVEN MONTHS LATER I BEGAN EXPERIENCING A HOST OF PROBLEMS WITH MY VEHICLE, STARTING WITH MULTIFUNCTION SWITCH WORN, THEN HOOD HINGES WORN, EXHAUST (MUFFLER BROKEN) RIGHT SPEAKER INOPERABLE, LEFT FRONT SEAT ADJUSTER BROKEN, GRILL ASSEMBLY LOOSE, BRAKE PEDAL BROKEN AND FINALLY TRANSMISSION FAILURE (NEEDS REPLACING). I HAVE DONE A BIT OF INQUIRING TO OTHER CHEVY BLAZER OWNERS AND FOUND OUT THAT THEY HAVE OR HAD EXPERIENCE SOME IF NOT ALL OF THE SAME PROBLEMS THAT I AM EXPERIENCING NOW. I AM HEREBY RESPECTFULLY REQUESTING YOUR ASSISTANCE IN RECTIFYING THIS COMPLAINT. I DON'T THINK THAT AFTER 11MTHS OF PURCHASING MY VEHICLE I SHOULD BE NEEDING MY TRANSMISSION REPLACE. FROM PASSED EXPERIENCED WITH REPLACING A TRANSMISSION ON MY WIFE NEW VEHICLE (MAZDA MX3) BACK IN 1992 IT HAS NEVER BEEN THE SAME. WE HAD BEEN HAVING THE SAME PROBLEMS AND MORE WITH IT. WE WERE ABLE TO ACTUALLY GET ANOTHER VEHICLE AND THE SAME PROBLEM KEEP OCCURING . AFTER THAT LONG AND TIRING EXPERIENCE WITH MY WIFE'S CAR I NOW THAT THIS WON'T BE NO DIFFERENT. I HAVE PURCHASED A LEMON AND I NEED TO KNOW WHAT RECOURSE I CAN TAKE TO INSURE THAT I WOULD NOT BE STUCK WITH A VEHICLE THAT WOULD BE COSTING ME MORE TO HAVE IT CONSTANTLY FIXED AND REPLACE. I THANK YOU FOR YOUR HELP AND ASSISTANCE IN THIS LONG AND TIRING ORDEAL. I ANXIOUSLY AWAIT HEARING FROM YOU. RESPECTFULLY YOURS. *AK
WHILE DRIVING ABS FUNCTION POORLY. *AK VEHICLE IS EXPERIENCING MULTI-FUNCTION SWITCH ASSEMBLY PROBLEM WHICH CAUSED LOSS OF HAZARD LIGHTS, BRAKE LIGHTS, TURN SIGNAL LIGHTS AND HAZARD LIGHTS. CONSUMER IS STATING THAT THE VEHICLE HAD A RECALL, # 01V364000, WHEN HE CALLED CHEVROLET CORPORATION, THEY TOLD HIM THAT THE COST WOULD …
Read full complaint
WHILE DRIVING ABS FUNCTION POORLY. *AK VEHICLE IS EXPERIENCING MULTI-FUNCTION SWITCH ASSEMBLY PROBLEM WHICH CAUSED LOSS OF HAZARD LIGHTS, BRAKE LIGHTS, TURN SIGNAL LIGHTS AND HAZARD LIGHTS. CONSUMER IS STATING THAT THE VEHICLE HAD A RECALL, # 01V364000, WHEN HE CALLED CHEVROLET CORPORATION, THEY TOLD HIM THAT THE COST WOULD BE COVERED BUT DEALER SAID NO. CONSUMER IS LOOKING FOR REIMBURSEMENT OF $362.92. *YD
INTERMITTENTLY WHEN BRAKES ARE APPLIED LEFT WHEEL PULSATES, AND OTHER WHEELS LOCK UP. DEALER HAS BEEN NOTIFIED, AND COULD NOT DUPLICATE THE PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
ON 11/20/01 I PRESSED BRAKE PEDAL TO FLOOR BUT MY BRAKES FAILED CAUSING MY VEHICLE TO BUMP A VEHICLE IN FRONT OF ME (BUMPED VEHICLE AT VERY SLOW SPEED DUE TO HEAVY STOP AND GO TRAFFIC). I INITIALLY THOUGHT THAT MY FOOT MERELY SLIPPED OFF THE BRAKE PEDAL AS AFTER THE INCIDENT MY BRAKES WORKED PROPERLY. HOWEVER, ON THE FOLLOWING…
Read full complaint
ON 11/20/01 I PRESSED BRAKE PEDAL TO FLOOR BUT MY BRAKES FAILED CAUSING MY VEHICLE TO BUMP A VEHICLE IN FRONT OF ME (BUMPED VEHICLE AT VERY SLOW SPEED DUE TO HEAVY STOP AND GO TRAFFIC). I INITIALLY THOUGHT THAT MY FOOT MERELY SLIPPED OFF THE BRAKE PEDAL AS AFTER THE INCIDENT MY BRAKES WORKED PROPERLY. HOWEVER, ON THE FOLLOWING DAY (11/21/01) MY BRAKES FAILED A SECOND TIME. I HAD TO SWERVE ONTO THE SHOULDER OF THE ROAD IN ORDER TO AVOID AN ACCIDENT AND WAS FINALLY ABLE TO GET MY VEHICLE STOPPED. AFTER A SHORT PERIOD OF TIME, MY BRAKES WERE OPERATIONAL AGAIN. AT THAT POINT, THE VEHICLE WAS TAKEN TO THE CLOSEST CHEVY DEALERSHIP (HERITAGE AUTO PLAZA IN ALEXANDRIA, VA) WHERE IT REMAINS AS OF 10:05 A.M. ON 11/26/01. *AK
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.