IllustrationTL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CONTACT STATED THAT THE MULTIFUNCTIONAL SWITCH FAILED, AND THE DEALER WILL NOT REPAIR IT UNDER RECALL. THE CURRENT AND FAILURE MILEAGES WERE 122,300.
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
Exterior Lighting complaints
68 reportsTL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. ALL OF THE BRAKE LIGHTS MALFUNCTIONED EXCEPT FOR THE WINDOW BRAKE LIGHT. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE CURRENT AN…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. ALL OF THE BRAKE LIGHTS MALFUNCTIONED EXCEPT FOR THE WINDOW BRAKE LIGHT. THE VEHICLE WAS NOT INSPECTED BY A DEALER. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH). THE CURRENT AND FAILURE MILEAGES WERE 31,000.
I HAVE A 2001 CHEVROLET BLAZER THAT RECENTLY HAD TO BE REPAIRED. I FEEL THAT A RECALL ITEM SHOULD COVER COST OF THE REPAIR. THE CHEVROLET CUSTOMER REPRESENTATIVE THAT I SPOKE TO SAID THAT IT IS NOT COVERED BY THE RECALL. IN A NUTSHELL, THE SYMPTOMS THAT THE CAR HAD ARE EXACTLY THE SAME AS THOSE MENTIONED IN NHTSA CAMPAIGN ID NUM…
Read full complaint
I HAVE A 2001 CHEVROLET BLAZER THAT RECENTLY HAD TO BE REPAIRED. I FEEL THAT A RECALL ITEM SHOULD COVER COST OF THE REPAIR. THE CHEVROLET CUSTOMER REPRESENTATIVE THAT I SPOKE TO SAID THAT IT IS NOT COVERED BY THE RECALL. IN A NUTSHELL, THE SYMPTOMS THAT THE CAR HAD ARE EXACTLY THE SAME AS THOSE MENTIONED IN NHTSA CAMPAIGN ID NUMBER : 01V364000. BOTH REAR, OUTSIDE STOPLIGHTS STOPPED WORKING. THE CENTER STOP AND THE TURN SIGNALS WORKED FINE. I HAD THE CAR REPAIRED AT A COST OF $470.29. ON THE INVOICE THE ITEM REPLACED IS A MULTIFUNCTION SWITCH? *TR
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE CONTACT STATED THAT THE BRAKE LIGHTS WOULD NOT ILLUMINATE. AS OF SEPTEMBER 24, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE MANUFACTURER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CURRENT AND FAI…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET BLAZER. THE CONTACT STATED THAT THE BRAKE LIGHTS WOULD NOT ILLUMINATE. AS OF SEPTEMBER 24, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE MANUFACTURER STATED THAT HIS VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 01V364000 (EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH). THE CURRENT AND FAILURE MILEAGES WERE 76,000. UPDATED 12/12/07
2001 BLAZER HAS DEFECTIVE BRAKE LIGHTS. THIS IS INTERMITTENT, AND IS RELATED TO THE HAZARD FLASHER SWITCH ASSEMBLY. THERE IS A RECALL ON THIS ISSUE FOR SELECTED VINS. GM WILL NOT COVER THIS PROBLEM ON MY VEHICLE WHICH HAS EXPERIENCED THIS PROBLEM AT LEAST 2 TIMES IN THE PAST YEAR. *AK
I WAS IN A DRIVE THROUGH WHICH LOOPED AROUND THE BUILDING. I APPLIED THE BRAKE TO STOP AT THE WINDOW AND COULD FEEL THE ABS ENGAGE AND THE VEHICLE DID NOT WANT TO STOP. IT SCARED ME AND OF COURSE I REAPPLIED THE BRAKE QUICKLY, TO AVOID HITTING THE VEHICLE IN FRONT OF ME, AND I WAS FINALLY ABLE TO STOP. THIS HAPPENED AGAIN A FEW …
Read full complaint
I WAS IN A DRIVE THROUGH WHICH LOOPED AROUND THE BUILDING. I APPLIED THE BRAKE TO STOP AT THE WINDOW AND COULD FEEL THE ABS ENGAGE AND THE VEHICLE DID NOT WANT TO STOP. IT SCARED ME AND OF COURSE I REAPPLIED THE BRAKE QUICKLY, TO AVOID HITTING THE VEHICLE IN FRONT OF ME, AND I WAS FINALLY ABLE TO STOP. THIS HAPPENED AGAIN A FEW WEEKS LATER AT A LARGE INTERSECTION AT A RED LIGHT. I WAS 7 MONTHS PREGNANT AT THE TIME AND WAS PRETTY SCARED. I HAVE HEARD SEVERAL OF THESE COMPLAINTS AND I KNOW THAT THE BRAKES ON EVERY YEAR BEFORE THIS WERE RECALLED. I ALSO HAD TROUBLE WITH THE BRAKE LIGHTS AND FOUR-WAYS, WHICH STOPPED WORKING. I WAS DRIVING AND THE FOUR WAYS CAME ON. I HAD TO PULL OVER AND ENDED UP HOLDING THE BUTTON DOWN WHILE I DROVE IN ORDER FOR THEM TO STOP FLASHING. SHORTLY AFTER THE TURN SIGNALS STOPPED WORKING. FINALLY, THE SPEEDOMETER TEMPORARILY STOPPED WORKING, THEN SHORTLY AFTER THAT, THE HEAT STOPPED WORKING, THE VEHICLE ONLY BLOWING COLD AIR. WE REPLACED THE THERMOSTAT BUT THE HEAT STILL WOULD NOT FUNCTION. I ENDED UP GETTING RID OF THE VEHICLE BECAUSE OF THE NUMEROUS MALFUNCTIONS. *JB
I OWN A 2001 CHEVY BLAZER, MY BRAKE LIGHTS AND HAZARD LIGHTS STOPPED WORKING FOR NO APPARENT REASON. THE BULBS ARE IN WORKING CONDITION, THE FUSES ARE NOT BLOWN. I THEN DID AN INTERNET SEARCH AND FOUND OUT THAT THE 2001 BLAZERS WERE RECALLED FOR THIS VERY SAME PROBLEM NHTSA CAMPAIGN 01V364000, SO I PHONED A CHEVY DEALER AND WAS …
Read full complaint
I OWN A 2001 CHEVY BLAZER, MY BRAKE LIGHTS AND HAZARD LIGHTS STOPPED WORKING FOR NO APPARENT REASON. THE BULBS ARE IN WORKING CONDITION, THE FUSES ARE NOT BLOWN. I THEN DID AN INTERNET SEARCH AND FOUND OUT THAT THE 2001 BLAZERS WERE RECALLED FOR THIS VERY SAME PROBLEM NHTSA CAMPAIGN 01V364000, SO I PHONED A CHEVY DEALER AND WAS TOLD MY VIN # WAS NOT INCLUDED IN THE RECALL AND IT WAS OVER I DON'T FEEL THAT I SHOULD BE BURDENED WITH THIS PROBLEM WHEN IT IS CLEARLY DEFECTIVE MANUFACTURING. *JB
DT*: THE CONTACT STATED THE BRAKE LIGHTS REMAIN ILLUMINATED. IN ORDER TO SHUT OFF THE BRAKE LIGHTS, THE BATTERY HAS TO BE DISCONNECTED TO KEEP FROM RUNNING DOWN THE BATTERY. AN NHTSA RECALL, 06V139000; WAS PERFORMED ON THE VEHICLE CONCERNING, THE; EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH HOWEVER; THE RECALL DID NOT REMEDY THE P…
Read full complaint
DT*: THE CONTACT STATED THE BRAKE LIGHTS REMAIN ILLUMINATED. IN ORDER TO SHUT OFF THE BRAKE LIGHTS, THE BATTERY HAS TO BE DISCONNECTED TO KEEP FROM RUNNING DOWN THE BATTERY. AN NHTSA RECALL, 06V139000; WAS PERFORMED ON THE VEHICLE CONCERNING, THE; EXTERIOR LIGHTING: BRAKE LIGHTS: SWITCH HOWEVER; THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER A SECOND REPAIR WITHOUT CHARGE UNDER THE RECALL.
SWITCH FAILURE FOR STOP LAMPS OTHER VEHICLE DID STOP AND ADVISE OF PROBLEM. GM DID RECALL SOME VIN #'S BUT NOT THIS UNIT. DEALER CHARGED $400. FOR SAME ITEMS IN RECALL #01V364000. *NM
DT: THE CONTACT STATED WHILE PARKED AT A BANK SMOKE CAME FROM THE STEERING COLUMN. WHEN HE TOOK THE VEHICLE TO THE DEALERSHIP , THEY FOUND THAT THE BRAKE LIGHTS AND TURN SIGNALS WERE NOT WORKING. THE TURN SIGNAL ASSEMBLY WAS REPLACED AND THERE HAVE BEEN NO FURTHER PROBLEMS. *AK
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.