IllustrationTL*THE CONTACT OWNED A 2001 CHEVROLET BLAZER. THE CONTACT STATED THAT THE AIR PUMP FILLED WITH WATER AND FROZE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE AIR PUMP WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.
2001 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 2001 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
150–25K
3525–50K
4550–75K
2275–100K
18100–150K
7150K+
142 reports with mileage · 184 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
35 crash reports5 fire reports19 injury reports
Engine And Engine Cooling complaints
23 reportsTHE ELECTRIC SMOG PUMP ON MY 2001 CHEVY BLAZER HAD FAILED WHEN PUMP FILLED WITH WATER AND SHORTED OUT. THIS IS CAUSED DUE TO THE SHORT INTAKE HOSE TO THE PUMP. THIS IS AN APPARENT KNOWN ISSUE WITH GM, BUT THEY WILL NOT REPLACE THE PUMP. THIS ALSO CAUSES THE VEHICLE TO FAIL EMISSIONS TESTING. GM WANTED $400 FOR THE PUMP + LAB…
Read full complaint
THE ELECTRIC SMOG PUMP ON MY 2001 CHEVY BLAZER HAD FAILED WHEN PUMP FILLED WITH WATER AND SHORTED OUT. THIS IS CAUSED DUE TO THE SHORT INTAKE HOSE TO THE PUMP. THIS IS AN APPARENT KNOWN ISSUE WITH GM, BUT THEY WILL NOT REPLACE THE PUMP. THIS ALSO CAUSES THE VEHICLE TO FAIL EMISSIONS TESTING. GM WANTED $400 FOR THE PUMP + LABOR TO REPAIR THE ISSUE. ONCE THE PART BECAME AVAILABLE FOR 3RD PARTY VENDORS, WE WERE ABLE TO REPLACE THE PUMP OURSELVES, ADDED A LONGER INTAKE HOSE, AND THE VEHICLE NOW RUNS CORRECTLY. I FEEL THAT SINCE GM IS AWARE OF THIS ISSUE AND IT ADVERSELY EFFECTS THE EMISSION CONTROL OF THE VEHICLE, THE REPAIR SHOULD BE GM'S RESPONSIBILITY. *TR
THERE IS AN ERROR CODE IN TEH COMPUTER P0410 THE SECONDARY INJECTOR NEEDS TO BE REPLACED AGAIN AND AGAIN, IT WAS COVERED UNDER WARRANTY THE FIRST TIME. THEN WEMOVED TO MASSACHUSETTS AND THE LIGHT CAME ON AGAIN WHICH I THEN GOT IT FIXED AND PAID FOR IT ON MY OWN BECAUSE IT WASN'T UNDER WARRANTY, AND THE LIGHT CAME ON AGAIN WIT…
Read full complaint
THERE IS AN ERROR CODE IN TEH COMPUTER P0410 THE SECONDARY INJECTOR NEEDS TO BE REPLACED AGAIN AND AGAIN, IT WAS COVERED UNDER WARRANTY THE FIRST TIME. THEN WEMOVED TO MASSACHUSETTS AND THE LIGHT CAME ON AGAIN WHICH I THEN GOT IT FIXED AND PAID FOR IT ON MY OWN BECAUSE IT WASN'T UNDER WARRANTY, AND THE LIGHT CAME ON AGAIN WITH TEH SAME CODE P0410 THE SECONDARY AIR INJECTOR. I HAVEN'T BEEN ABEL TO GET THE VEHICLE INSPECTED DUE TO TEH ERROR CODE BECUASE IT CAUSED AN EMMSISIONS FAILURE. THE SECOND TIME COST ME $400, I'VE LOOKED ON THE INTERNET ONLY TO FIND THAT MANY OTHER POEPLE HAVE THE SAME PROBLEM AND NO RECALL HAS BEEN ISSUED AS OF YET. I HAVE CONTACTED CHEVROLET ABOUT THE PROBLEM, WHICH TO NO AVAIL THEY WOULD NOT COVER THE PART ORANY COST OF A NEW ONE. THE VEHICLE WAS STILL NOT INSPECTED NOR WILL EVER BE BECAUSE REPLACING THE PART APPERENTLY WASN'T THE PROBLEM. IS THERE ANYTHING THE NHTSA COULD DO IN THIS SITUATION? *AK
ENGINE FAILURE DUE TO A LACK OF LUBRICATION TO THE NUMBER 6 CYLINDER. THE FAILURE OCCURRED WITH ONLY 60K ON THE TRUCK. THE TRUCK HAD REGULAR OIL CHANGES AND THE OIL LEVEL WAS CHECKED EVERY 500 MILES. *JB
DT: THE CONTACT STATED THE CHECK ENGINE LIGHT CAME AND THE ENGINE STARTED MISSING. THE AIR REFLECTOR ON THE BOTTOM OF THE THROTTLE BOTTLE PLATE DISINTEGRATED; THE AIR REFLECTOR HAS GONE THROUGH THE MOTOR. THE PLATE WAS EMBEDDED IN THE PISTONS, BROKE TWO SPARK PLUGS, AND BENT PUSH RODS. HE CHANGED THE SPARK PLUGS. HE THEN PUL…
Read full complaint
DT: THE CONTACT STATED THE CHECK ENGINE LIGHT CAME AND THE ENGINE STARTED MISSING. THE AIR REFLECTOR ON THE BOTTOM OF THE THROTTLE BOTTLE PLATE DISINTEGRATED; THE AIR REFLECTOR HAS GONE THROUGH THE MOTOR. THE PLATE WAS EMBEDDED IN THE PISTONS, BROKE TWO SPARK PLUGS, AND BENT PUSH RODS. HE CHANGED THE SPARK PLUGS. HE THEN PULLED THE VEHICLE IN AND REALIZED THE PUSH RODS AND LIFTERS WERE BAD. HE CONTACTED THE DEALER THEY OFFERED NO FREE REMEDY.*AK
DT: THE CONSUMER OWNS TWO GMC VEHICLES WITH THE SAME PROBLEM. THE CONSUMER RECEIVED NETS RECALL 05V155000 ON ONE OF THE VEHICLES BUT NOT FOR THE OTHER. THE PROBLEM WAS WITH THE FUEL MODULE RESERVOIR ASSEMBLY. SINCE THE VIN WAS NOT INCLUDED THEY WOULD NOT CORRECT THE PROBLEM. *AK (12/02/05) THE SERVICE ENGINE LIGHT SOON ST…
Read full complaint
DT: THE CONSUMER OWNS TWO GMC VEHICLES WITH THE SAME PROBLEM. THE CONSUMER RECEIVED NETS RECALL 05V155000 ON ONE OF THE VEHICLES BUT NOT FOR THE OTHER. THE PROBLEM WAS WITH THE FUEL MODULE RESERVOIR ASSEMBLY. SINCE THE VIN WAS NOT INCLUDED THEY WOULD NOT CORRECT THE PROBLEM. *AK (12/02/05) THE SERVICE ENGINE LIGHT SOON STAYED ON AND THE FUEL GAUGE DID NOT WORK PROPERLY. *SC
DT: CONSUMER OWNED A 2001 CHEVROLET BLAZER WHICH HE PURCHASED IN JANUARY 2002. THE VEHICLE STALLED SIX TIMES IN 2002, TWO TIMES IN 2004, AND TWO TIMES ON JULY 21, 2005. THE VEHICLE WAS NEVER TAKEN TO THE DEALERSHIP FOR THIS PROBLEM. ALSO, THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER. THIS HAPPENED AT ANY SPEED. THE VE…
Read full complaint
DT: CONSUMER OWNED A 2001 CHEVROLET BLAZER WHICH HE PURCHASED IN JANUARY 2002. THE VEHICLE STALLED SIX TIMES IN 2002, TWO TIMES IN 2004, AND TWO TIMES ON JULY 21, 2005. THE VEHICLE WAS NEVER TAKEN TO THE DEALERSHIP FOR THIS PROBLEM. ALSO, THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER. THIS HAPPENED AT ANY SPEED. THE VEHICLE DID NOT ALWAYS START RIGHT UP. THE PROBLEM WAS MORE PERSISTENT IN THE SUMMER. *AK *NM
2001 CHEVROLET BLAZER DEVELOPING VARIOUS PROBLEMS.***NO ANSWER REQUIRED***. *MR THE DIFFERENTIAL PINION SHAFT SEAL WAS LEAKING. WHEN IT RAINED THE TRANSMISSION SLIPPED, THE CIGARETTE LIGHTER WAS INOPERATIVE, THE LIGHTER SOCKET WAS REPLACED. THE HEATER WAS NOT BLOWING HOT AIR, THE SERVICE ENGINE SOON LIGHT ILLUMINATED, THE BRAK…
Read full complaint
2001 CHEVROLET BLAZER DEVELOPING VARIOUS PROBLEMS.***NO ANSWER REQUIRED***. *MR THE DIFFERENTIAL PINION SHAFT SEAL WAS LEAKING. WHEN IT RAINED THE TRANSMISSION SLIPPED, THE CIGARETTE LIGHTER WAS INOPERATIVE, THE LIGHTER SOCKET WAS REPLACED. THE HEATER WAS NOT BLOWING HOT AIR, THE SERVICE ENGINE SOON LIGHT ILLUMINATED, THE BRAKE LIGHT WAS INOPERABLE, THE DIRECTIONAL SWITCH WAS REPLACED. THE FRONT REAR ROTORS WERE ROTTED, THE REAR WHEEL WELL MOLDING WAS COMING UNDONE, THE DRIVERS WINDOW WAS LEAKING WATER. THE VEHICLE WAS NOT SHIFTING PROPERLY, THE ALTERNATOR WAS REPLACED, THE TAIL GATE GLASS WOULD NOT LOCK, THE DRIVER DOOR DID NOT SHUT EASILY, THE BATTERY WAS REPLACED. THE HEADLIGHTS WERE INOPERABLE. THE DRIVER SEAT RECLINER WAS REPLACED, THE RETRACTOR IN THE SEAT BELT WAS RESET. THE REAR WINDOW MOLDING WAS LOOSE. THE OIL COOLER LINES WERE LEAKING.*JB
GETS A P0140 DTC SECONDARY AIR PUMP. AIR PUMP IS CORRODED AND SHAFT WON'T TURN. MAXIFUSE BLOWS. *JB
I PURCHASED A USED 2001 CHEVROLET BLAZER LAST MARCH. I HAD THE VEHICLE FOR 1 MONTH AND THE SERVICE ENGINE SOON LIGHT CAME ON. I TOOK IT TO THE GARAGE AND THEY SAID I NEEDED AN AIR INTAKE BOX. I WAS ABLE TO GET A USED ONE. AFTER ONE YEAR I AM BACK TO THE SAME SITUATION. THIS AIR INTAKE BOX THAT WAS ANOTHER VEHICLE HAD THE SAME PR…
Read full complaint
I PURCHASED A USED 2001 CHEVROLET BLAZER LAST MARCH. I HAD THE VEHICLE FOR 1 MONTH AND THE SERVICE ENGINE SOON LIGHT CAME ON. I TOOK IT TO THE GARAGE AND THEY SAID I NEEDED AN AIR INTAKE BOX. I WAS ABLE TO GET A USED ONE. AFTER ONE YEAR I AM BACK TO THE SAME SITUATION. THIS AIR INTAKE BOX THAT WAS ANOTHER VEHICLE HAD THE SAME PROBLEM. WHEN REMOVED THE BOX CONTAINS ALOT OF CONDENSATION. THE SERVICE GARAGE DOES NOT KNOW WHY THIS HAPPENS. THE CONDENSATION I AM SURE IS WHATS CAUSING THE BOX TO FAIL. I WOULD LIKE THIS INVESTIGATED TO SEE IF THIS IS A RECALL.*AK
Official recalls
308V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.