Illustration1997 CHEVROLET BLAZER. FUEL GAUGE STOPPED WORKING 3 YEARS AGO. TRUCK WAS OUT OF WARRANTY AT THAT TIME. APPROXIMATE MILAGE WAS 20,000. CURRENT MILAGE IS 30,000. THIS REQUIRES A $350.00 FUEL PUMP, NOT INCLUDING LABOR. *AK ALSO, WINDSHIELD WIPERS STOP WORKING INTERMITTANTLY.(ANOTHER $75.00 FOR PARTS)
1997 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1997 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 171 of 768 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
60 crash reports26 fire reports44 injury reports
Fuel System, Other complaints
32 reportsFUEL SENDING UNIT IS FAILING. ONCE GAS HAS PASSED THE 3/4 FULL POINT ON THE GUAGE IT STAYS IN THAT AREA. I HAVE RAN OUT OF GAS A COUPLE OF TIMES BECAUSE OF THIS. TO BE SAFE I HAVE TO REFUEL MY TANK AFTER 250 MILES HAVE BEEN PUT ON THE TRIP METER.*AK
WHEN PUMPING GAS INTO THE FUEL TANK TO ITS FULL LIMIT IT WOULD THEN SPLASH OUT ONTO THE CONSUMER AND GROUND. DEALER HAD BEEN NOTIFIED. *AK
CONSUMER NOTICE FUEL INDICATOR GIVES WRONG READING DUE TO FUEL TANK ELECTRICAL SHORT.*AK
WINDSHIELD WIPERS LOSE INTERMITTENT FUNCTION AND STICK IN LOW SPEED. USUALLY HAPPENS IN A LIGHT RAINSTORM. WIPERS, WHEN MALFUNCTIONING, ALSO WILL STAY ON GOING AT LOW SPEED EVEN WITH THE SWITCH TURNED OFF. GAS GAUGE ALSO IS NOT FUNCTIONING RIGHT AND HAS A TENDENCY TO BOUNCE FROM EXTREME TO EXTREME WITHOUT WARNING. *JB
THE TRANSMISSION IN MY VEHICLE HAS A DEFECTIVE VALVE BODY AND IT CAUSED MY TRANSMISSION TO BREAK, I WENT TO THE DEALER WHEN I FIRST HAD THE PROBLEM OF A HARD SHIFT FROM FIRST TO SECOND GEAR WHEN THE VEHICLE WAS BEING DRIVEN LONG DISTANCES. THE DEALER SAID THE VEHICLE IS SHIFTING FINE AND TO BRING IT BACK WHEN IT DOES IT AGAIN. T…
Read full complaint
THE TRANSMISSION IN MY VEHICLE HAS A DEFECTIVE VALVE BODY AND IT CAUSED MY TRANSMISSION TO BREAK, I WENT TO THE DEALER WHEN I FIRST HAD THE PROBLEM OF A HARD SHIFT FROM FIRST TO SECOND GEAR WHEN THE VEHICLE WAS BEING DRIVEN LONG DISTANCES. THE DEALER SAID THE VEHICLE IS SHIFTING FINE AND TO BRING IT BACK WHEN IT DOES IT AGAIN. THIS WAS BACK ON 08/19/02 AND NOW I HAVE A CODE 1870 ON THE COMPUTER AND THE TRANSMISSION IS SHOT. I FOUND OUT THE TRANSMISSION IS A 4L60E AND IT IS VERY UNRELIABLE. ALSO I ALREADY HAD TO CHANGE MY WATER PUMP AND ALTERNATOR AND MY GAS GAUGE DOES NOT WORK AND THERE IS A PROBLEM WITH MY WINDSHIELD WIPERS ALSO. *JB
1997 CHEV BLAZER S-10 WINDSHIELD WIPPERS INTERMITTENT PROBLEM. STOP WORKING WITHOUT WARNING TRANSMISSION TCV SHORTED OUT, CAUSING COMPUTER TO SHORT OUT, REQUIRING REPLACEMENT GAS GAUGE DOESN'T WORK PAST 1/2 TANK NO WARNING. RAN OUT OF GAS ON INTERSTATE.
ENGINE LIGHT KEEPS COMING ON HAD A DIAGNOSTIC CHECK DONE WITH THE CODE P0440 COMING UP WHICH IS THE EVAPORATIVE EMISSIONS SYSTEM YET NO-ONE CAN FIND ANYTHING WROND WITH THE BLAZER
WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING THERE WAS FUEL SMELL COMING FROM UNDERNEATH THE DASHBOARD. PLEASE PROVIDE ADDITIONAL PROBLEM DEALER IS AWARE OF THE PROBLEM. TS
CONSUMER STATES THAT WHILE DRIVING AND WITHOUT WARNING THE FUEL TANK CRACK CAUSING FLUID TO LEAK OUT. DEALER NOTIFIED. TS
Official recalls
403V117000 · Seat Belts:front:buckle Assembly
Mar 31, 2003
CERTAIN SPORT UTILITY VEHICLES WERE BUILT WITH A DRIVER'S SEAT BELT BUCKLE ASSEMBLY THAT CONTAINS AN ENERGY-ABSORBING LOOP. SUSTAINED LOADS OF SUFFICIENT MAGNITUDE AND DURATION ON THE BELT IN SEVERE CRASHES COULD FULLY DEPLOY THE BUCKLE ENERGY-ABSORBING LOOP, INTRODUCING A TOTAL OF 10 ADDITIONAL INCHES OF WEBBING INTO THE SEAT BELT SYSTEM. THE FREE FALLING LATCH PLATE USED IN THIS SYSTEM MAY ALLOW WEBBING TO DYNAMICALLY DISTRIBUTE BETWEEN THE LAP AND SHOULDER BELT AS THE DRIVER'S POSITION CHANGES DURING A MULTIPLE ROLLOVER EVENT.
Consequence & remedy
Consequence: IF THE ENERGY-ABSORBING LOOP FULLY DEPLOYS IN A SEVERE MULTIPLE ROLLOVER CRASH, IT IS POSSIBLE THAT A BELTED DRIVER MAY EXPERIENCE PARTIAL OR EVEN COMPLETE EJECTION FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE ENERGY-ABSORBING SEAT BELT ASSEMBLIES WITH ONE THAT DOES NOT HAVE THE ENERGY-ABSORBING LOOP. OWNER NOTIFICATION BEGAN ON AUGUST 8, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
03V093000 · Visibility:rearview Mirrors/devices:exterior
Mar 7, 2003
CERTAIN SPORT UTILITY VEHICLES, MINI VANS, AND PICKUP TRUCKS MAY DEVELOP A SHORT CIRCUIT IN THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH.
Consequence & remedy
Consequence: IF THIS WERE TO HAPPEN, IT COULD RESULT IN AN INOPERATIVE SWITCH, HEAT DAMAGE TO THE DRIVER'S DOOR, AND/OR IGNITION OF COMPONENTS IN THE DRIVER'S DOOR AND A SUBSEQUENT VEHICLE FIRE WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS TO THE ELECTRIC OUTSIDE REARVIEW MIRROR SWITCH. OWNER NOTIFICATION BEGAN ON APRIL 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
01V200000 · Suspension:front:control Arm:upper Ball Joint
Jun 28, 2001
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.