IllustrationTHE HEADLIGHTS HAVE NEVER BEEN GOOD, CAN'T SEE. AIR CONDITIONER COMPRESSOR LEAKED OUT REFRIGERANT, INDEPENDENT GARAGE WANTS $ 1000.00 TO FIX PROPERLY..... ANTI LOCK BRAKE MODULE WENT OUT, INDEPENDENT GARAGE WANTS $ 1000.00 TO FIX.*AK
1996 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1996 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 105 of 1,153 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 420 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
156 crash reports31 fire reports77 injury reports
Service Brakes, Hydraulic complaints
420 reportsTHE CONSUMER STATES THAT HE SUFFERED LOSS OF BRAKING AFTER THE ABS WAS FIXED ON RECALL DUE TO THE DEALER USING DEFECTIVE PARTS. EVERY LIGHT ON THE VEHICLE WENT OUT WHILE THE CONSUMER WAS DRIVING, CONSUMER BELIEVES THE SERVICE DEPARTMENT IMPROPERLY INSTALLED THE WIRES WHILE PERFORMING THE RECALL. *YH
WHILE DRIVING, VEHICLE VEERS TO THE LEFT, AS IF OUT OF ALIGNMENT. UPON PUTTING FOOT ON BRAKES TO SLOW DOWN, VEHICLE DID NOT STOP. CONSUMER HAD AN ACCIDENT, THERE WERE TWO INJURIES. *AK CONSUMER STATES REAR AXLE SEAL IS LEAKY, WHEN STOPPING VEHICLE OR SLOWING, THE BRAKE PEDAL GIVES WAY, AIR BAG FAILED. *YD
WHILE DRIVING THE VEHICLE AND APPLYING THE BRAKES THE VEHICLE STARTED SHAKING OUT OF CONTROL. NLM
THE ABS BRAKE SYSTEM HAD FAILED WITHOUT ANY WARNINIG OR INDECATION, I HAD MY MECHANIC CHECK THE SYSTEM OUT AND HE FOUN THA THE ABS PUMP WAS MALFUNCTIONING. BUT IT DID NOT PRODUCE A FAULT CODE TO THE COMPUTER NOR DID THE DASH LIGHT COME ON. HE ALSO CHECKED WITH OTHER MECKANIC IN THE AREA AND THEY ALSO HAVE HAD THE SAME REPORTS FR…
Read full complaint
THE ABS BRAKE SYSTEM HAD FAILED WITHOUT ANY WARNINIG OR INDECATION, I HAD MY MECHANIC CHECK THE SYSTEM OUT AND HE FOUN THA THE ABS PUMP WAS MALFUNCTIONING. BUT IT DID NOT PRODUCE A FAULT CODE TO THE COMPUTER NOR DID THE DASH LIGHT COME ON. HE ALSO CHECKED WITH OTHER MECKANIC IN THE AREA AND THEY ALSO HAVE HAD THE SAME REPORTS FROM THEIR CUSTOMERS ABOUT THE BRAKES FAILING. THE QUICK FIX IS TO DISABLE THE ABS SYSTEM AND RUN THE BRAKES IN THE MANUAL MODE. THERE SEEMS TO BE A PROBLEM WITH (96-97 ) SYSTEMS. THE REPAIR COST FOR ABS RANGE FROM 900.00 TO 1500.00 DOLLLARS TO FIX. AT THAT PRICE THERE PROBABLY A LOT OF PEOPLE RIDING AROUNRD WITH THE ABS SYSTEM DESABLED. I THINK THIS SHOULD HAVE A TOP PRIORITY TO BE CHECKED OUT. HAD I NEEDED THE BRAKES IN A REAL EMERGENCY OR PANIC STOP I DON'T THINK I WOULD BE WRITING THIS LETTER. THANK YOU FOR YOR TIME IN THIS MATTER JOHN T NUTTALL 24 B STREET LOWELL,MA. 01851. *AK
WHILE TRAVELING ON THE HIGHWAY VEHICLE ACCELERATED WITHOUT PRIOR WARNING, DEALERSHIP IS AWARE OF THE PROBLEM.*AK. CONSUMER STATED WHEN SHE TOOK HER FOOT OFF THE ACCELERATOR TO SLOW THE VEHICLE DOWN, THE VEHICLE STAYED AT THE SAME SPEED, CONSUMER TRIED DOWNSHIFTING AND PUMPING THE BRAKES, SHE HAD TO SLAM ON THE BRAKES AND USE …
Read full complaint
WHILE TRAVELING ON THE HIGHWAY VEHICLE ACCELERATED WITHOUT PRIOR WARNING, DEALERSHIP IS AWARE OF THE PROBLEM.*AK. CONSUMER STATED WHEN SHE TOOK HER FOOT OFF THE ACCELERATOR TO SLOW THE VEHICLE DOWN, THE VEHICLE STAYED AT THE SAME SPEED, CONSUMER TRIED DOWNSHIFTING AND PUMPING THE BRAKES, SHE HAD TO SLAM ON THE BRAKES AND USE THE EMERGENCY BRAKE TO SLOW THE VEHICLE DOWN ENOUGH TO GET OFF OF THE FREEWAY, CONSUMER STATED THE DEALER REPLACED THE ACCELERATOR CABLE, BRAKES, SHOES, CALIPERS AND ROTORS.*JB
MANY PROBLEMS ARE CONTINUING. CURRENTLY, THE FRONT SUSPENSION NEEDS REPAIRED, THE BRAKES WERE REPLACED AT 18000 AND ARE NOW GONE AGAIN, THE REAR SEALS ARE LEAKING DAMAGING THE REAR BRAKES, THE DRIVE LIGHTS STILL FLASH INTERMITTENTLY, A SMELL OF GASOLINE IS IN THE VEHICLE AFTER REFUELING, THE ENGINE PINGS NO MATTER WHAT FUEL IS …
Read full complaint
MANY PROBLEMS ARE CONTINUING. CURRENTLY, THE FRONT SUSPENSION NEEDS REPAIRED, THE BRAKES WERE REPLACED AT 18000 AND ARE NOW GONE AGAIN, THE REAR SEALS ARE LEAKING DAMAGING THE REAR BRAKES, THE DRIVE LIGHTS STILL FLASH INTERMITTENTLY, A SMELL OF GASOLINE IS IN THE VEHICLE AFTER REFUELING, THE ENGINE PINGS NO MATTER WHAT FUEL IS USED. NOTHING THE DEALER HAS DONE HAS SOLVED THE MULTITUDE OF PROBLEMS. SEAT BELT PROBLEMS ON PASSENGER SIDE, INTERIOR TRIM FELL OFF, ON AND ON.
ABS LIGHT WAS ILLUMINATED WHEN VEHICLE WAS TAKEN TO THE DEALERSHIP FOR SERVICE OF RECALL CAMPAIGN 99V193000. WHEN CONSUMER TOOK POSSESSION OF VEHICLE ABS LIGHT WAS STILL ILLUMINATED ON INSTRUMENT PANEL. DEALERSHIP INFORMED CONSUMER NOT TO WORRY ABOUT THE LIGHT. WHEN BRAKES WERE APPLIED THE PEDAL WAS NORMAL; HOWEVER THER…
Read full complaint
ABS LIGHT WAS ILLUMINATED WHEN VEHICLE WAS TAKEN TO THE DEALERSHIP FOR SERVICE OF RECALL CAMPAIGN 99V193000. WHEN CONSUMER TOOK POSSESSION OF VEHICLE ABS LIGHT WAS STILL ILLUMINATED ON INSTRUMENT PANEL. DEALERSHIP INFORMED CONSUMER NOT TO WORRY ABOUT THE LIGHT. WHEN BRAKES WERE APPLIED THE PEDAL WAS NORMAL; HOWEVER THERE WAS EXTENDED STOPPING DISTANCE WHICH RESULTED IN A COLLISION. VEHICLE IS AT DEALERSHIP. PLEASE PROVIDE FURTHER INFORMATIONDDITIONAL INFORMATION / DOCUMENTATION. *AK
VEHICLE EXPERIENCED SEVERAL BRAKE PROBLEMS, CONSUMER HAS TAKEN VEHICLE TO DEALER ON 8 OCCASIONS TO HAVE BRAKES REPAIRED, HOWEVER CONSUMER WAS IN 2 SEPARATE ACCIDENTS DUE TO ABS FAILURE, ONE AT 35MPH AND THE OTHER AT 60MPH, THERE WERE NO INJURIES. *YH
WHEN APPLYING BRAKES IN A PANIC STOP PEDAL WENT TO THE FLOOR, CAUSING EXTENDED STOPPING DISTANCE, AND RESULTING IN A COLLISION. PLEASE PROVIDE FURTHER DETAILS IF NEEDED. *AK
Official recalls
603V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V200000 · Suspension:front:control Arm:upper Ball Joint
Jun 28, 2001
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA99022 · Upper And Lower Control Arm Ball Joint
Opened Jul 30, 1999 · Closed Aug 28, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99021 · Upper Control Arm Ball Joint Breakage
Opened Mar 5, 1999 · Closed Jul 30, 1999
Status: closed (inferred from source dates) · Power Train
AN UPPER CONTROL ARM BALL JOINT FAILS, RESULTING IN THE FRONT SUSPENSION COLLAPSING ON THE FAILED SIDE.
EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.