IllustrationTHE VEHICLE IS EQUIPPED WITH ABS. ON MULTIPLE OCCASIONS, WHEN I ATTEMPTED TO STOP THE VEHICLE THE WHEELS LOCKED AND THE VEHICLE WENT INTO A SKID. THE SKID (SLID) IS A SAFETY ISSUE SINCE IT CAUSES A REDUCTION IN STEERING CONTROL WHICH COULD RESULT IN AN ACCIDENT. *TT
1996 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1996 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 105 of 1,153 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 420 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 182 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
156 crash reports31 fire reports77 injury reports
Service Brakes, Hydraulic complaints
420 reportsI OWN A 1996 CHEVROLET BLAZER WHICH I PURCHASED NEW IN 1996. IT NOW HAS 59,000 MILES ON IT. WE HAVE REGULARLY SCHEDULED MAINTENANCE DONE ON THE CAR, ALONG WITH SCHEDULED OIL CHANGES, CHECKING BELTS, HOSES, ETC. WE ARE CONSTANTLY HAVING OUR BRAKES REPAIRED/REPLACED. LAST YEAR WE NEEDED TO HAVE A BRAKE BOOSTER REPLACED WHICH CO…
Read full complaint
I OWN A 1996 CHEVROLET BLAZER WHICH I PURCHASED NEW IN 1996. IT NOW HAS 59,000 MILES ON IT. WE HAVE REGULARLY SCHEDULED MAINTENANCE DONE ON THE CAR, ALONG WITH SCHEDULED OIL CHANGES, CHECKING BELTS, HOSES, ETC. WE ARE CONSTANTLY HAVING OUR BRAKES REPAIRED/REPLACED. LAST YEAR WE NEEDED TO HAVE A BRAKE BOOSTER REPLACED WHICH COST US OVER $700 AND TODAY WE WERE TOLD THAT OUR "ENTIRE" COOLING SYSTEM IS CORRODED...$1,900. AT 59,000 MILES I CERTAINLY DON'T THINK THIS SHOULD HAVE HAPPENED. *NLM
WINDSHIELD WIPERS FRONT & REAR FAILED, WATER PUMP QUIT, DRIVE SHAFT BROKE, BALL JOINTS RIGHT FRONT BROKE, HEATER QUIT, AIR CONDITIONER QUIT. DRIVERS SIDE REAR VIEW MIRROR FELL OFF, STEERING PROBLEMS, BRAKE PROBLEMS, UNIVERSAL JOINTS WORN OUT, CRACKED FRONT ROTORS,ETC. *JB
1. ANTI-LOCK BRAKE CONTROLLER BAD 2. AIR CONDITIONER COMPRESSOR LEAKS OUT ALL REFRIGERANT 3. HEAD LIGHTS ARE SO BAD, YOU CAN NOT SEE THE ROAD HARDLY AT ALL. *JB
CONSUMER STATES THAT WHEN APPLYING THE ANTI LOCK BRAKES THEY CAN HEAR A LOUD NOISE AND THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED. TS
THE BRAKES HAVE BEEN CHECKED SEVERAL TIMES FOR THIS PROBLEM AND I WAS TOLD THAT THERE WAS NOTHING WRONG, BUT IT HAS CAUSED 1 ACCIDENT IN WICH I WAS CITED AND NEARLY CAUSED 4 OTHER ACCIDENTS. THE BRAKES HAVE FAILED AT LEAST 5 OTHER TIMES IN CONDITIONS THAT NORMAL BRAKES WOULDN'T HAVE HAD A PROBLEM. DT
CONSUMER STATES BALL JOINTS ARE CONSTANTLY FAILING. CONSUMER HAS HAD TO REPLACE THEM TWICE. A RECALL WAS INITIATED, BUT CONSUMER'S VIN WAS NOT INCLUDED. RELATED RECALLS 01V200000 AND 01I018000. *AK RIGHT FRONT WHEEL FELL OFF AS A RESULT OF THE FAULTY BALL JOINTS. THERE WAS SQUEAKING NOISE ON TURNS DUE TO IDLER ARM FAILURE. FRO…
Read full complaint
CONSUMER STATES BALL JOINTS ARE CONSTANTLY FAILING. CONSUMER HAS HAD TO REPLACE THEM TWICE. A RECALL WAS INITIATED, BUT CONSUMER'S VIN WAS NOT INCLUDED. RELATED RECALLS 01V200000 AND 01I018000. *AK RIGHT FRONT WHEEL FELL OFF AS A RESULT OF THE FAULTY BALL JOINTS. THERE WAS SQUEAKING NOISE ON TURNS DUE TO IDLER ARM FAILURE. FRONT PADS WORN OUT AND ROTORS FAILED, BOTH WERE REPLACED. *YH
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHILE APPLYING BRAKES AT LOW SPEED, INTERMITTENTLY BRAKE PRESSURE CAUSED PEDAL TO HARDEN. MORE PRESSURE NEEDED TO BE APPLIED ON BRAKE PEDAL TO GET VEHICLE TO STOP. DEALER WAS NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AKI
WHILE DRIVING AT 5-10 MPH CONSUMER TRIED TO SLOW DOWN, AND WHEN APPLYING BRAKES VEHICLE MADE A BUZZING NOISE,AND DID NOT STOP. VEHICLE RAN INTO ANOTHER VEHICLE. *AKCONSUMER EXPLAINS THAT THERE WAS PLENTY OF ROOM FOR THE VEHICLE TO COME TO A COMPLETE STOP BUT BECAUSE OF THE DEFECT WITH THE BRAKES, CONSUMER HIT THE VEHICLE IN F…
Read full complaint
WHILE DRIVING AT 5-10 MPH CONSUMER TRIED TO SLOW DOWN, AND WHEN APPLYING BRAKES VEHICLE MADE A BUZZING NOISE,AND DID NOT STOP. VEHICLE RAN INTO ANOTHER VEHICLE. *AKCONSUMER EXPLAINS THAT THERE WAS PLENTY OF ROOM FOR THE VEHICLE TO COME TO A COMPLETE STOP BUT BECAUSE OF THE DEFECT WITH THE BRAKES, CONSUMER HIT THE VEHICLE IN FRONT. IT WAS AS IF VEHICLE WAS OPERATING ON ICE. CONSUMER IS CONVINCED THAT THIS IS A PROBLEM STRAIGHT FROM THE FACTORY. *JG
Official recalls
603V159000 · Visibility:windshield Wiper/washer
Apr 28, 2003
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
01V200000 · Suspension:front:control Arm:upper Ball Joint
Jun 28, 2001
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
99V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
97V096001 · Seat Belts
Jun 12, 1997
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA99022 · Upper And Lower Control Arm Ball Joint
Opened Jul 30, 1999 · Closed Aug 28, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99021 · Upper Control Arm Ball Joint Breakage
Opened Mar 5, 1999 · Closed Jul 30, 1999
Status: closed (inferred from source dates) · Power Train
AN UPPER CONTROL ARM BALL JOINT FAILS, RESULTING IN THE FRONT SUSPENSION COLLAPSING ON THE FAILED SIDE.
EA97007 · Steering Shaft Separations
Opened Apr 17, 1997 · Closed Mar 12, 1998
Status: closed (inferred from source dates) · Steering
COUPLING BOLTS, JOINING THE STEERING SHAFT, MAY SEPARATE.IN SOME CASES, TOTAL UNFORESEEN, LOSS OF STEERING CONTROL MAY RESULT.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.