IllustrationCAR STALLED NUMEROUS TIMES AT ANY SPEED. INDEPENDENT SHOP STATED THAT VEHICLE STALLED DUE TO A FAULTY EGR VALVE. DEALER NOTIFIED. *AK
1995 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1995 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 64 of 1,224 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 513 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports25 fire reports63 injury reports
What owners actually said
1,224 reportsWHILE PULLING INTO A PARKING LOT ANOTHER DRIVER NOTICED GAS POURING FROM REAR OF CONSUMER'S VEHICLE. *AK
AIR CONDITIONING EVAP. CASE DISINTEGRATING IN ENGINE COMPARTMENT ALLOWING / PULLING ENGINE GASES / FUMES INTO PASSENGER COMPARTMENT. *JB
OCCASIONAL SMELL OF GASOLINE WITHIN THE PASSENGER COMPARTMENT AREA, USUALLY WHEN MAX A/C IS ENGAGED. SMELL GOES AWAY PRIOR TO HAVING CHECKED BY DEALER. DEALER ADVISE THAT IT CAN'T BE CHECKED IF IT DOESN'T SMELL WHEN BROUGHT TO DEALERSHIP. OCCURS SEVERAL TIMES A YEAR SINCE PURCHASE. *JB
WHILE TRAVELING AT 45 MPH DOWN HILL, THE CONSUMER MADE A SUDDEN STOP AND THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE. THE CONSUMER APPLIED THE BRAKES WITH BOTH FEET ON THE FLOOR BOARD, HOWEVER THE VEHICLE DID NOT STOP AND SUBSEQUENTLY CRASHED. *AK *SCC *JB
VEHICLE OIL LINE EXPLODED. *MR WHILE DRIVING DOWN THE HIGHWAY, THE ENGINE LIGHT CAME ON. THE CONSUMER LIFTED THE HOOD AND VIEWED OIL EVERYWHERE. THE SERVICE DEALER STATED THAT THE OIL LINE EXPLODED. THE OIL LINE FROM THE OIL FILTER MOUNTED OFF THE ENGINE IN THE FRONT OF THE VEHICLE. *SCC *JB
CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING, THE EGR VALVE FAILED, WHICH CAUSED THE BRAKES TO FAIL. DEALER NOTIFIED. *AK THE MIXING WITH THE FUEL WAS THE BIGGEST PROBLEM. (WHEN THERE WAS CARBON BUILD UP IN THE EGR VALVE, IT WOULD LEAVE IT OPEN AND CAUSED NO VACUUM HARD PEDAL AND BRAKE FAILURE. WHEN IT RAINED OR…
Read full complaint
CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING, THE EGR VALVE FAILED, WHICH CAUSED THE BRAKES TO FAIL. DEALER NOTIFIED. *AK THE MIXING WITH THE FUEL WAS THE BIGGEST PROBLEM. (WHEN THERE WAS CARBON BUILD UP IN THE EGR VALVE, IT WOULD LEAVE IT OPEN AND CAUSED NO VACUUM HARD PEDAL AND BRAKE FAILURE. WHEN IT RAINED OR WAS COLD THE TRUCK RAN ROUGH. THE SERVICE LIGHT CAME ON WHEN THE VEHICLE HAD RUN ROUGH MORE THAN ONCE, NOISE WAS PRESENT AND THERE WAS A SMELL OF BURNT WIRES AND THE IGNITION SWITCH WAS REPLACED, THE BRAKE PEDAL SEEMED SOFT ON MORE THAN ONE OCCASION AND THE MASTER CYLINDER AND OTHER BRAKE COMPONENTS WERE REPLACED TO TRY AND SOLVE THE PROBLEM, THE CD PLAYER HAD NOT WORKED SINCE THE IGNITION SWITCH WAS CHANGED, THE REAR WINDSHIELD WIPERS HAD BECOME INOPERATIVE, A NOISE WOULD OCCUR WHEN TURNING BUT WAS NOT DUPLICATED, AND THE MUFFLER TAIL PIPE HAD FALLEN OFF AND RUSTED DUE TO CARBON BUILD-UP. THE EGR VALVE WAS CLEANED BUT THE PROBLEM PERSISTED. THE MECHANIC STATED THAT IN ORDER TO PERFORM A PROPER JOB, THE EXCESSIVE CARBON BUILD UP IN THE UPPER AND LOWER INTAKE MANIFOLD WHICH EFFECTED THE EGR PENDEL, AND THE 02 SENSOR COULD CAUSE A PROBLEM WITH THE EXHAUST SYSTEM, CATALYTIC CONVERTER, FUEL PUMP, THE BRAKES, ETC. THE BRAKES SQUEAKED, THERE WERE NO DASH LIGHTS, NO AIR CONDITIONING, AND NO 4-WHEEL DRIVE. THE FUEL INJECTIONS NEEDED TO BE CHECKED, AND THERE WERE TWO RECALL STICKERS ON THE ENGINE. *SCC THE REAR WIPER MOTOR, FUEL INJECTORS AND BRAKES WERE REPLACED. *JB
MY BRAKES WOULDN'T WORK AND I WAS SPEEDING ON THE ROAD. MY ALTENATOR "WENT OUT". THE EXACT INCIDENT I HAD HAPPENED WITH A FRIEND'S FRIEND A COUPLE OF DAYS AGO. HE ALSO DRIVES A BLAZER.*AK
EGR VALVE & OXYGEN SENSORS PROBLEM THE ABOVE MENTIONED ITEMS HAVE BEEN IDENTIFIED AS A PROBLEM WITH THESE VEHICLES BY DEALER & PRIVATE MECHANICS. A SERVICE BULLETIN WAS SENT OUT IN 1997 WITH A SUMMARY THAT PROVIDES IF NOTHING ELSE A TEMPORARY FIX. I HAVE SPENT SEVERAL HUNDRED DOLLARS FIXING THIS PROBLEM OVER THE LAST 5 YEARS …
Read full complaint
EGR VALVE & OXYGEN SENSORS PROBLEM THE ABOVE MENTIONED ITEMS HAVE BEEN IDENTIFIED AS A PROBLEM WITH THESE VEHICLES BY DEALER & PRIVATE MECHANICS. A SERVICE BULLETIN WAS SENT OUT IN 1997 WITH A SUMMARY THAT PROVIDES IF NOTHING ELSE A TEMPORARY FIX. I HAVE SPENT SEVERAL HUNDRED DOLLARS FIXING THIS PROBLEM OVER THE LAST 5 YEARS AND WOULD LIKE TO HAVE SOME TYPE OF REIMBURSEMENT, PREFERABLY A RECALL TO HAVE IT FIXED PERMANENTLY. I HAVE VIEWED OTHERS COMMENTS ON THIS VEHICLE AND IT IS AN OVERALL PROBLEM. SEEMS LIKE THE MANUFACTURER IS NOT TAKING ANY RESPONSIBILITY. SINCE YOUR QUESTIONS BELOW DO NOT PRVIDE ROOM FOR EXPLANATION IN THE CRASH COLUMN, I WOULD LIKE TO REMIND EVERYONE THAT WHEN THESE VALVES GET CLOGGED UP THE VEHICLE LITERALLY SEIZES. JUST STOPS, NICE THOUGHT! MY PERSONAL MECHANIC HAS RECOMMENDED THAT WHEN THE VEHICLE STARTS CLUGGING (AS IT WILL), PRIOR TO SEIZING UP & JUST STOPPING IN THE MIDDLE OF THE ROAD, (AS IT HAS ALREADY DONE), BRING IT IN, (WE WILL CLEAN IT OUT). WHO'S FAULT WILL AN ACCIDENT BE? THAT REPAIR COULD BE TO THE TUNE OF $100.00 DEPENDING ON IF ANYTHING ELSE WAS AFFECTED BY THIS. THIS PROBLEM HAS BEEN IDENTIFIED, AND STILL NOTHING IS DONE ABOUT IT. CURRENTLY WE ARE A TWO CAR FAMILY WITH 2 TEENAGERS IN THE MARKET. CHEVROLET DEALERS WILL NOT BE ON MY LIST TO VISIT. FOR THIS PROBLEM YOU WOULD NEED A REACURRING INCIDENT DATE.*AK
EGR VALVE, FUEL INJECTION SYSTEM,CPI INJECTOR, FREEZE PLUGS. *AK
Official recalls
699V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
95V180000 · Engine And Engine Cooling:cooling System:fan
Sep 22, 1995
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
95V080000 · Suspension:front:control Arm:upper Ball Joint
Apr 24, 1995
THE UPPER BALL JOINT NUTS WERE UNDER-TORQUED RESULTING IN IMPROPER SEATING IN THE STEERING KNUCKLE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BALL JOINT STUD TO LOOSEN, AND FRACTURE RESULTING IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER BALL JOINT NUT ON BOTH SIDES OF THE VEHICLE TO THE CORRECT TORQUE VALUES.
94V242000 · Service Brakes, Hydraulic:pedals And Linkages
Dec 12, 1994
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.