IllustrationLEFT LOWER BALL JOINT RIPPED THROUGH CONTROL ARM. ALSO ON MAY 16TH, 2001, RIGHT BALL JOINT RIPPED THROUGH LOWER CONTROL ARM. DEALERSHIP HAS NOT DETERMINED CAUSE OF THIS DEFECT. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK
1995 Chevrolet Blazer
Owner reports · Recalls · Investigations
More warning signs than most Blazer years
Owner complaints for the 1995 Chevrolet Blazer are substantially higher than the model-year median of 32.
About this comparison →How this year compares
Owner complaints by model year
Compare all Blazer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 64 of 1,224 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 513 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 213 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports25 fire reports63 injury reports
Suspension complaints
35 reportsPULLING INTO A PARKING LOT, RIGHT BALL JOINT BROKE. ALSO, WHEN LEAVING A PARKING LOT, FUEL INJECTOR FAILED, CAUSING HYDRAULIC BRAKES ARE TERRIBLE.*AK
THE UPPER BALL JOINT FAILED WHILE I WAS TURNING IN TO MY DRIVEWAY. THE FRONT WHEEL THEN FOLDED UNDER MAKING IT IMPOSSIBLE TO DRIVE. IF I HAD BEEN TRAVELING ON AN INTERSTATE, SURELY I WOULD HAVE LOST CONTROL AND POSSIBLY WOULD HAVE "ROLLED" THE VEHICLE SEVERAL TIMES. THIS PROBLEM WAS IDENTIFIED UNDER A NHTSA CAMPAIGN ID #95V08…
Read full complaint
THE UPPER BALL JOINT FAILED WHILE I WAS TURNING IN TO MY DRIVEWAY. THE FRONT WHEEL THEN FOLDED UNDER MAKING IT IMPOSSIBLE TO DRIVE. IF I HAD BEEN TRAVELING ON AN INTERSTATE, SURELY I WOULD HAVE LOST CONTROL AND POSSIBLY WOULD HAVE "ROLLED" THE VEHICLE SEVERAL TIMES. THIS PROBLEM WAS IDENTIFIED UNDER A NHTSA CAMPAIGN ID #95V080000. WHEN I CALLED THE CHEVROLET HOTLINE (1 800 222 1020) I WAS TOLD THAT MY VIN WAS NOT COVERED BY THIS RECALL. I WAS GIVEN A REQUEST #C02430111. I BELIEVE THIS RECALL SHOULD BE EXPANDED TO COVER ALL BLAZERS, ESPECIALLY SINCE MY REPAIR BILL FOR THIS IS ALMOST THE SAME WORDING AS WAS USED IN THE CAMPAIGN NUMBER PREVIOUSLY MENTIONED. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NO SUMMARY LISTED FOR ABOV EVEHICLE. *AK
BRAKE LININGS HAD TO BE REPLACED AT 30,000 MILES AND JUST ABOUT EVERY 30,000 MILES AFTER THAT. THE REAR END WENT OUT AT ABOUT 72,000 MILES AND HAD TO BE REPLACED AT A COST OF ABOUT $1800. WE WERE ON A TRIP FROM KENTUCKY TO ALABAMA ON JUNE 23,2000, AND THE POWER BRAKE BOOSTER WENT OUT. WE WERE FORCED TO TRAVEL WITH BRAKES THAT…
Read full complaint
BRAKE LININGS HAD TO BE REPLACED AT 30,000 MILES AND JUST ABOUT EVERY 30,000 MILES AFTER THAT. THE REAR END WENT OUT AT ABOUT 72,000 MILES AND HAD TO BE REPLACED AT A COST OF ABOUT $1800. WE WERE ON A TRIP FROM KENTUCKY TO ALABAMA ON JUNE 23,2000, AND THE POWER BRAKE BOOSTER WENT OUT. WE WERE FORCED TO TRAVEL WITH BRAKES THAT SOUNDED LIKE THERE WAS A HORRIBLE AIR LEAK EVERY TIME YOU APPLIED THEM, AND THE PEDAL WENT TO THE FLOOR. THE ABS LIGHT HAD COME ON IN JUNE, 1999, BUT WE HAD RECENTLY PAID $1800 FOR REPLACEMENT OF THE REAR END, AND WERE TOLD THAT OUR REGULAR BRAKES WOULD DO FINE, SO WE WAITED. WHEN WE HEARD THAT A RECALL HAD BEEN CALLED ON THAT ABS SYSTEM WE CALLED THE DEALER NUMEROUS TIMES, BUT THEY ALWAYS SAID THAT THEY HADN'T RECEIVED ANY INFORMATION FROM GM ABOUT IT YET. WE FINALLY GOT A RECALL NOTICE IN THE MAIL ABOUT 2 WEEKS AGO, ALMOST A YEAR AFTER IT WAS ANNOUNCED. WHEN THE REAR END WENT OUT, WE HAD BEEN HEARING A STRANGE RUMBLING NOISE THAT GOT PROGRESSIVELY LOUDER. WE TOOK THE CAR TO SEVERRAL LOCAL MECHANICS, BUT THEY COULDN'T FIND ANYTHING WRONG. AFTER A FEW WEEKS WE TOOK IT TO THE DEALER AND THEY HAD TO REPLACE THE WHOLE REAR END. NOW IT IS BEGINNING TO MAKE THE SAME SOUND, AND THEY WILL CHECK THAT TOMORROW. THEY TOOK MY CAR TODAY TO CHECK THE BRAKES AND SAID THAT THE POWER BRAKE BOOSTER WAS BAD AND THE MASTER CYLINDER WAS BAD. THAT ALONE WILL COST OVER $700. THEY SAID THAT THE WHOLE ABS MODULE WAS BAD, AND IF WE WANT THAT FIXED IT WILL BE ABOUT $1000 DOLLARS MORE. IF THEY DECIDE THAT THE REAR END IS BAD AGAIN, THAT WILL ADD ANOTHER $1800 DOLLARS AGAIN, I GUESS. THIS VEHICLE HAS BEEN DRIVEN MAINLY BY ME AND MY HUSBAND (51 & 52 YRS OLD)-- AROUND TOWN AND ON THE HIGHWAY TO VISIT OUR KIDS AND PICK UP GRANDKIDS. IT HAS NOT BEEN MISUSED, AND HAS HAD ALL MAINTENANCE WORK DONE. *AK
FRONT END BECAME DETACHED FROM THE REAR END. THERE WAS NO WARNING ABOUT THIS PROBLEM. *AK
POSSIBLE DESIGN DEFECT IN THE FUEL PUMP/CENTRAL PORT INJECTOR, FAILED ON TWO OCCASIONS DUE TO SAME DEFECT. *MJS ALSO, FUEL LEVEEL VARIES FROM EMPTY TO FULLWHEN DRIVING VEHICLE. *AK
ENGINE IDLES ON IT'S OWN. NLM
CONSUMER WAS DRIVING AND HE FELT VIBRATION INSIDE OF THE CAR. THE DRIVER'S SIDE REAR WHEEL WAS PASSING ALONG THE ROAD DUE TO LUGS: NUTS BEING DEFECTIVE. DEALER REFUSED TO REIMBURSE FOR REPAIRS BECAUSE VEHICLE OUT OF WARRANTY. *AK. *ML
Official recalls
699V193000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jul 19, 1999
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
98V150001 · Visibility:windshield Wiper/washer
Jul 1, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
96V234000 · Fuel System, Gasoline:storage:tank Assembly
Nov 14, 1996
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
95V180000 · Engine And Engine Cooling:cooling System:fan
Sep 22, 1995
FAN BLADE RIVET BREAKAGE CAN OCCUR CAUSING THE FAN BLADE TO SEPARATE FROM THE SPIDER.
Consequence & remedy
Consequence: IF THIS OCCURRED WHILE THE HOOD WAS OPEN, A PERSON WORKING UNDER THE HOOD OF THE VEHICLE OR IN THE VICINITY OF THE VEHICLE COULD BE STRUCK BY THE FAN BLADE AND INJURED.
Remedy: DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE FAN WITH A NEWER FAN HAVING THICKER-HEADED RIVETS.
95V080000 · Suspension:front:control Arm:upper Ball Joint
Apr 24, 1995
THE UPPER BALL JOINT NUTS WERE UNDER-TORQUED RESULTING IN IMPROPER SEATING IN THE STEERING KNUCKLE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BALL JOINT STUD TO LOOSEN, AND FRACTURE RESULTING IN A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL RETORQUE THE UPPER BALL JOINT NUT ON BOTH SIDES OF THE VEHICLE TO THE CORRECT TORQUE VALUES.
94V242000 · Service Brakes, Hydraulic:pedals And Linkages
Dec 12, 1994
THE BRAKE PEDAL PIVOT BOLT WAS STARTED IN THE WELD NUT, BUT WAS NOT TORQUED CORRECTLY CAUSING THE BOLT TO DISENGAGE FROM THE WELD NUT.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN A TOTAL LOSS OF BRAKINGCAPABILITY.
Remedy: DEALERS WILL INSPECT FOR HAND-STARTED BRAKE PEDAL BOLTS AND TORQUE THEM TO CORRECT SPECIFICATIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA01019 · Front Seat Recliner Bolt
Opened Dec 28, 2001 · Closed Sep 27, 2002
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
EA00008 · Loss Of Power Assist
Opened Mar 16, 2000 · Closed Aug 31, 2001
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
RQ99015 · Front Seat Recliner Bolt Failure
Opened Jul 14, 1999 · Closed Dec 28, 2001
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
No summary supplied.
PE99024 · Loss Of Power Assist Braking
Opened Apr 5, 1999 · Closed Mar 16, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
CONSUMERS ALLEGE A PARTIAL LOSS OF BRAKING ABILITY
EA97022 · Windshield Wiper Failure
Opened Oct 23, 1997 · Closed Jul 2, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
Additional source detail variants (2)
Visibility
There is no summary currently available
Visibility
There is no summary currently available
PE97028 · Windshield Wiper
Opened Jun 17, 1997 · Closed Oct 23, 1997
Status: closed (inferred from source dates) · Visibility
DURING THIS PRELIMINARY EVALUATION, OVER 400 ADDITIONAL COMPLAINTS WERE FURNISHED BY GM.IN ADDITION GM REPORTED OVER 3000 WIPER SYSTEM WARRANTY REPAIRS ON THE SUBJECT VEHICLES.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.